2004 GMC SAVANA 1500 — Problems, Recalls & Safety Data
N/A
Safety Rating
5
Owner Complaints
1
Recall
0
Service Bulletins
0
Investigations
Overview of the 2004 GMC SAVANA 1500
The 2004 GMC SAVANA 1500 has received a total of 5 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There has been 1 recall campaign affecting this vehicle, covering issues with FUEL SYSTEM, GASOLINE. The most commonly reported problems involve the Tires (2 complaints), Service Brakes Hydraulic (1 complaint), and Steeringlinkagestie Rod Assembly (1 complaint).
Recalls for the 2004 GMC SAVANA 1500
NHTSA has recorded 1 recall for the 2004 GMC SAVANA 1500, potentially affecting up to 88,303 vehicles.
Recall 06E043000 — FUEL SYSTEM, GASOLINE
| 88,303 vehicles affected
Defect: CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK...
Consequence: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
View full details →Owner Complaints for the 2004 GMC SAVANA 1500
5 complaints have been filed with NHTSA for the 2004 GMC SAVANA 1500. Below is a breakdown by vehicle component.
| Component | Complaints | Crashes | Fires | Injuries | Deaths |
|---|---|---|---|---|---|
| Tires | 2 | 0 | 0 | 0 | 0 |
| Service Brakes Hydraulic | 1 | 0 | 0 | 0 | 0 |
| Steeringlinkagestie Rod Assembly | 1 | 0 | 0 | 0 | 0 |
| Structurebody | 1 | 0 | 0 | 0 | 0 |
Most Recent Complaints
TL*THE CONTACT OWNS A 2004 GMC SAVANNA EQUIPPED WITH DEFINITY DAKOTA A/T TIRES, SIZE 235/75R16. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH, WHEN THE VEHICLE MADE A THUMPING NOISE. THE CONTACT PULLED OVER AND NOTICED ALL OF THE TREAD ON THE RIGHT REAR TIRE WAS MISSING. A SPARE TIRE WAS INSTALLED ON THE VEHICLE. THE FOLLOWING DAY, THE CONTACT STATED THAT THE FRONT PASSENGER SIDE TIRE HAD A 9/10 INCH BLISTER ON IT. THE CONTACT INSTALLED FOUR NEW TIRES. THE FAILURE MILEAGE WAS 62,000 AND CURRENT MILEAGE WAS 63,400.
TL* THE CONTACT OWNS A 2004 GMC SAVANNA 1500 WITH FALKEN ZINEN STZ01 TIRES, LINE SIZE P265/50/R20. WHILE DRIVING AT 50 MPH, THE VEHICLE BEGAN TO VIBRATE EXCESSIVELY. ONE OF THE TIRES EXPERIENCED BELT SEPARATION AND THE REAR BELT FRACTURED. THE TIRE WAS REPLACED HOWEVER; WITHIN 200 MILES ALL THREE REMAINING TIRES EXPERIENCED THE EXACT SAME FAILURE. THE REMAINING THREE TIRES WERE REPLACED. THE CONTACT STATED THAT THE FRONT REPLACEMENT TIRES BEGAN TO EXHIBIT BELT SEPARATION. THE TIRES WERE NOT YET REPLACED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 17,000 AND THE CURRENT MILEAGE 42,000.
THE CARGO DOORS ARE VERY DIFFICULT TO OPEN. THE DOOR HINGES HAVE RUSTED INTERNAL, SO THAT ONE OF THE HINGES SNAPPED OFF (LOWER HINGE, PASSENGER SIDE CARGO DOOR). GM HAS TSB FOR THIS BUT WILL NOT COVER IT. IT IS VERY UNSAFE IF YOU CAN NOT EXIT THE DOOR. *TR
TL*- THE CONTACT OWNS A 2004 GMC SAVANNA VAN WITH A CURRENT ODOMETER READING OF 10,200 MILES. THE CONTACT STATED THAT THE VAN TOOK A LONG TIME TO STOP WHEN THE BRAKES WERE APPLIED. THE CONTACT FOUND THAT THE BRAKES THAT CAME WITH THE VEHICLE WERE TOO SMALL, WHICH RESULTED IN EXTENDED STOPPING DISTANCE WHEN APPLIED. THE MANUFACTURER WAS CALLED ABOUT THIS PROBLEM ,AND THEY TOLD THE CONTACT TO CALL HIS LOCAL DEALER AND HAVE THEM LOOK AT THE BRAKES. THE DEALER TOLD THE CONTACT THAT THE BRAKES WERE PERFORMING CORRECTLY. THE CONTACT STATED THAT WHEN HE WAS DRIVING AT 70 MPH UNDER ANY WEATHER CONDITIONS HE OFTEN HAD TO PULL TO THE SIDE OF THE ROAD WHEN BRAKING TO AVOID HITTING OTHER VEHICLES. *AK UPDATE *4/23/07 *TR
DT*: THE CONTACT STATED WHILE DRIVING AT 30 MPH, A NOISE WAS HEARD COMING FROM THE FRONT OF THE VEHICLE. UPON INSPECTION BY AN INDEPENDENT MECHANIC, IT WAS DETERMINED THAT THE INNER TIE ROD WAS FRACTURED AND HAD TO BE REPLACED. THIS WAS THE SECOND TIME THE SAME PROBLEM OCCURRED AND HAD TO BE REPLACED. THE MANUFACTURER WAS INFORMED. UPDATED 10/04/06.*JB
Safety Rating for the 2004 GMC SAVANA 1500
NHTSA has not yet tested the 2004 GMC SAVANA 1500 in its New Car Assessment Program.
Technical Service Bulletins for the 2004 GMC SAVANA 1500
No technical service bulletins have been reported for this vehicle.
NHTSA Investigations for the 2004 GMC SAVANA 1500
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the GMC SAVANA 1500
- 1999 GMC SAVANA 1500 — 1 complaint
- 2000 GMC SAVANA 1500 — 5 complaints
- 2001 GMC SAVANA 1500 — 3 complaints
- 2002 GMC SAVANA 1500 — 3 complaints
- 2003 GMC SAVANA 1500 — 3 complaints
- 2004 GMC SAVANA 1500 (current)
- 2005 GMC SAVANA 1500 — 7 complaints
- 2006 GMC SAVANA 1500 — 1 complaint
- 2007 GMC SAVANA 1500 — 3 complaints
- 2008 GMC SAVANA 1500 — 2 complaints
Other GMC Models
- GMC SIERRA 1500 — 10,327 total complaints
- GMC ACADIA — 7,420 total complaints
- GMC YUKON — 6,108 total complaints
- GMC SIERRA — 4,896 total complaints
- GMC TERRAIN — 4,098 total complaints
- GMC JIMMY — 3,778 total complaints
- GMC ENVOY — 3,269 total complaints
- GMC YUKON XL — 2,820 total complaints