2003 FORD RANGER Engine And Engine Coolingengine Problems

2003 FORD RANGER 4.0L 4WD AT. TWO OF THE SIX VALVE SEATS IN THE ENGINE DROPPED CAUSING THE ENGINE TO LOSE COMPRESSION AFTER LESS THAN 70K MILES. NOTICED LOSS OF POWER, TOOK IT IN AND HAD TO PAY OVER $2K IN REPAIRS EVEN THOUGH IT WAS STILL UNDER WARRANTY. THE VALVE SEATS WERE REPLACED. THE PROBLEM WAS FIXED BUT A FEW MONTHS LATER WHILE MERGING TO FREEWAY SPEEDS THE CAR STALLED AND WOULD NOT RE-START. TOWED IT IN TO FIND THAT THE ENGINE HAD JUMPED TIMING AND BENT ALL SIX CRANK ARMS. AGAIN, REPAIRS WERE MADE. TOP END OF THE ENGINE WAS REPLACED INCLUDING THE CRANKS. THIS IS RIDICULOUS FOR A TRUCK WITH LESS THAN $70K MILES ON. I FEEL THE ORIGINAL REPAIR COSTS UPWARDS OF $2,000.00 SHOULD HAVE BEEN COVERED UNDER THE WARRANTY AS IT WAS AN INTERNAL ENGINE ISSUE AND BEEN REIMBURSED. ALSO A NEW ENGINE SHOULD BE...

TRUCK BUCKS/JERKS DURING DRIVE CYCLE WHEN IN 3RD OR 4TH GEAR, RPM ~2500. *JB

A FAILED ROLLER ROCKER DESTROYED A CAM AND LIFTER AFTER ONLY 66,000 MILES. 3,000 MILES PREVIOUS I HAD TAKEN IT TO THE DEALER WHO SAID THEY COULDN'T HEAR THE NOISE. BY THE TIME THEY COULD HEAR IT, THE DAMAGE HAD MORE THAN TRIPLED. THE FAILURE WAS DEFINITELY CAUSED BY THE DEFECTIVE ROLLER ROCKER(THE PART IS AVAILABLE FOR INSPECTION). *NM

DT: THE CONSUMER STATED THAT HIS 2003 FORD RANGER CAUGHT ON FIRE ON 9-30-05. THE VEHICLE STARTED SMOKING WHILE IN MOTION. THE VEHICLE WAS PULLED OVER. THE FIRE WAS VIEWED COMING FROM UNDER THE HOOD. THE FIRE DEPARTMENT WAS CALLED. THE TRUCK WAS DECLARED A TOTAL LOSS. THE CONSUMER FELT THAT THE FIRE DEPARTMENT WAS UNABLE TO DETERMINE THE CAUSE OF THE FIRE. THE CONSUMER EXPERIENCED NO PRIOR PROBLEMS WITH THE VEHICLE. THE DEALER WAS MADE AWARE OF THE PROBLEM. THE CONSUMER CONTACTED HIS INSURANCE COMPANY. THE TRUCK WAS TOWED TO A JUNK YARD IN ILLINOIS. PICTURES WERE TAKEN OF THE ENGINE AND THE VEHICLE ITSELF. THE CONSUMER PLANNED TO NOTIFY THE MANUFACTURER ABOUT THE FIRE. *AK (11/22/05) A POPPING NOISE WAS COMING FROM THE ENGINE AND IT BEGUN TO LOSE POWER. THE CONSUMER POPPED THE HOOD AND SAW FIRE COMING OUT OF THE ENGINE. BY THE TIME THE FIRE...

DT: THE CONTACT OWNS A 2003 FORD RANGER. WHILE DRIVING VEHICLE STALLED. THE DEALERSHIP HAD THE VEHICLE 6 TIMES, BUT COULD NOT FIND ANYTHING WRONG WITH IT. THE CONTACT STATED THE VEHICLE STARTED JERKING THEN IT DIED, AND AFTER WAITING APPROXIMATELY 1 HOUR THE VEHICLE STARTED BACK UP. THE DEALERSHIP WANTED TO TRADE THE VEHICLE WITH THE CONTACT. BUT THE MANUFACTURER WANTED THE DEALERSHIP TO FIND THE CAUSE OF THE PROBLEM BEFORE THEY WOULD AUTHORIZE THE TRANSACTION. THE CONSUMER CONTACTED THE MANUFACTURER. *AK

WHEN THE TRANSMISSION IS ENGAGED, AUTOMATIC, ON ACCELERATION, THERE IS A CHATTERING NOISE COMING FROM THE ENGINE AREA. HAPPENS WHETHER A/C IS ON OR NOT. *NM

WHEN PLACING VEHICLE IN REVERSE, MOTOR RACED WITH FOOT ON THE BRAKES. IT WAS LATER DETERMINED BY DEALERSHIP THAT IT WAS A COMPUTER PROBLEM AND WAS REPROGRAMMED. *LA THIS REMEDIED THE PROBLEM TEMPORALLY. FAILURE HAS OCCURRED NUMEROUS TIMES SINCE THE PART REPLACEMENT. CONSUMER FELT IF FORD COULDN'T REPAIR THE VEHICLE WITHOUT IT FAILING AGAIN, THEN HIS MONEY SHOULD BE RETURNED. *PH

WHILE DRIVING VEHICLE INTERMITTENTLY STALLED. THE CAUSE OF THE PROBLEM HAD NOT BEEN DETERMINED. *AK

BRAKE AND ENGINE PROBLEMS. *MR THE ROTORS WERE TURNED ON THE FRONT BRAKES AND A IDLER WAS INSTALLED BECAUSE THE ENGINE STALLED OUT. (TWICE AFTER THAT THE VEHICLE WAS RETURNED THE VEHICLE FOR THE SAME PROBLEM) *SCC *JB