1995 FORD WINDSTAR Service Brakes Hydraulic Problems

TL* THE CONTACT OWNS A 1995 FORD WINDSTAR. THE CONTACT STATED THAT BRAKE FLUID WAS LEAKING FROM THE VEHICLE AND THE BRAKE AND ABS WARNING LIGHTS WERE ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS AWAITING A DIAGNOSIS OF THE FAILURE. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 02V101000 (SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 37,000.

ABS BRAKE WARNING LIGHT (YELLOW) COMES ON WHILE DRIVING AND WON'T GO OFF. *TT

FORD WINDSTAR ABS/BRAKE LIGHT STILL COMES ON AFTER RECALL. *TR

THE FORD DEALER FIX A SAFETY RECALL 09S09 BUT NOW MY ABS SYSTEM MESSED UP.IT IS VERY DANGROUS PLEASE INVESTIGATE ON THIS ISSUE.THANKS

MY SPEEDOMETER AND ODOMETER STOPPED WORKING A COUPLE OF DAYS AGO ON MY 1995 FORD WINDSTAR. I GOT ON THE INTERNET AND FOUND THE RECALL HAVING TO DO WITH THE ABS BRAKE LIGHT. I UNDERSTAND THAT MY CAR COULD CATCH FIRE WHEN UNATTENDED. WE HAVE BEEN LOSING BRAKE FLUID FOR SOME TIME. WHEN THE AREA IN QUESTION FOR THE RECALL UNDER THE BRAKE MASTER CYLINDER WAS INSPECTED, THERE WAS INDEED FLUID LEAKING. WE HAVE ALSO HAD AN ABS LIGHT ON THE DASH LIGHTING FOR SOME TIME. MY HUSBAND HAS JUST BEEN ADDING BRAKE FLUID, BUT NOW THE LIGHT DOESN'T EVEN LIGHT. I DON'T KNOW ABOUT THE CRUISE CONTROL NOT WORKING. MY MECHANIC WILL LOOK AT IT BEFORE FORD DOES. *TR

SEVERE CORROSION OF BRAKE LINES. ONE LINE HAS ALREADY CORRODED TO THE FAILURE POINT RESULTING IN TOTAL BRAKE FAILURE. FURTHER INVESTIGATION SHOWS ALL BRAKE LINES ARE SUSPECT. FORD HAS SKIMPED TO SAVE MONEY BY NOT USING STAINLESS OR COATED LINES ON THIS VEHICLE AND THE RESULT IS A VEHICLE WHICH MAY IN A PANIC STOP HAVE TOTAL FAILURE OF THE BRAKES. UNFORTUNATELY I CANNOT JUSTIFY THE COST OF REPLACEMENT SO THE VEHICLE IS STILL BEING DRIVEN WITH THIS CONDITION. PHOTOS ARE AVAILABLE. *TR

TL*THE CONTACT OWNS A 1995 FORD WINDSTAR. WHILE DRIVING AT ANY SPEED, THE ABS LIGHT WOULD ILLUMINATE ON THE INSTRUMENT PANEL AND BRAKE FLUID WOULD LEAK. THE CONTACT ALSO NOTICED THAT THE CRUISE CONTROL SWITCH WORKED INCONSISTENTLY. SHE DISCOVERED THAT THE CRUISE CONTROL DEACTIVATION SWITCH HAD MELTED. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 152,000.

DURING BRAKE TEST AT MOTOR VEHICLE DIVISION THE PEDAL WENT TO THE FLOOR. ALL BRAKE FLUID EMPTIED FROM THE RESERVOIR. FURTHER INVESTIGATION SHOWED REAR BRAKE LINES ARE SEVERELY CORRODED AND THE LINE TO THE LEFT REAR BRAKE HAD FAILED DUE TO THE CORROSION. THE HOLE WAS LOCATED IN THE 90 DEGREE BEND AT THE BRAKE DRUM. LUCKILY THE VEHICLE COULD BE SAFELY STOPPED HOWEVER, THE POTENTIAL FOR INJURY WAS GREAT IF THIS HAD OCCURRED IN A TRAFFIC SITUATION. *TR

