2018 HARLEY-DAVIDSON FLHR Power Train Problems

The contact owns a 2018 Harley-Davidson FLHR Road King. The contact stated that upon start of the motorcycle there was an abnormal grinding sound coming from the motorcycle without warning. The contact had taken the motorcycle to a dealer where he was informed that the gears inside of the transmission were breaking apart and that the transmission needed to be replaced. The dealer was able to order a new transmission and replaced the transmission under warranty; however, despite the repair, the failure returned and the contact returned the motorcycle back to the dealer. The contact had attempted to reach the manufacturer on numerous occasions but was unsuccessful after each attempt. The motorcycle had not been repaired and remained in the possession of the dealer. The failure mileage was approximately 6,100.

THIS IS A DESCRIPTION OF THE DRIVABILITY PROBLEMS CAUSED BY THE EXCESSIVE PRIMARY CASE FLUID. WHILE IN MOTION ON A CITY STREET THE MOTORCYCLE WOULD SOMETIMES NOT SHIFT DOWN FROM 3RD-2ND OR FROM 2ND TO 1ST GEARS. THIS CAUSES PROBLEMS WHEN TURNING AND WANTING TO USE ENGINE BREAKING TO SLOW DOWN DURING THE TURN. I COULD NOT USE THE ENGINE BREAKING AND WOULD HAVE TO USE THE BRAKES QUICKLY AS TO NOT CAUSE AN ACCIDENT. ALSO, WHEN SITTING STILL WITH ENGINE RUNNING IN NEUTRAL AT A TRAFFIC LIGHT, THE TRANSMISSION WOULD SOMETIMES NOT SHIFT FROM NEUTRAL TO 1ST GEAR. THE DELAY IN TRYING TO PROCEED CAUSES OTHER MOTORISTS TO ALMOST RUN INTO THE BACK OF MY MOTORCYCLE. THIS WAS MOST DANGEROUS WHEN TRAVELING IN A GROUP OF MOTORCYCLES RIDING CLOSE TOGETHER. ALSO, DURING AN EMERGENCY STOP CONDITION WHEN TRAVELING ON A CITY STREET ABOUT 50 MPH IN 5TH GEAR, IT...

SAME ISSUE WITH 2017-2017 RECALL ON HARLEY CLUTCHES PURCHASED A 2019 ROAD KING BY HARLEY AND THE CLUTCH WILL NOT RELEASE THE GEAR IN 1ST/ BIKE CREEPS FORWARD WHEN CLUTCH HANDLED IS PULLED IN. WONT GO INTO NEUTRAL WITH OUT DOUBLE CLUTCHING THE CLUTCH HANDLE.OUT OF TOWN DEALERSHIP INSPECTED AND FOUND MASTER CYLINDER COVER GASKET SUCKED DOWN AND NOT FLUID. THEY FLUSHED THE CLUTCH SYSTEM AND REFILLED. WORKED FOR TEST DRIVE BUT WHEN I HAD PUT 100 MORE MILES ON THE BIKE ISSUES CAME BACK. THIS BIKE HAD A LITTLE OVER 800 MILES ON IT.