2007 FORD FUSION Tires Problems

THE DASHBOARD AROUND AIRBAG PORTION HAS COME APART AND IS RISING UP ALL THE WAY ACROSS THE DASHBOARD. PASSENGERS' SIDE THE SEAT BELT LIGHT AND SEAT BELT BUZZER GOES OFF. HAVE NOTIFIED FORD. NO COMPENSATION. DO NOT HAVE PICTURES AVAILABLE, BUT IF NEEDED WILL EMAIL THEM ASAP. THE CONSUMER STATED THERE WERE TOXIC GASES LEAKING FROM THE AIRBAG COMPARTMENT WHICH TAMPERED WITH THE ADHESIVE ON THE DASHBOARD. THE DASHBOARD BEGAN TO BUBBLE UP AROUND THE COMPARTMENT. THE SEATBELTS WOULD NOT RELEASE. THE CONSUMER'S GRANDCHILD HAD TO WRIGGLE OUT FROM UNDER THE SEAT BELT. THE SEATBELT HAD TO BE UNSCREWED FROM THE FLOOR TO RELEASE THE PRESSURE ON IT. THE INTERIOR DASHBOARD LIGHT, RADIO, CLOCK, MILEAGE, AND CD PLAYER WOULD NOT OPERATE. THE ENGINE LIGHT ILLUMINATED, THE DRIVER'S SEAT SEAMS BEGAN SEPARATING, THE BRAKES STICK, THE INTERIOR DOOR HANDLES BROKE OFF, THE REARVIEW FELL OFF WHILE DRIVING, AND THE TIRES HAD...

TL* THE CONTACT OWNS A 2007 FORD FUSION EQUIPPED WITH GOODYEAR DUNLOP SIGNATURE TIRES, SIZE 255/50/R17. THE CONTACT STATED THAT THE TIRES WERE WEARING PREMATURELY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE TIRES WERE WORKING UP TO STANDARDS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE TIRES WERE REPLACED. THE DOT NUMBER AND VIN WERE UNAVAILABLE. THE TIRE FAILURE MILEAGE WAS 18,000. THE VEHICLE FAILURE AND CURRENT MILEAGE WAS 84,000. *TR

SE V6, TIRES: WHEN I INFLATE THE TIRES TO THE PRESSURE RECOMMENDED BY FORD ON THE DOOR STICKER, THE RESULT IS RAPID TIRE WEAR ON THE OUTSIDES OF THE TIRES (UNDER INFLATED). WHEN I INFLATE THE TIRES ACCORDING TO THE TIRE MANUFACTURERS RECOMMENDATION ON THE SIDEWALL, THE TIRES DO NOT WEAR OUT ON THE OUTSIDE (UNDER INFLATED), NOR IN THE MIDDLE (OVER INFLATED). FORD RECOMMENDS A TIRE PRESSURE THAT IS 9 PSI LOWER THAN THE TIRE MANUFACTURER RECOMMENDS. APPARENTLY THEY DID NOT LEARN FROM FIRESTONE THAT THE TIRES CAN FAIL DUE TO OVERHEATING WHEN THEY ARE UNDER INFLATED, RESULTING IN BLOW OUTS AT FREEWAY SPEED AND DEATHS DUE TO THE RESULTING ACCIDENTS. NOR DID THEY CHANGE THEIR WAYS AS A RESULT OF DAMAGE AWARDS FOR LAWSUITS DUE TO UNDER INFLATED FIRESTONE TIRE FAILURES. PERHAPS THE DAMAGE AWARDS WERE TOO SMALL. *TR

TL* THE CONTACT OWNS A 2007 FORD FUSION WITH MICHELIN WEATHERWISE REAR TIRES, LINE SIZE P205/60/T16, SERIAL NUMBERS WEA28Z AND WEA28X. THE CONTACT STATED THAT THE TIRES WOULD WOBBLE EXCESSIVELY WHEN DRIVING ANY SPEED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO EXAMINED THE TIRES AND DISCOVERED THAT THE TIRE BELTS WERE FAILING AND CAUSING THE TIRES TO BECOME OUT OF ROUND. THE REAR TIRES WERE REPLACED. THE TIRE FAILURE MILEAGE WAS 19,000. THE VEHICLE FAILURE AND CURRENT MILEAGE WAS 43,379. THE VIN WAS NOT AVAILABLE.

