2011 FORD F-350 SD Fuelpropulsion System Problems

A FUEL INJECTOR CLAMP BROKE LEADING TO RAW FUEL POURING DOWN THE SIDE OF THE MOTOR AS WELL AS VAPORIZED FUEL SPRAYING AROUND THE TOP OF THE MOTOR. AFTER ORDERING THE REPLACEMENT CLAMP I REALIZED THEY HAVE CHANGED THE DESIGN FROM A PIECE OF CAST METAL TO STAMPED STEEL ( MUCH STRONGER). IF THE FUEL IGNITED IT COULD BE CATASTROPHIC. LUCKILY THE CLAMP BROKE IN MY DRIVE WAY AND NOT WHILE TOWING A HEAVY LOAD. THIS COULD LEAD TO THE VEHICLE SHUTTING DOWN OR WORSE CATCHING FIRE. ENCLOSE FIND PICTURES OF THE BROKEN CLAMP AND THE REDESIGNED NEW CLAMP. THERE ARE 7 MORE CLAMPS ON THIS MOTOR WAITING TO FAIL. THIS VEHICLE ONLY HAS 57,000 MILES ON IT AND HAS NEVER BEEN ABUSED.

TL* THE CONTACT OWNS A 2011 FORD F-350 SUPER DUTY THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A SUDDEN LOSS OF POWER AND STALLED INTERMITTENTLY. THE WARNING INDICATOR FOR THE EXHAUST FLUID ILLUMINATED, WHICH MEANT THE FLUID WAS LOW. THE CONTACT WAS UNABLE TO DETERMINE THE CAUSE OF THE INTERNAL FAILURE AND STALLING. THE DEALER (PARAMOUNT FORD HYUNDAI OF VALDESE 101 MALCOLM BLVD, VALDESE, NC 28690 (828) 338-9348) DIAGNOSED THAT THE ECM NEEDED TO BE REPLACED OR THE INCORRECT FUEL MAY HAVE BEEN USED. THE DEALER WAS UNABLE TO DUPLICATE AND DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 64,000. UPDATED 07/18/17*LJ *JS

WE WERE TRAVELING ON US23 IN WISE VIRGINIA, DOWN A MOUNTAIN. A SIGNAL AT THE BOTTOM TURNED RED; WHEN MY HUSBAND APPLIED THE BRAKES, THE ENGINE EXPERIENCED TOTAL FAILURE. THERE WAS NO ADVANCE INDICATION FROM THE VEHICLE SAFETY SYSTEM THAT ANYTHING WAS WRONG. WITH NO ENGINE POWER, MY HUSBAND HAD NO BRAKES OR POWER STEERING TO CONTROL THE VEHICLE. DUE TO DRIVER SKILL AND LUCK, WE WERE ABLE TO BRING THE VEHICLE TO A SAFE STOP. THE VEHICLE IS NOW AT FREEDOM FORD IN WISE, AND THEIR TECHNICIAN SAYS THE FAILURE WAS DUE TO EXCESSIVE WATER IN THE FUEL, AND THE FUEL SYSTEM IS CONTAMINATED AND NEEDS TO BE COMPLETELY REPLACED. THIS INDICATES TO- VARIOUS OUTSIDE MECHANICS- THAT THE WATER AND FUEL SEPARATOR WASN'T WORKING; THUS ALLOWING THE ENGINE TO BECOME OVERWHELMED. THIS SUGGESTS FAULTY PARTS- A FAULTY SEPARATOR-WHICH SHOULD BE COVERED UNDER OUR WARRANTY. HOWEVER, FORD IS CLAIMING THAT...

TL* THE CONTACT OWNS A 2011 FORD F-350 SD. WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE CHECK VALVE IN THE FUEL TANK FRACTURED, WHICH CAUSE A BLOCKAGE IN THE FUEL SYSTEM. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 210,000.