1991 FORD TAURUS Power Trainaxle Assembly Problems
13 NHTSA complaints on file
Power Trainaxle Assembly Issues in the 1991 FORD TAURUS
13 power trainaxle assembly complaints have been filed with NHTSA for the 1991 FORD TAURUS. Of these, 0 involved a crash, 0 involved a fire, and 0 resulted in injury.
13
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
All Power Trainaxle Assembly Complaints
#8010623
|
RECALL ON SUBFRAME WAS DONE IN FEBRUARY 1999, AT THIS TIME SUBFRAME IS DETACHING FROM THE BODY ON DRIVERS SIDE OF VEHICLE.*AK CONSUMER STATED THAT FRONT MOTOR MOUNT WAS REPLACED TWICE. ALSO FRONT PASSENGERS CV AXLE WAS REPLACED TWICE. *YH
#749067
|
TOTAL REPAIRS 3400.00 AT A TIME WHEN MONEY IS VERY SCARCE AS I AM RETIRED AND ON A VERY LIMITED INCOME. I EXPECTED TO MAINTAIN SMALL REPAIRS, BUT WITH TAKING CARE OF THE VEHICLE AND THE LOW MILEAGE, I BELIEVE THE AXELS/ BRAKES AND TRANSMISSION ARE VERY PREMATURE AND MAYBE THE A/C. AT 37168 MILES, THE CAR SHOULD BE RUNNING LIKE NEW.*AK
#559376
|
THE TRANS-AXLE RECALL WAS NEVER REPAIRED EVEN WHEN THE VEHICLE WAS SERVICED 3 TIMES FOR OTHER RECALLS, THE VEHICLE HAS HAD THREE RECALLS SINCE THE RECALL WAS ISSUED. NLM *JB
#836069
|
FRONT AXLES HAVE A RUBBER CUP ON THEM WHICH WEARS OUT AND BREAKS, DIRT ACCUMULATES AND VEHICLE WILL GO INTO NEUTRAL AND THERE WOULD BE NO CONTROL. DEALER NOT CONTACTED, AND PROBLEM STILL EXISTS. *AK
#836894
|
CONSUMER WAS DRIVING APPROXIMATELY 15MPH WHEN VEHICLE LOST POWER, VEHICLE WOULD NOT MOVE, ALTHOUGH THE ENGINE WAS STILL RUNNING ON AN INCLINE. THERE WAS A BULLETIN 94-M84-AX4S FOR THE TRANSAXLE CONSUMER RECEIVED A RECALL NOTICE. DEALERSHIP LOOKED AT VEHICLE, AND SAID THERE WAS NO PROBLEM, IN WARRANTY, 14.000 MILES LATER PROBLEM OCCURRED. RECALL 93V106. *AK
#835559
|
WHILE DRIVING AT 30 MPH WITHOUT PRIOR WARNING THE ENGINE HEAD GASKET BLEW OUT AND THE MOTOR MOUNTS ARE BROKE AND NEEDED TO BE REPLACED. WORN OUT FRONT AXLE, AND A/C O-RINGS LEAK. *AK
#543436
|
MOTOR MOUNTS FAILED AS WELL AS THE AXLES AS A DIRECT RESULT OF RECALL ON SUBFRAMES, CAUSING DIFFICULT STEERING.
#824455
|
HAD TAKEN VEHICLE TO DEALER. WAS INFORMED THAT MOTOR MOUNTS WERE CRACKED & BROKEN & NEEDED REPLACING. MOTOR MOUNTS NEED REPLACING AGAIN FOR SAME PROBLEM. HAD TO REPLACE AXLES, FRONT DISC BRAKES ROTORS & CV BOOTS. REPLACED ALSO, ACCORDING TO MECHANIC.
#534831
|
TRANSAXLE FAILED CAUSING SUDDEN DOWNSHIFTING.