WE OWN A 2007 FORD FUSION WITH APXM. 40 K MILES. IT WAS SOLD WITH MICHELIN TIRES THAT I BELIEVE TO BE DEFECTED AND DANGEROUS. WE HAVE JUST REPLACE THE THIRD OUT OF FOUR TIRES. EACH TIRE WAS BLOWN OUT THE SIDEWALL. I HAVE CONTACTED FORD AND MICHELIN AND GOTTEN NO HELP WITH THE REPLACEMENT OF THESE TIRE FROM EITHER. I HAVE READ ON OTHER WEBSITE COMPLAINTS ABOUT THESE SAME TIRES. SOMETHING NEEDS TO BE DONE BEFORE SOMEBODY DIES FROM THIS. *TR

IN FEB 2008 I BOUGHT A NEW 2007 FORD FUSION. THE PROBLEM I'M HAVING IS WITH MICHELIN TIRES (225/50R17). THREE OF THE FOUR TIRES HAVE DEVELOPED BUBBLES AND HAD TO BE REPLACED WITHIN THE PAST YEAR. THE FIRST WAS JULY 19, 2009, THE SECOND WAS JULY 2, 2010 AND THE THIRD WAS AUGUST 4, 2010. I CONTACTED MICHELIN WHO GAVE ME THE RUN-AROUND BUT NO SOLUTION. I TOOK THE LAST TIRE TO A MICHELIN DEALER AND WAS TOLD THAT MICHELIN WOULDN'T GIVE ME ANYTHING BECAUSE AN AUTHORIZED DEALER DIDN'T REPLACE THE TIRE. HOW CAN I GO AROUND FINDING A PARTICULAR DEALER WHEN I'M SETTING ON THE INTERSTATE WITH A FLAT TIRE? I WENT TO THE FIRST PLACE I FOUND WHO COULD REPLACE THE TIRE. EACH TIME I WAS OUT OF TOWN WHEN THE FAILURE HAPPENED, THE FIRST TWO TIMES I WAS EVER OUT OF STATE SO IT'S NOT LIKE BEING...

OUR 20 YEAR OLD SON WAS DRIVING HOME FROM COLLEGE WHEN HIS LEFT FRONT TIRE BLEW OUT. HE WAS ABLE TO MAINTAIN CONTROL AND GET TO THE SIDE OF THE ROAD AND CALL ROADSIDE ASSISTANCE. THE RIM WAS DAMAGED IN THE PROCESS. AFTER ORDERING A NEW RIM AND WHEEL, I WAS GOING TO DRIVE IT TO THE DEALERSHIP WHEN WE NOTICED THAT THE LEFT REAR TIRE WAS NOW FLAT. ONCE WE WERE ABLE TO GET ENOUGH AIR IN IT TO DRIVE TO THE DEALERSHIP, WE DID. AT THE DEALERSHIP IT WAS DISCOVERED THAT ALL THE VALVE STEMS WERE EITHER CRACKED OR LEAKING, SO THEY ALL HAD TO BE REPLACED. WE WERE UNAWARE THAT THE 2007 FORDS HAD FAULTY VALVE STEMS, HAD WE KNOWN THIS, WE WOULD HAVE REPLACED THEM FOR SAFETY CONCERNS. WE WERE LUCKY, ONLY ONE VALVE STEM BROKE WHILE OUR SON WAS DRIVING AND HE MAINTAINED CONTROL, THE...

TL*THE CONTACT OWNS 2007 FORD FUSION EQUIPPED WITH CONTINENTAL CONTI PRO CONTACT P205/60R16 TIRES. THE CONTACT STATED THAT SHE NOTICED A BUBBLE ON THE SIDE WALL OF THE FRONT PASSENGER SIDE TIRE. THE VEHICLE WAS TAKEN TO A TIRE CENTER AND THE FAILED TIRE WAS REPLACED WITH A TIRE OF A DIFFERENT MAKE. THE TIRES WERE ROTATED FREQUENTLY TO REDUCE THE RISK OF FAILURE BUT THE FAILURE WOULD STILL OCCUR INTERMITTENTLY TO THREE OUT OF THE FOUR ORIGINAL TIRES. EACH TIME THE FAILED TIRE WAS REPLACED WITH A TIRE OF A DIFFERENT MAKE. ONLY THE CONTINENTAL TIRES EXPERIENCED THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 26,000. THE CURRENT MILEAGE WAS APPROXIMATELY 37,500.

