2009 GMC W4500 — Problems, Recalls & Safety Data
N/A
Safety Rating
0
Owner Complaints
3
Recalls
1
Service Bulletin
0
Investigations
Overview of the 2009 GMC W4500
The 2009 GMC W4500 has received a total of 0 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 3 recall campaigns affecting this vehicle, covering issues with VEHICLE SPEED CONTROL:ACCELERATOR PEDAL, EQUIPMENT:APPLIANCE:AIR CONDITIONER, POWER TRAIN:DRIVELINE:DRIVESHAFT. 1 technical service bulletin have been issued by ISUZU MANUFACTURING SERVICES OF AMERICA for this model year.
Recalls for the 2009 GMC W4500
NHTSA has recorded 3 recalls for the 2009 GMC W4500, potentially affecting up to 17,696 vehicles.
Recall 17V324000 — VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
| 14,807 vehicles affected
Defect: Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain model year 2008-2009 and 2012-2013 Isuzu NPR and NPR HD vehicles and 2008-2009 GMC W3500 and GMC W4500 vehicles. The affected vehicles, equipped with a gasoline-powered engine, have a throttle pedal that may get stuck under the steel stopper bolt, causing the pedal to remain in the full throttle position.
Consequence: A stuck open accelerator pedal may result in very high vehicle speeds and make it difficult to stop the vehicle, which could cause a crash, serious injury or death.
Remedy: Isuzu will notify owners, and dealers will remove and replace the stopper bolt with a flanged plate, to prevent lateral movement of the throttle, free of charge. The recall began on June 23, 2017. Owners may contact Isuzu customer service...
View full details →Recall 09V434000 — EQUIPMENT:APPLIANCE:AIR CONDITIONER
| 53 vehicles affected
Defect: E-N-G MOBILE SYSTEM IS RECALLING CERTAIN MODEL YEAR 2008 CHEVROLET W5500, MODEL YEAR 2007-2009 DODGE 3500, MODEL YEAR 2009 MIGHTY MOVER, MODEL YEAR 2006-2009 FORD E-250, E-350 AND E-450, MODEL YEAR 2008-2009 GMC W4500, MODEL YEAR 2007 INTERNATIONAL 4300, MODEL YEAR 2009 TOYOTA LAND CRUISER VEHICLES EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER...
Consequence: THIS DEFECT COULD RESULT IN A FIRE.
Remedy: E-N-G MOBILE SYSTEM WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2009. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR...
View full details →Recall 09V042000 — POWER TRAIN:DRIVELINE:DRIVESHAFT
| 2,836 vehicles affected
Defect: IZUSU IS RECALLING 2,836 MY 2008-2009 NPR/NQR AND NRR, GMC W3500, 4500 AND 5500, CHEVROLET W3500, 4500 AND 5500 TRUCKS. THE PROPELLER SHAFT WAS MANUFACTURED WITH INSUFFICIENT HIGH FREQUENCY HEAT TREATMENT. AS A RESULT, THE AFFECTED PORTION OF THE PROPELLER SHAFT MAY NOT MAINTAIN ITS DURABILITY THROUGH THE EXPECTED VEHICLE USEFUL LIFE.
Consequence: THE PROPELLER SHAFT COULD BREAK OFF WHILE THE VEHICLE IS BEING DRIVING, WHICH WOULD RESULT IN THE VEHICLE STALLING AND COASTING TO A STOP, OR LOSS OF VEHICLE CONTROL WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE PROPELLER SHAFT FREE OF CHARGE. THE RECALL BEGAN ON MARCH 5, 2009. OWNERS MAY CONTACT ISUZU AT 1-866-441-9638.
View full details →Owner Complaints for the 2009 GMC W4500
No complaints have been filed with NHTSA for the 2009 GMC W4500.
Safety Rating for the 2009 GMC W4500
NHTSA has not yet tested the 2009 GMC W4500 in its New Car Assessment Program.
Technical Service Bulletins for the 2009 GMC W4500
ISUZU MANUFACTURING SERVICES OF AMERICA has issued 1 technical service bulletin (TSBs) for the 2009 GMC W4500. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
SB-09-K-001 — POWER TRAIN:AUTOMATIC TRANSMISSION
ISUZU (CHEVROLET/GMC): THE TRANSMISSION SLIPS, WILL NOT SHIFT, OR MAY OVERHEAT. TECHNICIANS MAY FIND DTCS P0894 OR P0218 STORED EITHER CURRENT OR IN HISTORY. THESE CONDITIONS MAY BE CAUSED BY FRICTION MATERIAL DEBONDING FROM THE TORQUE CONVERTER CLUTCH. HARSH OR DELAYED SHIFTS, NO DRIVE, NO REVERSE, SLIPS AND THE SES/MIL...
NHTSA Investigations for the 2009 GMC W4500
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the GMC W4500
- 2004 GMC W4500 — 2 complaints
- 2005 GMC W4500 — 0 complaints
- 2006 GMC W4500 — 3 complaints
- 2007 GMC W4500 — 3 complaints
- 2008 GMC W4500 — 0 complaints
- 2009 GMC W4500 (current)
- 2010 GMC W4500 — 0 complaints
Other GMC Models
- GMC SIERRA 1500 — 10,327 total complaints
- GMC ACADIA — 7,420 total complaints
- GMC YUKON — 6,108 total complaints
- GMC SIERRA — 4,896 total complaints
- GMC TERRAIN — 4,098 total complaints
- GMC JIMMY — 3,778 total complaints
- GMC ENVOY — 3,269 total complaints
- GMC YUKON XL — 2,820 total complaints