1996 FORD WINDSTAR Wheelsrim Problems

14 NHTSA complaints on file

Check any vehicle history by VIN - Free vehicle history report

Wheelsrim Issues in the 1996 FORD WINDSTAR

14 wheelsrim complaints have been filed with NHTSA for the 1996 FORD WINDSTAR. Of these, 0 involved a crash, 0 involved a fire, and 0 resulted in injury.

Complaints

Crashes

Fires

Injuries

Deaths

All Wheelsrim Complaints

#10098554 | November 9, 2004

THE ORIGINAL WHEELS ON MY 1996 WINDSTAR HAVE DEVELOPED AIR LEAKS AT THE WELDS. THE FIRST TIME THIS HAPPENED, I WENT TO A SALVAGE YARD FOR A REPLACEMENT, AND THEY SAID WINDSTAR WHEELS ARE SCARCE BECAUSE THIS SEEMS TO BE A COMMON PROBLEM. I HAVE REPLACED ALL FOUR WHEELS WITHIN THE PAST TWO YEARS. I BELIEVE THE OEM WHEELS ARE DEFECTIVE. (IN 34 YEARS OF DRIVING, I'VE NEVER HAD THIS PROBLEM WITH EVEN ONE WHEEL ON ANY CAR. 4 OUT OF 4 WHEELS WITH THE SAME PROBLEM ON THIS VAN TELLS ME SOMETHING IS WRONG WITH THE PRODUCT.) OUR DRIVING IS ON GOOD ROADS, SO IT CANNOT BE ATTRIBUTED TO ROUGH USE. THE ONLY CONSEQUENCE SO FAR IS THAT TIRE PRESSURE IS SLOWLY LOST, LEADING TO LOW PRESSURE. OUR ONLY EXPENSE SO FAR IS THAT WE HAVE HAD TO REPLACE ALL THE WHEELS, ONE AT A TIME. THIS PROBLEM CAUSES...

#10091691 | September 28, 2004

PROBLEMS WITH TIRES ON 1996 FORD WINDSTAR.*MR THE CONSUMER PURCHASED A SET OF NEW TIRES FOR HIS VEHICLE. AFTER 50,000 MILES THE CONSUMER HAD A FLAT TIRE SHORTLY WHICH RESULTED FROM RIM SEPARATION (A SEPARATION BETWEEN THE OUTER RIM THAT HOLDS THE TIRE AND THE INNER PART THAT HAS THE LUG HOLES). THE CONSUMER PURCHASED ANOTHER RIM AND EXPERIENCED THE SAME PROBLEM TWO MONTHS LATER. TC

#10087232 | August 4, 2004

CONSUMER STATED THAT ALL FOUR RIMS HAD CRACKS IN THEM. CONSUMER TOOK VEHICLE TO THE DEALER, WHERE IT WAS DETERMINED THAT THE RIMS WERE DEFECTIVE. *AK

#10021787 | May 28, 2003

THE RIMS INSIDE OF THE WHEEL HAD A HOLE THAT DEVELOPED CRACKS INSIDE OF THE WHEEL WHICH CAUSED IT TO DETERIORATE. *TT

#10017398 | April 22, 2003

THE DRIVER SIDE RIM CRACKED. *JB

#8014813 | July 25, 2002

WHILE TRAVELING ON THE HIGHWAY THE RIM OF THE TIRE IS CUTTING INSIDE BEAD OF THE TIRE CAUSING A BLOW OUT. THE DEALERSHIP IS AWARE OF THE PROBLEM.*JB

#764360 | July 19, 2002

1. AUTO TRANSMISSION FRONT SEAL PREMATURE FAILURE CAUSING LEAKS. 2. 5.5 X 15 STEEL RIM CRACKED DUE TO MATERIAL DEFECTS, CAUSING DANGEROUS STEELING RESPONSES. BOTH DEFECTS HAVE BEEN REPORTED TO FORD SAN FRANCISOC REGION, BUT FORD DENY RESPONSIBILITY.

#749692 | August 3, 2001

IN 1999 WHEN TURNING TO THE RIGHT, WE EXPERIENCED A GRINDING NOISE. MY HUSBAND REMOVED THE HUBCAP AND FOUND THE STEEL RIM OF THE WHEEL TO BE CRACKED BADLY. WE CONTACTED THE MANUFACTURER AND THE DEALER WHO BOTH SAID IT WAS A SERIOUS PROBLEM, BUT THAT THE OTHER SHOULD PAY TO HAVE IT FIXED. BECAUSE I PUT MY 3 SMALL CHILDREN IN THE CAR, I PAID TO HAVE IT FIXED. TWO YEARS LATER, WE HAVE FOUND TWO MORE WHEELS HAVE CRACKED. THIS TIME, WE CONTACTED THE DEALER AND THE MANUFACTURER AGREED TO HELP PAY FOR THE REPAIR. THE SPEEDOMETER WAS THE FIRST "PROBLEM" WE CAME ACROSS WITH THIS CAR. AT SPEEDS OF OVER 40MPH THE NEEDLE WOULD GO SPORACTICALLY BACK AND FORTH BETWEEN ABOUT 35 AND 110MPH. WE WERE TOLD IT WOULD BE $400 TO REPLACE SO, WE HAVE NOT YET HAD IT FIXED. SINCE THE FIRST FEW MONTHS OF...

#732470 | October 2, 2000

BOTH OF THE FRONT RIMS DEVELOPED CRACKS. THIS WAS DISCOVERED IN AN INSPECTION TO FIND A CLICKING NOISE COMING FROM TIRE AREA. FORD WAS CONTACTED(LOCAL DEALER AND NATIONAL CUSTOMER SERVICES) THEY DO NOT SEEM CONCERNED AND WERE UNWILLING TO REPLACE THE RIMS. I FEEL THAT 2 (TWO) RIMS CRACKING ON ONE VECHICLE WITHOUT ANY APPARENT CAUSE MAY BE A SIGN OF FAULTY RIMS AND A POTENTIAL HAZARD TO ALL OWNERS OF LIKE RIMS.*AK

#732470 | October 2, 2000

BOTH OF THE FRONT RIMS DEVELOPED CRACKS. THIS WAS DISCOVERED IN AN INSPECTION TO FIND A CLICKING NOISE COMING FROM TIRE AREA. FORD WAS CONTACTED(LOCAL DEALER AND NATIONAL CUSTOMER SERVICES) THEY DO NOT SEEM CONCERNED AND WERE UNWILLING TO REPLACE THE RIMS. I FEEL THAT 2 (TWO) RIMS CRACKING ON ONE VECHICLE WITHOUT ANY APPARENT CAUSE MAY BE A SIGN OF FAULTY RIMS AND A POTENTIAL HAZARD TO ALL OWNERS OF LIKE RIMS.*AK

#862337 | May 22, 2000

FOUR RIMS AT A TIME WILL LEAK AIR WITHOUT PRIOR WARNING. ALSO, TIRES WILL GO FLAT, EVEN ON HIGHWAY. *AK

#548727 | November 29, 1999

WHEEL RIM LEAKED AIR. YH

#844364 | September 22, 1999

WHILE DRIVING VEHICLE THE TIRE WAS FLAT, TOOK TIRE FOR REPAIR AND CONSUMER WAS TOLD THAT THE TIRE WAS FLAT BECAUSE THE WHEEL RIM HAD SPLIT NEAR ONE OF THE WELDS, UNWELDED AND CAME APART. *AK

#543531 | February 8, 1999

2 RIMS FAILED CAUSING SLOW LEAK.

Other 1996 FORD WINDSTAR Problem Areas

← Back to 1996 FORD WINDSTAR overview