BRAKES FAILED ON 1995 FORD WINDSTAR. - REAR BRAKE LINE HAS CORRODED BADLY. THERE IS ABSOLUTELY NO EXCUSE FOR SAFETY RELATED COMPONENTS TO BE MANUFACTURED WITH MATERIAL THAT CAN CORRODE. IF AIRPLANES CAN SAFELY FLY AFTER 30+ YEARS OF SERVICE. WHY CAN'T AUTO MANUFACTURERS BE REQUIRED TO INSTALL CORROSION RESISTANT COMPONENTS FOR SAFETY CRITICAL SYSTEMS???? *TR

DT*: THE CONTACT STATED WHILE TRAVELING 30 MPH, THE BRAKE PEDAL WAS DEPRESSED AND THE VEHICLE DID NOT RESPOND. THE VEHICLE STOPPED WHEN THE PARKING BRAKE WAS DEPRESSED. IT WAS TOWED HOME WHERE THE BRAKE LINES WERE INSPECTED. THERE WAS CORROSION ON THE UNDERCARRIAGE OF THE VEHICLE, INCLUDING THE BRAKE LINES. THE VEHICLE HAS NOT BEEN SEEN BY A MECHANIC, BUT THE MANUFACTURER WAS ALERTED.

DT: CONSUMER HAS 1995 WINDSTAR. CONSUMER SAYS THAT THE BRAKE LIGHT WAS COMING ON. THIS HAPPENED FREQUENTLY. IT WAS MAYBE SIX MONTHS BEFORE BRAKE FLUID HAD TO BE ADDED THE SECOND TIME. THEN IT GOT TO WHERE THE FLUID HAD TO BE ADDED ABOUT ONCE A WEEK. WHEN CONSUMER ADDED BRAKE FLUID THE LIGHT WOULD GO OFF. ALSO CRUISE CONTROL DID NOT WORK. CONSUMER TOOK VEHICLE TO DAUGHTER'S AUTO MECHANICS CLASS, WHERE SHE FOUND THAT THE SPEED CONTROL DECELERATION SWITCH BURNED OFF OF THE MASTER CYLINDER. CONSUMER HAD PROBLEM REPAIRED WITH WHAT THE FORD DEALER CALLED A REPLACEMENT PART. CONSUMER WANTED TO KNOW IF THE REPLACEMENT PART WAS SAFE.*AK

PROBLEMS WITH HEAD GASKETS, TRANSMISSION, AND FAULTY BRAKES ON 1995 FORD WINDSTAR.*MR *JB

I HAVE OWNED THIS VAN SINCE 1999. SINCE I HAVE OWNED IT WE HAVE HAD NOTHING BUT PROBLEMS WITH IT. I HAVE HAD THE ROTORS TURNED, AND REPLACED AT LEAST 3 TIMES, AND THEY NEED IT AGAIN. I HAVE HAD THE HEAD GASKET REPLACED 3 TIMES AND ONE OF THEM TIMES WAS AT 99,000 MILES WHEN IT WAS UNDER THE WARRENTY. IT HAD BEEN REPLACED AT LEAST ONE TIME BEFORE THAT. MY SLIDING DOOR WON'T STAY CLOSED, EVEN THOUGH I JUST SPENT $300 GETTING A NEW LATCHED PUT ON. MY WINDOWS WON'T WORK. I HAD LARSON MOTORS FIX A HEAD GASKET AND MY ELECTRONIC WINDOWS, COST ME OVER $250 FOR THE WINDOW, THAT ONLY WORKED 2 TIMES. I CALLED, AND SINCE THEY PUT "MAY NOT BE THE PROBLEM" ON THE INVOICE, THEY THINK THAT CLEARS THEM, AND THEY WANTED ME TO SPEND MORE MONEY ON ANOTHER PART. MY SPEEDOMETOR HAS...

