2021 FOREST RIVER WILDWOOD — Problems, Recalls & Safety Data

CASTL ROCK RADIAL ST226 235/80R16. WHILE TRAVEL AT 65 MPH THE TIRE TREAD ON THE FRONT AXLE OF MY CAMPER CAME APART AND WHIPPED AROUND. THIS WHIPPING CAUSED MULTIPLE PUNCTURE HOLES IN THE REAR TIRE CAUSING THE REAR TIRE TO GO FLAT. THIS CAUSED DAMGAGE TO THE SKIRT OF THE CAMPER AND A DRAIN VALVE. THE TIRES WERE PURCHASED WITH THE CAMPER WHICH I BOUGHT NEW IN MAY OF 2021 AND HAVE APPROXIMATELY 4500 MILES ON THE TIRES. THE TIRES ARE CHECKED MONTHY AND ARE ALWAYS INFLATED TO 80 PSI COLD. THERE WERE NO WARNING SIGNS AND FORTUNATELY THE TIRE THAT LOST THE TREAD STAYED INFLATED SO I COULD SAFELY GET TO THE SHOULDER TO EVALUATE THE DAMAGE. I THEN IDLED TO THE NEXT EXIT TO UNHOOK THE TRAILER SO I COULD CHANGE THE FLAT TIRE AND THEN SLOWLY PROCEED TO THE REPAIR SHOP. ALL FOUR TIRES ARE AVAILABLE FOR INSPECTION BY YOU. THE ONE THAT FAILED, THE ONE THAT WAS PUNCUTED AND THE TWO ON THE PASSENGER WHCIH ARE INTACT. AS A PRECAUSTION I AM REPLACING ALL FOUR TIRES. I HAVE READ ON MULTIPLE FORUMS OF MULTIPLE INCIDENTS WITH THESE TIRES FOR SIMILIAR ISSUES AND THESE TIRES SHOULD BE RECALLED. FOR SAFETY REASONS. I HAVE REACHED OUT TO FOREST RIVER AND THEY STATE IN A MEIAL THERE HAVE NOT BEEN AN ISSUES AND I WILL CONTACT THE TIRE MANUFACTURE IN REGRADS TO THIS. I URGE YOU TO TAKE ALL FOUR TIRES AND DO A COMPLETE EVALUATION TO DETERMINE WHAT CAUSED THIS FAILURE AS THERE HAVE NEEN SIMILIAR INCIDENTS.

Tire exploded while driving, causing loss of control. Spare tire replaced and also did the same thing. Tires had under 5,000 miles on them, tire pressures checked before trip, and tires have been stored indoors. Many people online are having the same issue with these particular tires.

Recently, I was extending the awning on my travel trailer and it free spooled out without motor resistance. After researching this, it seems like a very common problem for the Dometic 9200 awning. (Motor part # 3316605.001) There is a design flaw in the motor where the metal drive rod is injected into a plastic gear. Over time 0-2 years this plastic piece wears out and start to spin/slip freely under load. This causes the awning to become unstable and allows it to extend at any time. This is a serious safety issue as it came out for a second time on the highway, while I was hauling it. Luckily, I saw it immediately and was able to pull over and secure it. It could have been a lot worse or caused an accident. Dometic won't talk to me, so I'm in the process of working with Forest River, as the awning was installed by them. I can buy a replacement motor, however unless the design is changed, it will just happen to others. There is a lot of similar complaints if you search for it. I have not had my trailer inspected as it is clear what is occurring. The consumer stated after a few attempts Dometic came to his house and repaired the motor and gear on the vehicle.

Recently, I was extending the awning on my travel trailer and it free spooled out without motor resistance. After researching this, it seems like a very common problem for the Dometic 9200 awning. (Motor part # 3316605.001) There is a design flaw in the motor where the metal drive rod is injected into a plastic gear. Over time 0-2 years this plastic piece wears out and start to spin/slip freely under load. This causes the awning to become unstable and allows it to extend at any time. This is a serious safety issue as it came out for a second time on the highway, while I was hauling it. Luckily, I saw it immediately and was able to pull over and secure it. It could have been a lot worse or caused an accident. Dometic won't talk to me, so I'm in the process of working with Forest River, as the awning was installed by them. I can buy a replacement motor, however unless the design is changed, it will just happen to others. There is a lot of similar complaints if you search for it. I have not had my trailer inspected as it is clear what is occurring. The consumer stated after a few attempts Dometic came to his house and repaired the motor and gear on the vehicle.

Recently, I was extending the awning on my travel trailer and it free spooled out without motor resistance. After researching this, it seems like a very common problem for the Dometic 9200 awning. (Motor part # 3316605.001) There is a design flaw in the motor where the metal drive rod is injected into a plastic gear. Over time 0-2 years this plastic piece wears out and start to spin/slip freely under load. This causes the awning to become unstable and allows it to extend at any time. This is a serious safety issue as it came out for a second time on the highway, while I was hauling it. Luckily, I saw it immediately and was able to pull over and secure it. It could have been a lot worse or caused an accident. Dometic won't talk to me, so I'm in the process of working with Forest River, as the awning was installed by them. I can buy a replacement motor, however unless the design is changed, it will just happen to others. There is a lot of similar complaints if you search for it. I have not had my trailer inspected as it is clear what is occurring. The consumer stated after a few attempts Dometic came to his house and repaired the motor and gear on the vehicle.