2010 FORD FOCUS Engine And Engine Cooling Problems

I TOOK THE VEHICLE IN FOR ITS 60K SERVICE AT APPROX 62K. ALL WAS OK. ABOUT 2 DAYS LATER I NOTICED A FUNNY SMELL IN THE CABIN. I PUT IT DOWN TO WHATEVER CHEMICALS THEY USED ON THE 60K SERVICE. ABOUT 3 DAYS LATER THE SMELL WAS GETTING WORSE, BUT ALSO THE AC WASN'T COOLING LIKE IT USED TO AND MY THEN 9 YEAR OLD DAUGHTER PASSED OUT IN THE CAR BECAUSE OF THE SMELL. I TOOK IT TO FORD AS THE INCIDENT HAPPENED STRAIGHT AFTER THE SERVICE AND THEY SAID NOTHING THEY DID WOULD HAVE CAUSED IT, BUT IT LOOKED LIKE THE AC CORE AND THE SMELL WAS PAG OIL. I TOOK THE CAR TO ANOTHER GARAGE AND THEY SAID THERE WAS NO FREON IN THE AC SYSTEM. THEY RECHARGED THE SYSTEM AFTER CHECKING FOR LEAKS AND NOT FINDING ANY. A WEEK LATER (TWO WEEKS AFTER THE INITIAL SERVICE)...

I TOOK THE CAR IN FOR THE 120K SERVICE. THE SERVICE WAS COMPLETED. A WEEK LATER I TOOK THE CAR BACK AND ASKED THEM THE CHECK A YELLOW CRUSTING UNDER THE DASHBOARD IN THE FRONT PASSENGER FOOTWELL. THEY DID AND SAID THEY DID NOT KNOW WHAT IT WAS OR WHAT WOULD CAUSE IT. A WEEK LATER WE NOTICED A SMELL IN THE CABIN. THE CAR WAS NOW 3 YEARS OLD AND WE HAD A SIMILAR SMELL 18 MONTHS PRIOR THAT COST US $1800 TO REPLACE THE AC CORE. SURELY THIS COULD NOT BE ANOTHER AC CORE PROBLEM. I TOOK THE CAR BACK TO THEM AND THEY FOUND NOTHING WRONG...EVEN THE SMELL HAD GONE. I TOOK THE CAR AND ON THE WAY HOME I NOTICED THE CAR WAS BEGINNING TO OVERHEAT...FORD WAS ALREADY CLOSED. I PULLED OVER AND CHECKED THE RADIATOR. I TOPPED IT UP AND IT TOOK A GALLON OF...

NOT PROVIDED BY FORD CABIN AIR FILTER BENEFITS A CABIN AIR FILTER IS AN AIR PURIFICATION FILTER, SOMETIMES CALLED A ?MICRO CABIN AIR FILTER? OR "IN-CABIN MICROFILTER,"DESIGNED TO REMOVE THE MICROSCOPIC DUST, ALLERGENS, POLLUTANTS AND OTHER PARTICLES THAT COME INTO THE PASSENGER CABIN OF YOUR VEHICLE THROUGH ITS AIR VENTS. IN ADDITION TO MAKING THE AIR IN THE INTERIOR OF YOUR CAR UNPLEASANT AND UNHEALTHY, A DIRTY CABIN AIR FILTER, CLOGGED WITH DIRT, DUST, SMELLY MOLD AND ALLERGENS, CAN ALSO IMPACT THE PERFORMANCE OF YOUR DEFROSTER, HEATING AND AC, AND HEALTH HAZARDS. *TR

WOULD LOSE RPM'S AT IDLE AND ALMOST STALL. WENT TO DEALERSHIP (NO HELP), COULD FIND NOTHING WRONG BECAUSE NO CODES, EVEN THOUGH ENGINE WAS STILL IDLING RUFF FOR THEM. DEALERSHIP WAS NOT HAPPY THAT I BROUGHT THE CAR IN BEFORE 50,000 MILES, STATING I SHOULDN'T NEED TUNE-UP TIL THIS MILEAGE. WENT TO A LOCAL MECHANIC (CERTIFIED) WHO COULDN'T FIND ANYTHING, AGAIN NO CODES. THE PROBLEM CONTINUES TO DATE. GOING TO MECHANIC FOR IDLE SENSOR REPLACEMENT, HOPING THIS WILL HELP. *TR

