1991 FORD EXPLORER Unknown Or Other Problems

15 NHTSA complaints on file

Check any vehicle history by VIN - Free vehicle history report

Unknown Or Other Issues in the 1991 FORD EXPLORER

15 unknown or other complaints have been filed with NHTSA for the 1991 FORD EXPLORER. Of these, 0 involved a crash, 0 involved a fire, and 0 resulted in injury.

Complaints

Crashes

Fires

Injuries

Deaths

All Unknown Or Other Complaints

#10165313 | August 12, 2006

I HAVE CONTACTED THE LOCAL DEALERSHIP IE.. HANSEL FORD AND CURTIS FORD. THE SERVICE DEPARTMENT STATED THAT SINCE MY VEHICLE (1991) FORD EXPLORER WAS OVER 10 YEARS. OLD THEY NO LONGER HAD ANY INFORMATION ON RECALLED PARTS OR RECALLED PAINT ECT. PLEASE MAIL OR E-MAIL ME A COMPLETET LIST OF ALL RECALLS 1991 FORD EXLPORER. *JB

#889069 | May 24, 2001

WHILE TRAVELING AT APPROXIMATELY 60 MPH FACTORY INSTALLED LUGGAGE RACK ON TOP OF VEHICLE BROKE, AND PIECES OF RACK FLEW OFF WITH 6 FOOT LADDER THAT WAS ON RACK. THERE WAS NO CRASH OR DAMAGE RESULTING FROM THIS TO OTHER VEHICLES. *AK *SLC

#875372 | November 21, 2000

WHILE DRIVING ENGINE WOULD SUDDENLY STALL OUT. WOULD HAVE NO WARNING. WOULD HAPPEN AT ANY SPEED. ENGINE LIGHT WOULD FLASH ON/OFF. TOOK VEHICLE TO DEALERSHIP & WAS INFORMED BY MECHANIC IT WAS MASS AIR FLOW WAS CAUSING A SHORT IN ENGINE LIGHT. PROBLEM WAS INTERMITTENT. *AK

#733812 | October 23, 2000

NO SUMMARY

#728309 | September 20, 2000

NO SUMMARY

#728972 | September 5, 2000

PAINT FLAKING OFF OF TOP AND HOOD - COMMON AMONG FORD EXPLORERS - FORD KNEW OF PROBLEM IN 1991 WHEN THEY ISSUED A SERVICE BULLETIN 91-18

#729318 | September 5, 2000

NO SUMMARY

#726054 | August 22, 2000

THE EXTERIOR PAINT HAS NOT WORN OFF IN A NORMAL FASHION. IT HAS FALLEN OFF IN LARGE (AVERAGE 3-INCH DIAMETER) CHUNKS, LEAVING BEHIND UNSIGHTLY SPOTS OF EXPOSED (AND THEREFORE RUSTED) METAL FRAME. THIS EXTREME AND STRANGE WEATHERING PROCESS WAS NOT CAUSED BY SOME EXTREME CLIMATIC CONDITIONS BUT MAY HAVE HAPPENED BECAUSE OF A POOR PAINT JOB OR LOW QUALITY PAINT. NOSAFETY DEFECT MENTIONED IN SUMMARY. *AK

#712959 | October 7, 1999

THE PAINT IS VERY FADED ON ALL AREAS OF THE VEHICLE. I WAS TOLD BY A AUTO BODY REPAIRMAN THAT THIS COULD BE ELIGIBLE FOR A NEW BODY PAINT REPAIR IF IT IS IN THE RECALL CATEGORY.

#712624 | October 1, 1999

THE PAINT ON THE TOP OF THE ROOF AND THE HOOD HAS BEEN FLAKING OFF SINCE 1995. IT HAS BECOME MORE NOTIEABLE IN THE LAST COUPLE OF YEARS. THIS CAR HAS BEEN KEPT IN THE GARAGE AND SHOULD NOT HAVE BEEN EXPERIENCING THIS PROBLEM. I TALKED TO THE FORD BODY SHOP IN SAN ANTONIO THAT IS AFFILIATED WITH THE ORIGINAL DEALER- NORTHSIDE FORD IN 1995 BUT THEY SAID THAT THE PAINT WAS NOT COVERED UNDER ANY WARRANTY'S. THE ONLY WAY THAT I HAVE DISCOVERED THAT I MAY HAVE SOME RECOURSE, IS THROUGH A RECENT ISSUE OF "CONCUMER REPORTS" - OCT '99 ISSUE. I WOULD APPRECIATE ANY HELP OR DOCUMENT THAT YOU COULD PROVIDE IN THIS MATTER.

#845088 | August 16, 1999

WHILE DRIVING DOWN THE ROAD AT 15MPH ALL OF A SUDDEN THE ABS BRAKE LIGHT AND ENGINE CHECK LIGHT CAME ON AND OFF, AND THEN STAYED ON. *AK

#810248 | March 20, 1997

SMOKE WAS COMING FROM INSIDE DASHOARD, MANUFACTURER REFUSES TO HELP. *AK

#505016 | June 24, 1996

CHECK ENGINE WARNING LIGHT CAME ON. *SD

#488998 | April 25, 1996

CHECK ENGINE LIGHT LUMINATES CONSTANTLY. *SD

#980513 | March 11, 1996

DEALER NEVER HAS PARTS. ON ALL RECALLS GULF FORD 115 MARKET ST., APALACHICOLA, FL 904 653-9600.

Other 1991 FORD EXPLORER Problem Areas

← Back to 1991 FORD EXPLORER overview