WE HAVE A 2007 FORD FUSION. SINCE JANUARY 1ST WE HAVE HAD 4 TIRE FAILURES, OR SO WE THOUGHT. THE PROBLEM SEEMS TO BE FAULTY CHINESE VALVE STEMS. EACH TIME. IT WAS AN IMMEDIATE LOSS OF AIR. FIRST THREE REPLACED AT FORD DEALERS, WHO MADE NO COMMENT ABOUT THE INVESTIGATION. THE FOURTH AT A TIRE STORE WHO'S MECHANIC EXPLAINED TO ME WHAT WAS REALLY GOING ON. OUR PROBLEMS BEGAN ON JAN. 1ST AND CONTINUED UNTIL MAY 23RD,APPROX. ONE EVERY 6 WEEKS! *TR

07 FORD FUSION REQUIRED TWO LEAKING STEMS TO BE REPLACED SINCE JAN 09. 4/6/09 TRAVELING ON I-4 OUTSIDE OF TAMPA AT 70 MPH WHEN THE RIGHT FRONT TIRE WENT FLAT, NO POP OR ANYTHING, JUST NOTICED A CHANGE IN THE ROAD NOISE SO I TOUCHED THE BREAK AND IT GOT LOUDER. I DID NOT LOSE CONTROL OF THE VEHICLE AND GOT SAFELY TO THE BREAKDOWN LANE WHEN THE TREAD PART OF WHEEL CONTINUED TO ROLL/BOUNCE DOWN THE BREAKDOWN LANE. A ROAD RANGER STOPPED AND CHANGED MY TIRE FOR ME, ASKED WHERE I WAS GOING AND TOLD ME TO BUY A NEW TIRE. PURCHASED NEW TIRE FOR $278 FROM A FORD DEALER WHO TOLD ME TO CONTACT TIRE MANUFACTURER FOR WARRANTY. THERE ARE NO OBVIOUS PUNCTURES IN THE TREAD, IMPOSSIBLE TO TELL IF ANY DAMAGE TO THE SIDEWALL AS THERE WASN'T MUCH LEFT ON THE RIM AND COULDN'T TELL ON THE...

ON 3/18/09, I HAD A TIRE FAIL ON MY 2007 FORD FUSION BECAUSE OF A RE-CALLED DILL # 414 VALVE STEM. I HAD TO REPLACE THE MICHELIN TIRE THAT HAD 10,487 MILES ON IT. I ALSO REPLACED THE OTHER THREE VALVE STEMS THAT WERE CRACKED (ALSO DILL #414). I AM SIX WEEKS AWAY FROM TRAVELING FROM MICHIGAN TO FLORIDA AT INTERSTATE SPEEDS OF 70 MPH. IF THIS TIRE HAD FAILED AT THOSE SPEEDS, I DON'T THINK I WOULD HAVE BEEN ABLE TO CONTROL MY VEHICLE TO A SAFE STOP. FORD MOTOR CO. (GORNO FORD DEALERSHIP IN WOODHAVEN, MI.) HAS NO INFORMATION ABOUT THIS PROBLEM. WHEN I CALLED TECH INTERNATIONAL (CLAY JOHNSON AT 740-967-9015), HE SAID THAT FORD MOTOR CO. DEARBORN IS WELL AWARE OF THIS PROBLEM. THIS IS A SERIOUS SAFETY PROBLEM THAT COULD HAVE RESULTED IN A FATAL INJURY. I HAVE THE DEFECTIVE VALVE STEMS IN MY CUSTODY. *TR

