2009 HARLEY-DAVIDSON FLHX Fuelpropulsion System Problems

HUNDREDS OF RIDERS IN FORUMS ONLINE HAVE REPORTED THE SAME ISSUE WHERE THE CONTACT BETWEEN THE MOTORCYCLE'S WIRE PINS GOING INTO THE THROTTLE INDUCTION MODEL ACTUATOR BECOMES DISRUPTED WHILE RIDING. HARLEY-DAVIDSON HAS PROGRAMED THE BIKE TO SHUT DOWN THE RPMS TO NO MORE THAN 2,000 AND SHUTTING DOWN ONE OF THE TWO CYLINDERS. THIS POSES VERY SERIOUS AND IMMEDIATE RISK OF DEATH TO THE RIDER AS THE BIKE SUDDENLY WITHOUT WARNING OR BRAKE LIGHTS DROPS IN SPEED VERY QUICKLY ON A HIGHWAY RESULTING IN POSSIBLY GETTING REAR-ENDED BY A VEHICLE, OR GETTING RUN OVER TRYING TO CROSS LANES OF TRAFFIC, OR GOING SIDEWAYS IF IN THE MIDDLE OF A CURVE; IN THE CASE OF A MOUNTAIN ROAD, THIS COULD MEAN FALLING TO ONE'S DEATH. ALL OF THIS COULD BE PREVENTED BY HD REPLACING THE EXISTING WIRING HARNESS(ES) WITH A SLIGHTLY LONGER ONES SO THE EXTREME ANGLE OF THE WIRE INPUT...

WHEN DRIVING THE BIKE GOES IN TO WHAT THEY CALL LIMO MODE , I HAVE NO THROTTLE AND WON'T GO , IT HAPPENED MANY TIMES PASSING ON HI WAY SPEEDS , LOCAL HD DEALER DON'T SEEM TO HAVE A FIX , I FEEL THIS IS A DANGER AND AFTER DOING SOME LOOKING I SEE THOUSANDS OF CASES LIKE MINE , IT SHOULD BE A RECALL BEFORE SOMEONE DIES ITS VARY DANGERS .

I WAS JUST RIDING DOWN THE I-405 FREEWAY NEAR SEATTLE, WA AT ABOUT 70 MPH IN THE LEFT WITH NO SHOULDER AVAILABLE TO PULL OVER ONTO. THE THROTTLE SUDDENLY FAILED AND I HAD NO POWER. I SLOWED DRAMATICALLY AND WAS NEARLY RUN OVER BY A TRUCK. I PUT ON MY FLASHERS AND MOVED 3 LANES RIGHT TO GET TO THE SHOULDER ON THE RIGHT. TRAFFIC WAS HEAVY AND I WAS FORTUNATE NOT TO BE HIT WHEN I HAD NO THROTTLE CONTROL. I CALLED A FRIEND AND HE CAME ABOUT AN HOUR LATER AND TOWED ME HOME. I FEEL THAT I WAS LUCKY NOT TO HAVE BEEN HURT OR KILLED IN THIS INCIDENT.

WHILE STOPPED AT RED LIGHT, AS THE LIGHT TURNED GREEN, I PROCEEDED TO APPLY THROTTLE WITH NO RESPONSE. LET OUT CLUTCH AND ROLLED NO FASTER THEN 20 MPH WHILE CARS WERE BACKING UP BEHIND ME. AFTER ROLLING AT 20 MPH FOR APPROXIMATELY HUNDRED YARDS, I WAS ABLE TO PULL OVER IN A SAFE LOCATION WITH OUT BEING RUN OVER. *TR

ACCELERATING FROM A STOP UP TO SPEED WHEN LOST THROTTLE RESPONSE, ENGINE WOULD NOT GO ABOVE 1500-2000 RPM. WAS ABLE TO LIMP TO THE SIDE OF THE ROAD. I SHUT BIKE DOWN AND WAITED A MINUTE AND RESTARTED IT. IT STARTED UP AND RAN AS NORMAL. TALKED TO MY LOCAL DEALER AND MADE THEM AWARE OF THE PROBLEM. THEY SEEMED VERY FAMILIAR WITH THIS ISSUE AND SAID TO BRING IT IN AND THEY WOULD GIVE ME A COST TO FIX. THIS SEEMS TO ME TO BE A SEVERE SAFETY ISSUE THAT SHOULD BE ON A MANUFACTURES RECALL. WHAT IF I WERE TRYING TO GET ON THE INTERSTATE AND LOST THE ABILITY TO MERGE . *TR

THE PROBLEM BEGAN AROUND APRIL OF 2012. WHEN I STARTED THE MOTORCYCLE, THERE WAS NO THROTTLE RESPONSE. THE MOTORCYCLE WILL IDLE AT 1000 RPM BUT THE THROTTLE WILL NOT WORK WHEN TWISTED TO ACCELERATE ENGINE. IT REMAINS AT IDLE. IT HAS HAPPENED SEVERAL TIMES AND I HAVE TO DISCONNECT THE BATTERY IN ORDER TO RESET THE ELECTRONIC THROTTLE. SOMETIMES IT WORKS, OTHER TIMES IT DOES NOT. IT ALSO HAPPENED VARIOUS TIMES WHEN MOTORCYCLE WAS IN MOTION AT SPEEDS OF 45 MPH ALMOST CAUSING ME TO GET STRUCK ON HIGHWAY FROM BEHIND BY ANOTHER VEHICLE. MOTORCYCLE HAS ALSO STOPPED WORKING WHILE RIDING CAUSING ME TO HAVE TO PUSH MOTORCYCLE HOME OR ATTEMPT TO REPAIR IT TO NO AVAIL. I BROUGHT MOTORCYCLE IN TO HARLEY DAVIDSON FOR REPAIR AT ADAMIC HARLEY DAVIDSON, JACKSONVILLE FLORIDA. THEY STATED THEY FIXED IT MOTORCYCLE BEGAN TO DO THE SAME THING AFTER APPROXIMATELY 75 MILES, NOW MOTORCYCLE...