TL* THE CONTACT OWNS A 2010 FORD FOCUS. THE CONTACT STATED THAT ANOTHER VEHICLE CRASHED INTO THE SIDE OF THE VEHICLE. THE AIR BAGS DID DEPLOY AND THE CONTACT SUSTAINED MINOR INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE COULD NOT BE SHUT OFF NOR SHIFTED INTO PARK FOLLOWING THE CRASH. THE VEHICLE WAS TOWED BY THE CONTACT'S INSURANCE COMPANY WHO RULED THE VEHICLE AS DESTROYED. THE CONTACT WAS INFORMED THAT THE IGNITION WIRES HAD TO BE CUT TO SHUT THE VEHICLE OFF. THE FAILURE AND THE CURRENT MILEAGE WAS 43,648.

THE INCIDENT OCCURRED ON 9/1/2011 AT ABOUT 3:00 PM. TRAFFIC WAS LIGHT AND WEATHER WAS DRY AND SUNNY. WE HAD BEEN DRIVING ABOUT 3 TO 4 HOURS WHEN THE PROBLEM BEGAN. WHILE DRIVING THE POSTED SPEED LIMIT IN OHIO ON I-75 SOUTHBOUND JUST SOUTH OF MILE MARKER 99 THE CAR STARTED BEHAVING LIKE I WAS OUT OF GAS EVEN THOUGH I HAD AT LEAST A HALF TANK LEFT. IT STARTED TO STALL AS I PULLED IT TO THE SHOULDER OF THE ROAD. AS I GOT IT STOPPED I NOTICED SMOKE/STEAM COMING FROM UNDER THE HOOD. I ATTEMPTED TO OPEN THE HOOD LATCH INSIDE THE CAR BUT WAS UNABLE TO. MY WIFE AND I EXITED THE CAR AND WENT TO THE FRONT WHERE SHE NOTICED IT WAS ON FIRE. WE IMMEDIATELY CALLED 911 FOR HELP. THE FIRE DEPARTMENT AND OHIO STATE TROOPERS ARRIVED AND ATTEMPTED TO PUT THE FIRE OUT. THE...

TL*THE CONTACT OWNS A 2010 FORD FOCUS. THE CONTACT STATED THAT WHEN SHE REAR ENDED THE TRUCK IN FRONT HER, THE ENGINE BEGAN SMOKING. THE VEHICLE CAUGHT FIRE AND WAS DESTROYED. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNAVAILABLE WHEN THE COMPLAINT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE UNKNOWN.

INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) I AM WONDERING WHAT ACTION I CAN TAKE NEXT. I OWN A BRAND NEW 2010 FORD FOCUS PURCHASED IN FEB 2010. THE CAR HAS A TERRIBLE SMELL ON THE INSIDE, I HAVE TAKEN IT BACK TO THE DEALER WHERE I PURCHASED IT AND ALL THEY DID WAS SPRAY SOMETHING IN THE CAR AND SEND US HOME. THE SMELL IS SO BAD THAT ALL I CAN DO IS BACK THE CAR OUT OF MY GARAGE OPEN THE DOORS AND WINDOWS AND AFTER DOING THAT FOR SEVERAL HOURS A DAY I DRIVE IT BACK INTO MY GARAGE TO SIT. I CAN'T DRIVE MY BRAND NEW FORD ANYWHERE BECAUSE I GET SO SICK FROM THE SMELL. I HAVE CONTACTED THE FORD MOTOR COMPANY ABOUT MY PROBLEM AND THEY SENT ME TO TOUSLEY FORD. TOUSLEY HAD MY VEHICLE FOR A FEW...