2017 FORD F-350 SD Engine Problems

Driving uphill at approx 20mph near my home. Loud bang/explosion from engine or front driver-side wheel well. Red alarm flashed on instrument cluster (something like “Front Brake Failure”) and strong odor of fuel or exhaust entered cab. I immediately pulled into a pullout and put vehicle in park when I noticed flames coming from the engine compartment through the gaps in hood and wheel well. I splashed a small amount of water on the driver side front tire, but the fire continued to grow. I backed away to a safe distance and called 911. Within 5 minutes, the entire engine compartment was on fire and I captured on video explosions as the fire raged Local fire department arrived within 15 minutes, but the entire engine and cab had already been destroyed by fire. Had I been driving at high speed or with passengers, this incident could have resulted in serious...

I have a 2017 F-350 SuperDuty with the Engine Block Heater option, two recalls have been issued related to a condition that can cause overheating of the power cord with the possibility of a fire. Recall 18V-894 and 19V-278 have both been applied and verified by Ford Customer Service. During the recent cold weather in the Houston, Texas area, the engine block heater was used to keep the engine warm to assist with starting. When I disconnected the power cord the was hot enough to have melted the plug to the point where the blades in the plug were loose and I had to use gloves to separate the engine heater cord from the extension cord. This should have been fixed under one or both of the previous recalls. It represents an electrical hazard that could lead to fire and loss of property. I asked Ford to remedy the situation...

The contact owns a 2017 Ford F-350 SD. The contact stated while driving 65 MPH, the contact drove over and object on the road and the check engine warning light and several other unknown warning lights illuminated. The contact stated that the vehicle was losing motive power. The accelerator pedal was depressed; however, the vehicle failed to respond as needed. The contact stated that the engine seized. The contact was able to coast to the side of the road. The contact attempted to restart the vehicle several times; however, the vehicle failed to restart. The vehicle was towed to the residence. A mechanic arrived at the residence and diagnosed the vehicle with high-pressure and low-pressure fuel pump failures due to the metal shavings inside the fuel rail and fuel injectors. Additionally, the EGR valve was damaged. The contact was advised that the entire fuel system needed to be replaced. The...

Engine Shuts Off Upon Acceleration on the onramp to a interstate highway causing the Ford f350SD, 6.7L Diesel to come to a stop in the outside lane of Interstate I81. Engine Shutdown happened again on a 2 lane highway while passing a slow farm tractor. The problem has been confirmed by Harrisonburg Ford, Harrisonburg, VA. The high pressure fuel pump is causing metal to be distributed throughout fuel system. The complete contaminated fuel system is required to be replaced by a High Pressure Fuel Pump KIT, which the Dealer ordered against the workorder for my truck. For over a month now, My truck is parked in the dealer storage and stating they are waiting on approval to start repair. Note I have Ford's Extended Warranty. I've read online that many other owners of 6.7L Diesel trucks are having the same problems. I my opinion, a RECALL is certainly justified for...

During recent oil change at a Ford dealership, Ford warned of an Oil Leaknon the “Upper Oil Pan” that could cause a fire and total loss. This problem was due to the improper installation of a gasket sealant at the time of manufacture. 2020 variants of the same vehicle saw the silicone gasket previously being used replaced be a conventional gasket which has rectified the issues being experienced by these models. These affected vehicles could pose a major risk not only the owners but to other motorists in the event a fire spontaneously ignites. They should be recalled and a conventional gasket (as has been implemented by Ford themselves) installed.

Engine had 77K miles on it and began knocking while towing a 5th wheel trailer. Took vehicle to diesel mechanic and was informed of rod bearing issues with the 6.7 powerstroke diesel. The entire long block had to be replaced due to poor design issues which were corrected with he new long block. Vehicle was out of the warranty period despite only have 77K miles on the engine and all maintenance was up to date.

2017 Ford F350 Superduty 6.7L diesel will intermittently surge/buck while towing uphill under load causing loss of power and creating unsafe driving situation. When it happens I’ve also observed electrical power loss to OBD-II port where I have accessory guage installed to monitor critical truck systems like oil temp, trans temp, coolant temp, etc.. No DTC or fault codes are generated when this happens. I haven’t taken to dealer yet but I’ve researched and read lots of truck forums where multiple Ford owners have had the same issue. When they’ve taken their truck to the dealer they’ve been told this is “normal”. I don’t agree and believe this is a serious safety issue to a consumer that suddenly loses all power and must let off all acceleration while other cars are following/around vehicle when vehicle surges. This has now happened four different times and various speeds (30-60 mph).