2004 GMC ENVOY Engine Problems

The contact owned a 2004 GMC Envoy. The contact stated that while driving at an undisclosed speed, the vehicle was shaking and made an abnormal rattling sound before the vehicle lost motive power and stalled. The vehicle was restarted and driven to the dealer to be diagnosed. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 130,000. The VIN was unavailable.

I JUST HAD MY BRAKES SERVICED AND MY BUSHINGS CHANGED, BUT MY ABS LIGHT STILL COMES ON. ALSO WHEN I GO TO BRAKE THE CAR STARTS TO SHAKE AND I'M GOING THE SPEED LIMIT. THE ENGINE HAS A ROUGH IDLE, AND SHUTS OFF WHEN AT A COMPLETE STOP AND WHEN THE VEHICLE IS IN MOTION. I'VE HAD MANY THINGS REPLACED ON THE VEHICLE, SUCH AS PURGE VALVE, GAS CAP. CHARCOAL CANISTER AND FUEL TANK. IN THE ENGINE THE SPARK PLUGS WERE CHANGED AS WELL AS THE COIL PACKS AND THE FUEL INJECTORS. ALONG WITH THE CAMSHAFT SENSOR. STILL GETTING P0455 AND PO0014. WON'T PASS SMOG CAN'T REGISTER VEHICLE, BUT MY ONLY MEANS OF TRANSPORTATION. 2004 GMC ENVOY XUV SLT 4DR 2WD

VEHICLE MAKES LOUD TICKING NOISE WHEN ACCELERATING FROM A FULL STOP. VEHICLE ALSO SOUNDS LIKE IT HAS AN EXHAUST LEAK.

VEHICLE WAS BEING DRIVING APPROXIMATELY AT 55 MPH. ENGINE LOSS POWER, GAS PEDAL LOST RESISTANCE AND WENT ALL THE WAY DOWN TO THE FLOOR BOARD. VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND ENGINE WAS STALLED AND ALL THE DASH LIGHTS WERE FLASHING ONE AND OFF. ENGINE STARTED TO HAVE WHITE SMOKE COMING FROM UNDER THE HOOD. AFTER A FEW MINUTES, THE WHITE SMOKE TURNED INTO BLACK SMOKE AND THE ENGINE CAUGHT ON FIRE. VEHICLE WAS ENGULFED IN FLAMES AFTER A FEW MINUTES.

TL* THE CONTACT OWNED A 2004 GMC ENVOY. WHILE DRIVING APPROXIMATELY 55 MPH, WHITE SMOKE EMERGED FROM THE ENGINE COMPARTMENT. THE CONTACT HAD TO PULL OVER IN A PARKING AREA AND EXITED THE VEHICLE. THE VEHICLE BURNED TO THE GROUND. THE POLICE AND FIRE DEPARTMENT WERE PRESENT. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

VEHICLE WAS BEING DRIVEN ON A TWO WAY HIGHWAY AT APPROXIMATELY 55 MPH. VEHICLE LOST ENGINE POWER WHILE DRIVING AND THE GAS PEDAL LOST RESISTANCE AND WENT TO THE FLOOR. VEHICLE WAS STEERED OVER TO THE SIDE OF THE ROAD. WHILE THE VEHICLE WAS STEERED OVER TO THE SIDE OF THE ROAD, CHECK ENGINE AND OTHER DASH LIGHTS STARTED FLASHING CHAOTICALLY. WHITE SMOKE STARTED COMING FROM UNDER THE HOOD. WITHIN A SHORT TIME, WHITE SMOKE TURNED INTO BLACK SMOKE AND THEN FLAMES STARTED TO APPEARS. THE FIRE UNDER THE HOOD EVENTUALLY CONTINUED TO GROW UNTIL IT COMPLETELY BURNED THE ENGINE COMPARTMENT MOST OF THE FIRST TWO ROWS OF THE INTERIOR BEFORE THE FIREMEN ARRIVED AND WERE ABLE TO PUT OUT THE FIRE.

ONE DAY MY SUNROOF WORKED AND THE NEXT DAY IT WOULD NOT. IT WAS STUCK IN THE IN THE OPEN POSITION (NOT FULLY OPEN, BUT WHEN THE FRONT END RAISES AN INCH OR SO). I TOOK IT TO A GM CERTIFIED MECHANIC AND THEY SAID I WOULD NEED A WHOLE NEW ASSEMBLY AND QUOTED ME $2,100. THE DEALERSHIP AND GM NOTIFIED ME THAT THEY WOULD NOT HELP ME WITH THIS DEFECT AT ALL. MY CAR IS IN EXCELLENT CONDITION WITH ONLY 85,000 MILES ON IT, BUT IT IS ONLY WORTH $5,000 AND I PAID OVER $14,000 FOR IT IN 2009 WHEN I BOUGHT IT FROM A GM DEALERSHIP. I CANNOT AFFORD TO LOSE $2,100 ON THIS VEHICLE. AND THIS IS NOT THE FIRST ISSUE THAT I HAVE HAD. WHEN I DROVE IT HOME FROM THE DEALERSHIP THE WHOLE INSTRUMENT PANEL FAILED. THEY FIXED THAT. THEN A YEAR LATER, WHEN I...

