2010 FREIGHTLINER CASCADIA Electrical System Problems

ON 06/26/2018 I WAS DRIVING IN CHICAGO ON SOUTH WESTERN AVE IT WAS RAININIG THAT NIGHT I PULLED OVER BECAUSE MY 2012 CASCADIA WAS ASKING FOR A REGEN OF THE DEF SYSTEM .. I PULLED OVER IN A SAFE AREA AND STARTED THE REGEN PROCESS. ABOUT 10 MIN IN TO THE REGEN PROCESS ON THE LOWER DRIVER SIDE DASH AREA HEAVY SMOKE AND THE SMELL OF BURNING WIRE WAS NOTICED A FIRE BROKE OUT AT THE FUSE BOX LOCATED ON THE LOWER DRIVER SIDE IT WAS DETERMINED BY INSURANCE COMPANY THAT THESE 2012 CASCADIAS ARE KNOWN FOR LEAKS IN THE CAB AREA CAUSING THE MOISTURE OR WATER TO LEAK IN AND INTERACT OR MAKE CONTACT WITH FUSE BOX AREA CAUSING A FIRE ...

TL* THE CONTACT OWNS A 2010 FREIGHTLINER CASCADIA. THE CONTACT STATED THAT THE INTERIOR AND INSTRUMENTAL PANEL LIGHTING FAILED INTERMITTENTLY. THE DEALER DIAGNOSED THAT WATER PENETRATED THROUGH THE WINDSHIELD AND CAUSED THE SAMCAP MODULE TO FAIL. THE MODULE WAS NOT REPLACED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 4,081.

TL* THE CONTACT OWNS A 2010 FREIGHTLINER CASCADIA. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, ALL THE WARNING LIGHTS ON THE INSTRUMENT PANEL ILLUMINATED. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD, WHERE THE VEHICLE WAS TURNED OFF AND RESTARTED. THE CONTACT STATED THAT WHEN THE VEHICLE WAS RESTARTED ALL OF THE WARNING LIGHTS WENT AWAY, BUT AFTER DRIVING FOR SEVERAL MINUTES THE WARNING LIGHTS BECAME ILLUMINATED AGAIN. THE VEHICLE WAS TAKEN FOR DIAGNOSTIC TESTING. THE CONTACT WAS INFORMED THAT THE SIGNAL DETECTION AND ACTIVATION MODULE HAD MALFUNCTIONED DUE TO WATER GETTING INTO CONTACT WITH THE ELECTRICAL COMPONENTS. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V127000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 600,000.

2010 FREIGHTLINER CASCADIA. CONSUMER STATES VEHICLE IS UNSAFE TO DRIVE DUE TO ELECTRICAL MALFUNCTIONS, CAUSING SUDDEN, UNEXPECTED LOSS OF POWER, OR LOSS OF USE OF WIPERS. TGW