2002 GMC YUKON XL Steeringcolumn Problems

DT*: THE CONTACT STATED IN NOVEMBER WHEN THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR ROUTINE SERVICE, THE DEALERSHIP NOTICED THE REAR ROTORS WERE HITTING THE INSIDE OF THE BACKING PLATES INSIDE THE HUB. ALSO, THE ROTORS WERE RUSTED. THE FRONT END WAS ALSO OBSERVED TO BE SHAKING. THE DEALERSHIP DETERMINED THE SHAKING WAS NORMAL 4X4 CHARACTERISTICS; HOWEVER THE DEALERSHIP INSTALLED A LUBE KIT THAT GOES ON THE STEERING COLUMN UNDERNEATH THE HOOD. THE SHAKING RETURNED AND THE DEALERSHIP INFORMED THE CONTACT THE LUBE KIT WAS NO LONGER A REMEDY FOR THIS SHAKING PROBLEM. THERE WAS NOT ANOTHER REMEDY OFFERED.

ON 07/14/03 AT 22602 MILES, WE TOOK OUR 2002 YUKON XL (REGENCY EDITION) TO SUSS PONTIAC IN DENVER, COLORADO, TO INVESTIGATE A CLUNKING/KNOCKING SOUND COMING FROM THE SUSPENSION WHEN TURNING WHICH CAUSED THE STEERING WHEEL TO VIBRATE. ON OCCASION, THE STEERING WHEEL HAD EXCESSIVE PLAY IN THE WHEEL AND WOULD HESITATE WHEN TURNING. SUSS PONTIAC VERIFIED THE COMPLAINT AND FOUND THE "INTERMEDIATE STEERING SHAFT" DRY AND CLUNKING. THE SHAFT WAS THEN LUBED AS PER BULLETIN #II-00-02-35-003B AND WE WERE TOLD AT THE TIME THAT THE PROBLEM SHOULD NOT REOCCUR. THE PROBLEM RECURRED DURING THE FALL OF 2005 WHILE VACATIONING IN TEXAS. AFTER DISCUSSING THE INCIDENT OVER THE PHONE WE WERE TOLD THAT IT WAS NOT A SAFETY CONCERN, MORE OF AN IRRITATION TO THOSE INSIDE THE VEHICLE AND WE SHOULD HAVE NO PROBLEM GETTING HOME. WE MADE IT BACK TO DENVER WITHOUT INCIDENT, BUT VERY ANNOYING. ON 10/25/05, THE VEHICLE...

WE ARE NOW REPLACING THE BUSHING IN THE STEERING COLUMN FOR THE SECOND TIME WITH LESS THAN 42,000 MILES. THIS COMPONENT WAS REPLACED ORIGINALLY AT 28,000 MILES AND HAS FAILED AGAIN. WITH THIS FAILURE HAS CAUSED LEFT WHEEL BEARING TO GO OUT. AT 58,000 MILE THE RIGHT WHEEL BEARING IS NOW IN NEED OF REPAIR, SHOULD HAVE GOTTEN THE EXTENDED WARRANTY, NONE OF THIS IS COVERED AFTER 36,000 MILES. ALSO, THE REAR AIR WILL EITHER BLOW COLD UNTIL THE THERMASTAT IS CHANGE TO THE RED SETTING COMPLETELY. WHEN TAKEN IN WITH THE INITIAL FAILURE OF THE STEERING COLUMN, I WAS TOLD THAT THE SETTING WORKED FINE BUT WOULD BE NOTED INCASE OF LATER FAILURE SO IT MIGHT BE COVERED UNDER WARRANTY.*AK