I PURCHASED THE VEHICLE MARCH OF 2014 FROM SUNSET MOTORS IN COEUR D ALENE, ID. THE FOLLOWING DAY THE CAR DIED AND I TOOK IT BACK TO THE DEALER WHERE THEY TOLD ME THE FUEL PUMP NEEDED REPLACED; WHICH THEY REPLACED. I LEFT THE DEALERSHIP AFTER THE REPAIR WAS COMPLETED AND FILLED MY GAS TANK WHEN I BEGAN TO SMELL A STRONG ODOR OF GAS. I PULLED AWAY FROM THE PUMP AND LOOKED UNDER THE VEHICLE TO SEE GAS LEAKING FROM WHAT APPEARED TO BE THE FUEL TANK. I TOOK IT BACK TO THE DEALERSHIP AND THEY SAID THAT THE NECK OF THE GAS TANK WAS CRACKED AND THEY WOULD REPAIR IT. I LEFT WITH THE VEHICLE AFTER SUNSET MOTORS STATED THE REPAIR WAS DONE ON THE GAS TANK. THE CHECK ENGINE LIGHT CAME ON THE FOLLOWING DAY. THE CODE WAS READING P0455 LARGE EVAP LEAK. I HAVE TRIED REPLACING...

I WILL CUT THE CAR ON AND REDUCED ENGINE POWER LIGHT COMES ON AND THE CAR IDOLS HARD THEN CUTS OFF WHILE DRIVING . I READ ON INTERNET ALIT OF GM VEHICLES HAVE THIS PROBLEM JUST WONDERING IS THERE A RECALL? ALSO CHECK ENGINE LIGHT AND REDUCED ENGINE POWER LIGHT WILL NOT CUT OFF. *TR

TL* THE CONTACT OWNS A 2004 GMC ENVOY. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD STALL WITHOUT WARNING. THE VEHICLE WOULD OPERATE NORMALLY ONCE THE ENGINE WAS RESTARTED. THE DEALER STATED THAT THE SPARK PLUGS WERE FAULTY. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 146,000. UPDATED 8/27/14*CN UPDATED 8/29/2014 *JS

STOPPED AT STREET LIKE, LIGHT WENT GREEN STARTED TO MOVE FORWARD AND CAR GOES DEAD. NO LIGHTS ON DASH, NOTHING SHOWING, JUST STOPS ABRUPTLY. AFTER A FEW MOMENTS TRIED RESTARTING CAR AND IT CAME BACK ON WITH CHECK ENGINE LIGHT. P0606 PCM FAILURE CODE DISPLAYED. COULD HAVE BEEN REAR ENDED BY SEMI TRUCK BEHIND ME OR KILLED IF I WAS TRYING TO TURN LEFT AT INTERSECTION. *TR

TL* THE CONTACT OWNS A 2004 GMC ENVOY. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STALLED WITHOUT WARNING AND THE SERVICE ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 89,000.

MY GMC ENVOY STALLS OUT WHEN I STOP AT TRAFFIC LIGHTS. I THEN HAVE TO PUT IT IN PARK TO RESTART THE VEHICLE. ALTHOUGH TEST METERS/EQUIPMENT HAVE BEEN USED TO FIND THE CAUSE FOR THE UNEXPLAINED STALL IS STILL UNKNOWN.THIS HAPPENS APX. ONCE EVERY (2) MONTHS. WHEN THE ENGINE STALLS OUT THE "CHECK ENGINE LIGHT" COMES ON AND LAST MONTH THE " REDUCED ENGINE POWER" LIGHT ALSO CAME ON AND THE ENVOY WOULD ONLY MOVE AT 3 TO 4 MPH. *TR

THE "CHECK GAUGES" LIGHT FLASHES FOLLOWED BY "LOW OIL PRESSURE" FOLLOWED BY "STOP ENGINE" AND THE ENGINE STALLS. EACH TIME THIS HAPPENS THE AC HAS BEEN ON. SENT TO DEALER AND THEY WERE UNABLE TO REPRODUCE THIS ISSUE. HAS HAPPENED 3 TIMES NOW. VERY SCARY. *TR

WHILE DRIVING ANOTHER MOTORIST SAW SMOKE COMING FROM REAR OF VEHICLE AND GOT VEHICLE STOPPED ON SIDE OF ROAD AT WHICH TIME THE ENGINE COMPARTMENT WAS ENGULFED IN FLAMES. CALLED FIRE DEPT AND POLICE. FIRE SPREAD THROUGH THE HEARER BOX INTO THE VEHICLE AND ACROSS DASH UNTIL IT BEGAN BURNING THE HEADLINER. FIRE DEPT PUT OUT FIRE BUT WAS A TOTAL LOSS. THERE WAS NO INDICATION ON INSTRUMENT PANEL OF ANY PROBLEMS (ALL GAUGES SHOWING NORMAL READINGS). *TR

ENGINE STALLS WHEN YOU SLOW DOWN AND THE AIR CONDITIONER OR WIDOW DEFOGGER IS ON . I HAVE ALSO HAD POWER SURGING. I HAD TO REPLACE THE MAP SENSOR TWICE AND THE BRACKET AND IT IS STILL SHOWING BAD. I ALSO REPLACE THE CAM SHAFT POSITION SENSOR AND THE THERMOSTAT. ALSO THE WIPER ON THE REAR WILL NOT SPRAY ANY WATER OR WASHER. *TR