AT 146,00 MILES I WAS JUST INFORMED THAT I WILL HAVE TO HAVE ANOTHER HEAD GASKET REPAIR DONE (THAT WOULD MAKE IT THE THIRD TIME THIS PART HAS FAILED) TO SAVE THE CAR...I WILL NOT DO IT, AS IN FEBRUARY, I SPENT OVER $750 TO HAVE THE REAR BRAKES REPAIRED FOR BRAKE FLUID COVERING THE SHOES OF THE BRAKES, CAUSE BY BRAKE LINE CORROSION (JUST AS IN THE RIGHT FRONT BRAKE LINE CORROSION THAT WAS A NATIONAL RECALL!!!!) BUT THERE WAS NO RECALL FOR THE REARS

THE ENGINE WAS THE MAIN PROBLEM DUE TO THE HEAD GASKET RECALL. IN JULY,2000, WE ARGUED WITH FORD ABOUT A BAD ENGINE RUNNING FOR WHICH WE HAD JUST PAID OVER $300 TO EVALUATE BY AN OUTSIDE REPAIR SHOP. AFTER ABOUT 6 WEEKS WE RECEIVED OUR CAR BACK WITH A NEW LONG BLOCK PAID FOR BY FORD, INCLUDING A RENTAL VAN FOR THE TIME IN THE SHOP. IN JANUARY 2001 THE ENGINE WAS RUNNING ROUGH AGAIN AND WE WERE CHARGED $81.45 TO CHECK IT OUT AND REPLACE A WIRE BAD ON CYLINDER 6 WHICH WAS MISFIRING. THREE MONTHS LATER IN APRIL 2001 THE CAR RAN ROUGH AGAIN AND THE ENGINE LIGHT WAS BACK ON (HAPPENED FOR YEARS INTERMITTENTLY SINCE WE OWNED THE CAR). THE NEW LONG-BLOCK HAD ANOTHER BAD HEAD GASKET REINSTALLED PER THE SECOND FORD DEALERSHIP SERVICE CENTER. AFTER NEARLY ANOTHER MONTH WE HAD THE SECOND NEW LONG-BLOCK IN LESS...

BRAKE WORK X2 TRANSMISSION X2 ALL BELTS TIRE & SUSPENSION WORK LUGS ON WHEELS NOT PROPERLY REPLACED ,IT ALMOST FELL OFF STILL PAYING ON VEHICLE WHILE IT SITS IN ASHLEY FORD PARKING LOT W/ DEAD TRANSMISSION I AM UNABLE TO PAY CLOSE TO $2000 FOR REPAIRS

THE SUPPLEMENTAL BRAKING SYSTEM IS HELD BY TWO BOLTS, ONE OF THE BOLTS CAME LOOSE, MAKING IT HARD FOR THE DRIVER TO SET THE PARKING BRAKE. *AK

CONSUMER STATED THAT BRAKES WERE DEFECTIVE. A COUPLE OF TIMES, ALMOST DID NOT STOP AT A STOP SIGN, VEHICLE KEPT GOING EVEN WHEN HE KEPT PUMPING THE BRAKES. CONSUMER TOOK VEHICLE TO THE MECHANIC, AND MECHANIC DETERMINED THAT A CYLINDER WAS MISSING IN THE MOTOR. ALSO, MECHANIC TOLD CONSUMER THAT CALIPERS AND ROTORS NEEDED TO BE REPLACED. CONSUMER INSISTED THAT BRAKES/CALIPERS, AND ROTORS WERE REPLACED, BUT BRAKES STILL DID NOT WORK PROPERLY. THEN, CONSUMER RECEIVED A RECALL NOTICE. TOOK VEHICLE TO THE DEALER,AND LEFT VEHICLE AT DEALERS. 20 MINUTES LATER, MECHANIC CALLED CONSUMER AND STATED THERE WAS NOTHING WRONG WITH VEHICLE. *AK *MR

THE VEHICLE HAS HAD THE BRAKES REPLACED ON AVERAGE EVERY 6,000 MILES. THE CATALYTIC CONVERTER HAS BEEN REPLACED AT 40,000 MILES, THE HEAD GASKET AT 20,000. THE CUTTING OUT, ENGINE FAILURE HAS BEEN HAPPENING SINCE HEAD GASKET WAS CORRECTED. FORD HAS RESPONDED TO A WRITTEN LETTER, AT WHICH TIME I WAS ACCUSED FOR FORGING MY HUSBAND'S SIGNATURE (LATER I WAS TOLD HE WAS JUST KIDDING). THIS VEHICLE IS UNSAFE TRANSPORTATION FOR MY 3 CHILDREN. WHEN MOVING OUT INTO TRAFFIC, WE ARE IN DANGER OF A COLLISION IF THE ENGINE FAILS, AS IT OFTEN DOES. PLEASE FEEL FREE TO CONTACT MYSELF OR MY HUSBAND WITH ANY QUESTIONS. BARBARA SMITH. *AK *JB ****DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS****724221.