#522699
|
TRANSMISSION FAILED PRIOR TO/AFTER MANUFACTURER'S RECALL. RECALL REPAIRS REFUSED DUE TO EXPIRATION OF WARRANTY. ALSO REPLACED TRANSAXLE. (94M84). *AK
#523449
|
AUTOMATIC TRANSMISSION REPLACED FOUR TIMES. ALSO, REPLACED TRANSAXLE. *AK
#524382
|
TRASAXLE REBUILT 4 TIMES. *AK
#959164
|
RACK AND PINION AND AXLE BROKE CAUSING FRONT WHEELS TO LOCK. TT
Other 1991 FORD TAURUS Problem Areas
Power Trainautomatic Transmission
221 complaints
Engine And Engine Coolingengine
88 complaints
Structureframe And Members
51 complaints
Steeringlinkagestie Rod Assembly
40 complaints
Engine And Engine Coolingenginegasoline
28 complaints
Air Bagsfrontal
24 complaints
Power Trainmanual Transmission
23 complaints
Air Bags
22 complaints
Equipmentapplianceair Conditioner
20 complaints
Service Brakes Hydraulicfoundation Componentsdiscrotor
19 complaints
Vehicle Speed Control
17 complaints
Service Brakes Hydraulicfoundation Components
14 complaints
Service Brakes Hydraulicfoundation Componentsdisc
14 complaints
Air Bagsfrontalsensorcontrol Module
10 complaints
Electrical Systemignition
10 complaints
Electrical Systemwiringfront Underhood
10 complaints
Engine And Engine Coolingcooling Systemradiator Assembly
10 complaints
Power Traindrivelineconstant Velocity Joint
10 complaints
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip
10 complaints
Suspensionfront
10 complaints
Tires
10 complaints
Visibilitywindshield Wiperwasher
10 complaints
Engine And Engine Coolingcooling System
9 complaints
Electrical Systemignitionswitch
8 complaints
Steeringlinkages
8 complaints
Suspension
8 complaints
Unknown Or Other
8 complaints
Wheels
8 complaints
Steeringhydraulic Power Assist System
7 complaints
Steeringrack And Pinion
7 complaints
Electrical System12v24v48v Battery
6 complaints
Seat Beltsfrontbuckle Assembly
6 complaints
Steering Steering Wheelhandle Bar
6 complaints
Electrical Systemignitionmodule
5 complaints
Exterior Lightingheadlights
5 complaints
Service Brakes Hydraulicfoundation Componentsdrum
5 complaints
Steering
5 complaints
Structurebody
5 complaints
Vehicle Speed Controlaccelerator Pedal
5 complaints
Seat Beltsfrontanchorage
4 complaints
Service Brakes Hydraulicpower Assistvacuum
4 complaints
Steeringhydraulic Power Assisthose Piping And Connections
4 complaints
Steeringhydraulic Power Assistpump
4 complaints
Electrical Systemalternatorgeneratorregulator
3 complaints
Electrical Systemstarter Assembly
3 complaints
Electrical Systemwiring
3 complaints
Electrical Systemwiringinteriorunder Dash
3 complaints
Engine And Engine Cooling
3 complaints
Engine And Engine Coolingexhaust System
3 complaints
Fuel System Gasolinedeliveryfuel Pump
3 complaints
Fuel System Gasolinedeliveryhoses Linespiping And Fittings
3 complaints
Latcheslockslinkagesdoorslatch
3 complaints
Power Train
3 complaints
Service Brakes Hydraulicfoundation Componentsdisccaliper
3 complaints
Service Brakes Hydraulicfoundation Componentsdiscpads
3 complaints
Service Brakes Hydraulicfoundation Componentsmaster Cylinder
3 complaints
Structurebodydoor
3 complaints
Suspensionfrontmacpherson Strut
3 complaints
Tirestreadbelt
3 complaints
Wheelslugsnutsboltsstuds
3 complaints