I HAVE AN INCIDENT TO REPORT RELATED TO PE08060. AFTER GETTING MY TIRES ROTATED I HAD A FLAT THE NEXT DAY. THE CAUSE WAS A BAD VALVE STEM. SINCE I HAD READ A NEWS ARTICLE ABOUT THIS POTENTIAL PROBLEM I HAD ALL 4 REPLACED. 2 OF THE STEMS HAVE CRACKING SIMILAR TO THAT DESCRIBED IN THE ARTICLE. THE PART IS TR414. *TR

ON 11-12-08 I PARKED MY 20007 FORD FUSION IN THE GARAGE AT 7:00 PM . ON THE MORNING OF 11-13 08 AT 6;00 AM THE FRONT RIGHT TIRE WAS FLAT. I CHANGED THE TIRE AND TOOK IT TO THE FORD DEALER FOR REPAIR. THEY FOUND THAT THE VALVE STEM WAS DEFECTIVE AND REPLACED SAME. I FEEL THIS SHOULD NOT HAVE HAPPENED AS THE TIRES WERE PROPERLY INFLATED. WHEN I INQUIRED IF THIS WAS COVERED BY WARRANTY, I WAS TOLD IT WASN'T. THE VEHICLE IS STILL UNDER WARRANTY.

TOTAL TREAD SEPARATION ON LEFT FRONT TIRE CAUSING BLOWOUT @ HIGHWAY SPEED HAD TO DRIVE ON RIM TO GET TO SAFE AREA TO REPLACE DESTROYED TIRE WITH SPARE. *TR

DECREASED TIRE INFLATION WHICH HAS ED TO THE REPLACEMENT OF TWO OF MY TIRES. *TR

A VALVE STEM ON MY 2007 FORD FUSION LEAKED AND NEED TO BE REPLACED. *TR

I HAD A FLAT TIRE AND WHEN I GOT IT REPAIRED WAS TOLD IT WAS A VALVE STEM...MY CAR ONLY HAS 17,000 MILES ON IT AND WAS TOLD THIS SHOULD NOT HAVE HAPPENED...2 DAYS LATER, ANOTHER FLAT TIRE ON A DIFFERENT TIRE WHILE I WAS DRIVING TO WORK...I STOPPED AND GOT A CAN OF 'FIX-A-FLAT- AND WHEN PUTTING IT IN THE TIRE, NOTICED IT WAS LEAKING AT THE VALVE STEM...I HAD 8 MORE MILES TO DRIVE TO WORK...TO MAKE A LONG STORY SHORT, I HAD TO REPLACE THE TIRE DUE TO A SIDE WALL BUBBLE FROM DRIVING IT WITHOUT PROPER INFLATION. *TR

SUDDEN DEFLATION AND SIDEWALL SEPARATION OF A TIRE SIDEWALL. VEHICLE E MODEL 2007 FORD FUSION SEL, 4CYL, TIRE MICHELIN PILOT SPORT MXM4 ALL SEASON 225/50VR17 93V 10500 MILES TOTAL ON VEHICLE AND TIRES. RIGHT FRONT TIRE EXPERIENCES A SUDDEN DEFLATION WHILE DRIVING ON A CITY STREET AT ROUGHLY 25-30 MPH. THE VEHICLE WAS STOPPED AND THE TIRE REMOVED. THE OUTER SIDEWALL OF THE TIRE WAS FULLY SEPARATED AND THE SIDEWALL CORD STRUCTURE WAS SEPARATED AS WELL. THE VEHICLE WHEEL RIM WAS UNDAMAGED ON THE OUTER AND INNER FACES. THE TIRES HAD BEEN CHECKED RECENTLY FOR PROPER INFLATION AND WERE IN GOOD CONDITION. AN INSPECTION OF THE TREAD AREA DID NOT SHOW ANY SIGNS OF PUNCTURE THAT WOULD FACILITATE RAPID DEFLATION. THE VEHICLE HAS BEEN USED ON PAVED STREETS ALMOST EXCLUSIVELY AND THE STREETS IN THE AREAS OF USE ARE IN REASONABLY GOOD CONDITION. NO DAMAGE TO THE VEHICLE IS APPARENT...

VEHICLE PULLS TO THE RIGHT, BRAKES ARE WORKING CORRECTLY WINDOWS ARE BEGINNING TO MOLD, CD HAS EATEN UP CD'S, TIRES DO NOT GRIP ROAD WELL. *TR