THE FRONT AREA OF MY VAN MAKES LOUD POPPING NOISES WHEN I APPLY THE BRAKES AND/OR TURN THE STEERING WHEEL. THIS PROBLEM OCCURS MAINLY IN THE SUMMER MONTHS OR TIMES WHEN THE TEMPERATURE IS WARMER. THIS PROBLEM BEGAN ABOUT A YEAR TO A YEAR AND A HALF AFTER I BOUGHT THE VAN WHEN IT WAS STILL UNDER WARRANTY, AND THE PROBLEM STILL EXISTS TODAY. I HAD TAKEN IT TO THE DEALER AND THEY TOLD ME THERE WAS NOTHING WRONG. THE DEALER SAID THE POPPING NOISE WAS THE BRAKE CYLINDERS EXPANDING ONTO THE PADS TO STOP THE VAN. IT IS ODD THOUGH BECAUSE THE FRONT END POPS WHEN I AM TURNING THE WHEEL AT A VERY SLOW SPEED WHEN I AM NOT APPLYING THE BRAKES. *NLM

CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEMS WITH THE REAR RIGHT BRAKE ALSO STATES THAT WHILE HUSBAND WAS DRIVING THE VEHICLE WAS ALMOST INVOLVED ON A COLLISION ALSO STATED THAT SHE HAS RECEIVED A RECALL FROM FORD ON THE FRONT RIGHT BRAKE. DEALER WAS CONTACTED AND STATED THAT HAD NOTHING TO DO WITH HER PREVIOUS PROBLEM SO THERE FOR THERE IS NOTHING THAT THEY CAN DO. TS

BRAKE FAILURE.

BROKEN LINE IN THE BRAKING SYSTEM RESULTED IN TOTAL LOSS OF BRAKING FUNCTION.

BROKEN LINE IN THE BRAKING SYSTEM RESULTED IN TOTAL LOSS OF BRAKING FUNCTION.

TRANSMISSION HAD TO BE REPLACED TWICE AND THERE ARE CONSTANT BRAKE PROBLEMS THAT SEEM TO BE UNREPAIRABLE.

BRAKES PADS WERE REPLACED AND THE ROTORS WERE TURNED. BRAKES OPERATED NORMALLY FOR APPROXIMATELY 4 MONTHS, THEN INTERMITTENT GRINDING NOISES WERE HEARD. VEHICLE WAS TAKEN IN FOR REPAIR OF NOISE PROBLEM AND MECHANICS SAID EVERYTHING WAS WORKING PROPERLY AND THE NOISE WAS NORMAL. THE BRAKES THEN FAILED WHEN ATTEMPTING TO MAKE AN ABRUPT STOP AND A MAJOR CRASH OCCURED.

WHEN APPLYING THE ABS BRAKES THE PEDAL WILL TRAVEL TO THE FLOOR, CAUSING EXTEN *AK

BRAKE FLUID RESERVOIR CONTINUALLY NEEDS TO BE REFILLED. FRONT PADS REPLACED TWICE AND RIGHT FRONT ROTOR REPLACED ONCE.

INTERMITTENT BRAKE FAILURE, CANNOT DUPLICATE TO DETERMINE CAUSE.

WHEN APPLYING THE ABS BRAKES THE PEDAL WILL FADE CAUSING EXTENDED STOPPING DISTANCE. ALSO THERE IS EXCESSIVE GRINDING, THE ROTORS WERE CUT WHICH RELIEVED SOME OF THE GRINDING. PLEASE ADD FURTHER DETAILS.