Engine And Engine Coolingexhaust Systememission Control
2 complaints
Exterior Lightingtail Lights
2 complaints
Latcheslockslinkageshatchbackliftgatelock
2 complaints
Power Trainautomatic Transmissioncooling Unit And Lines
2 complaints
Power Trainautomatic Transmissiongear Position Indication Prndl
2 complaints
Power Traindrivelinedifferential Unit
2 complaints
Seats
2 complaints
Service Brakes Hydraulicfoundation Componentsdrumdrum
2 complaints
Service Brakes Hydraulicpedals And Linkages
2 complaints
Service Brakes Hydraulicpower Assisthydraulic
2 complaints
Structure
2 complaints
Suspensionfrontstabilizer Bar
2 complaints
Tirestemporaryemergency Spare Tire
2 complaints
Vehicle Speed Controlcables
2 complaints
Vehicle Speed Controlcruise Control
2 complaints
Visibilitydefrosterdefoggerhvac System
2 complaints
Visibilitydefrosterdefoggerhvac Systemheater Core
2 complaints
Visibilityrearview Mirrorsdevicesinterior
2 complaints
Air Bagssidewindow
1 complaint
Child Seat
1 complaint
Electrical System
1 complaint
Electrical System12v24v48v Batterycables
1 complaint
Electrical Systemhorn
1 complaint
Engine And Engine Coolingcooling Systemfan
1 complaint
Engine And Engine Coolingcooling Systemhoseslinespipingfittings
1 complaint
Engine And Engine Coolingenginegasolinebelts And Associated Pulleys
1 complaint
Engine And Engine Coolingexhaust Systememission Controlgas Recirculation Valve Egr Valve
1 complaint
Equipment
1 complaint
Equipmentelectrical
1 complaint
Exterior Lighting
1 complaint
Exterior Lightingbrake Lights
1 complaint
Fuel System Gasoline
1 complaint
Fuel System Gasolinedelivery
1 complaint
Fuel System Gasolinestorageauxillary Tank
1 complaint
Fuel System Otherdeliveryhoses Linespiping And Fittings
1 complaint
Fuelpropulsion System
1 complaint
Latcheslockslinkageshoodlatch
1 complaint
Latcheslockslinkagestailgatelatch
1 complaint
Parking Brakeconventionalmechanicallinkage And Cable
1 complaint
Power Trainautomatic Transmissionlever And Linkagefloor Shift
1 complaint
Power Trainautomatic Transmissiontorque Converter
1 complaint
Power Trainclutch Assembly
1 complaint
Power Traindrivelinedriveshaft
1 complaint
Seatsfront Assemblyhead Restraint
1 complaint
Seatsfront Assemblypower Adjust
1 complaint
Service Brakes
1 complaint
Service Brakes Airantilock
1 complaint
Service Brakes Hydraulic
1 complaint
Service Brakes Hydraulicfoundation Componentshoses Linespiping And Fittings
1 complaint
Steeringhydraulic Power Assistpower Steering Fluid
1 complaint
Steeringlinkagesrodrelayconnecting
1 complaint
Structurebodydoorhinge And Attachments
1 complaint
Suspensionfrontshock Absorber
1 complaint
Suspensionfrontspringscoil Springs
1 complaint
Suspensionfrontwheel Bearing
1 complaint
Suspensionrear
1 complaint
Suspensionrearshock Absorber
1 complaint
Tiressidewall
1 complaint
Vehicle Speed Controllinkages
1 complaint
Visibility
1 complaint
Visibilitydefrosterdefoggerhvac Systemfanmotor
1 complaint
Visibilitydefrosterdefoggerhvac Systemwindshieldelectrical Heating Element
1 complaint
Visibilitypower Window Devices And Controls
1 complaint
Visibilityrear Window Wiperwasherswitchwiring
1 complaint
Visibilitywindshield
1 complaint
Visibilitywindshield Wiperwashermotor
1 complaint