1999 FORD F-350 SD Electrical System Problems

I HAVE A 1999 F350 SUPER DUTY DIESEL WITH A 7.3 ENGINE AND MY INSIDE LIGHT DO NOT WORK RIGHT SOME TIMES IT WILL JUST COME ON AS YOU ARE DRIVING DOWN THE STREET AND SOME TIMES IT WONT COME ON WHEN YOU OPEN THE DOOR .THE INSIDE LIGHT IS GETTING WORSE MY TRUCK WOULD JUST STOP RUNNING AS YOU ARE DRIVING DOWN THE STREET OR AT A STOP LIGHT. I WENT INTO THE FUSE BOX UNDER THE STEERING WHEEL AND I THOUGHT IT COULD BE A FUSE COME TO FINE OUT THAT MY RELAY FUSE TO THE INSIDE LIGHT WAS SO HOT THAT IT COULD HAVE STARTED A FIRE SO I PULLED IT OUT NOW I DRIVE AROUND WITH NO INSIDE LIGHTING. *TR

AUTO PART PUT ON ORDER BUT SEEMS FORD MOTOR COMPANY KNOWS PROBLEM EXISTED WITH MANY OTHER TRANSMISSIONS YET IT SEEMS TECH'S AT AUTO DEALERS ARE SOME HOW NOT AWARE OF PROBLEM IN TECH ORDERS THAT SHOULD BE ISSUED. THE PART IS HARD TO GET AS IT'S ON BACK ORDERS. THE PART NUMBER IS(CLUSTER GEARS FOR SPEEDOMETERS THAT GO INTO TRANSMISSIONS)XC3Z*10849*YA INSTRUMENT CLUSTER WITH 7543 AGC-20AMP GLASS FUSE.THE DEALERS ARE CHARGING CUSTOMERS A TOTAL OF $610.18 FOR THE REPAIR. WHEN THIS PART FAILS THE SPEEDOMETER STOPS OPERATING V10TRANSMISSIONS *TR

THE BATTERIES ON MY 1999 F350 CREW CAB DUALLY WITH A 7.3 DIESEL WENT DEAD. WHEN I TRIED TO CHARGE THE BATTERIES THE CHARGER SHOWED AN EXTREMELY HIGH DRAW. I HEARD A SOLENOID CLICKING UNDER THE DRIVERS SIDE BATTERY AND THE RADIO WOULD TURN ON AND OFF. I ALSO NOTICED THAT MY HEATER CONTROL WOULD WORK EVEN WITH THE KEY OFF. AFTER TAKING TO THE LOCAL FORD DEALER I WAS TOLD THAT THE WINDSHIELD WAS LEAKING AND WATER HAD DAMAGED THE GEM MODULE AND THE FUSE BLOCK. REPAIR COST TO REPLACE THE GEM MODULE, FUSE BLOCK AND SEAL THE LEAKING AREA WAS $1063.01. WHEN CHECKING THE INTERNET TO SEE WHAT THE GEM MODULE CONTROLLED I FIND THAT THE WATER LEAK IS A KNOW PROBLEM DUE TO A SKIP OR VOID IN THE PRODUCTION SEALER. ACCORDING TO THE FORUMS I HAVE READ THERE ARE MANY MANY TRUCKS WITH THIS SAME PROBLEM....

TWO FAILURES OF CAM POSITION SENSOR CASUSED ME TO BE STRANDED TWICE UNTIL THE PART WAS REPLACED. *AK

THE VEHICLE SUDDENLY LOST ACCELERATING POWER, THEN LOST ALL POWER, BRAKES AND STEERING. I WAS ABLE TO PULL OVER WITH NO PROBLEMS. NEW CAM SENSOR SOLVED PROBLEM. *JB

1999 FORD F-350. PARKED IN DRIVEWAY. FIRE IN THE ENGINE COMPARTMENT. SOURCE APPEARS TO BE JUST BEHIND THE AIR FILTER BOX IN THE AREA OF THE MASTER CYLINDER. MOST OF THE ELECTRICAL HARNESS DESTROYED. DRIVER SIDE BATTERY MELTED DOWN. DENVER FIRE HAD TO RESPOND TO PUT OUT THE FIRE. I WAS NEVER NOTIFIED OF A RECALL AND THIS VEHICLE HAS BEEN SERVICED AT LEAST TWICE BY THE LOCAL FORD DEALERSHIP. *JB