2011 FORD E-450 — Problems, Recalls & Safety Data
N/A
Safety Rating
10
Owner Complaints
10
Recalls
2
Service Bulletins
0
Investigations
Overview of the 2011 FORD E-450
The 2011 FORD E-450 has received a total of 10 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 10 recall campaigns affecting this vehicle, covering issues with EQUIPMENT ADAPTIVE/MOBILITY, FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS. 2 technical service bulletins have been issued by Ford Motor Company for this model year. The most commonly reported problems involve the Fuelpropulsion System (3 complaints), Electrical System (2 complaints), and Engine (1 complaint).
Recalls for the 2011 FORD E-450
NHTSA has recorded 10 recalls for the 2011 FORD E-450, potentially affecting up to 5,982 vehicles.
Recall 15V112000 — EQUIPMENT ADAPTIVE/MOBILITY
| 117 vehicles affected
Defect: Farber Specialty Vehicles (Farber) is recalling various specialty vehicles modified by Farber and equipped with model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.
Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Remedy: Farber will notify owners to take their vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on March...
View full details →Recall 14V595000 — EQUIPMENT ADAPTIVE/MOBILITY
| 437 vehicles affected
Defect: Elkhart Coach (Elkhart) is recalling certain model year 2006-2014 Ford E-350 and Ford E-450 vehicles manufactured January 1, 2006, to May 1, 2014 and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.
Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Remedy: Elkhart will notify owners to take the vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on October...
View full details →Recall 14V426000 — FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
| 36 vehicles affected
Defect: Roush Performance Products, Inc. (Roush) is recalling certain model year 2010-2012 Ford E-150 Wagons and Cargo Vans, E-250 Cargo Vans and Extended Cargo Vans, E-350 Wagons, Extended Wagons, Cargo Vans, and Extended Vans, and E-450 Cutaway models. These models were modified by Roush to be equipped with certain propane fuel system conversion kits manufactured January 2011 to August 2012 with...
Consequence: A propane leak in the presence of an ignition source increases the risk of a fire.
Remedy: Roush will notify owners and will replace the aluminum fuel line fittings with new stainless steel fittings, free of charge. The recall began on September 1, 2014. Owners may contact Roush customer service at 1-800-597-6874.
View full details →Recall 11V445000 — VISIBILITY:WINDSHIELD
| 4,532 vehicles affected
Defect: Ford Motor Company (Ford) is recalling certain model year 2011 Ford E-150, E-250, E-350, and E-450 vehicles built from May 12, 2011, through May 26, 2011. Due to improper manufacturing conditions, some of the windshields may form bubbles after an extended time in hot temperatures. As such, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety...
Consequence: The presence of bubbles may hinder driver's visibility thereby increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the windshield if bubbles are present, free of charge. The recall began in January 2014. Owners may contact the Ford customer relationship center at 1-866-436-7332. Ford's recall campaign number is...
View full details →Recall 12V584000 — EQUIPMENT
| 227 vehicles affected
Defect: Creative Bus Sales, Inc is recalling certain model year 2006-2011 Chevrolet and GMC C5500, and Ford E450, and Econoline 350 vehicles equipped with Braun wheelchair lifts. Over time, or with frequent use, the roll stop latches on the outer barrier of the lifts may become bent or misaligned.
Consequence: A wheelchair occupant may defeat or ride over the insufficiently latched roll stop. If this occurs when the lift platform is in an elevated position, the wheelchair's occupant could fall and sustain injury.
Remedy: Braun is conducting this recall on behalf of Creative Bus Sales. Braun will notify owners, and dealers will repair the vehicles free of charge. The recall began on November 23, 2012. Owners may contact Creative Bus at 1-888-633-8380 or Braun...
View full details →Recall 11E033000 — FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM
| 286 vehicles affected
Defect: ROUSH IS RECALLING CERTAIN AFTERMARKET ROUSH CLEAN TECH LIQUID PROPANE AUTOGAS FUEL SYSTEM KITS USED FOR INSTALLATION ON THE FOLLOWING VEHICLES: MODEL YEAR 2007 AND 2008 FORD E-350 (DUEL REAR WHEEL), MY 2009-2011 FORD E- 150, E-250, AND E-350, AND MY 2009-2011 FORD E-450 CUTAWAYS. THE FUEL RAILS INCLUDED IN THE KITS CONTAIN IMPROPERLY SEATED INJECTOR RETENTION CLIPS. THIS COULD...
Consequence: A GAS LEAK IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: ROUSH WILL NOTIFY OWNERS OF THE VEHICLES OF WHICH THE KITS WERE INSTALLED ON IN ORDER TO ARRANGE FOR FREE REPLACEMENT OF THE INJECTOR RETENTION CLIPS. THE SAFETY RECALL BEGAN ON SEPTEMBER 29, 2011. OWNERS MAY CONTACT ROUSH AT 1-800-59-ROUCH...
View full details →Recall 11V450000 — FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM
| 101 vehicles affected
Defect: ROUSH IS RECALLING CERTAIN MODEL YEAR 2009-2011 FORD E-150, E-250, AND E-350 5.4L ENGIN VANS/WAGONS/CUTAWAYS, AND MODEL YEAR 2010-2011 FORD E-450 6.8L ENGINE CUTAWAY VEHICLES ALTERED BY ROUCH TO OPERATE USING THE ROUSH BRANDED CLEANTECH PROPANE AUTOGAS FUEL SYSTEM. THE FUEL RAILS INCLUDED IN THE KITS CONTAIN IMPROPERLY SEATED INJECTOR RETENTION CLIPS. THIS COULD RESULT IN LEAKAGE OF PROPANE AUTOGAS.
Consequence: A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: ROUSH WILL NOTIFY OWNERS OF THE VEHICLES OF WHICH THE KITS WERE INSTALLED IN ORDER TO ARRANGE FOR FREE REPLACEMENT OF THE INJECTOR RETENTION CLIPS. THE SAFETY RECALL BEGAN ON SEPTEMBER 26, 2011. OWNERS MAY CONTACT ROUSH AT 1-734-466-6255.
View full details →Recall 11E019000 — FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
| 39 vehicles affected
Defect: ROUSH IS RECALLING CERTAIN AFTERMARKET ROUSH CLEAN TECH LIQUID PROPANE AUTOGAS FUEL SYSTEM KITS PRODUCED BETWEEN DECEMBER 17, 2010, AND MAY 6, 2011, USED FOR INSTALLATION ON FLEET VEHICLES MODEL YEAR 2009 THROUGH 2011 FORD E-SERIES VANS/WAGONS/SHUTTLES/CUTAWAY (150, 250 AND 350) WITH 5.4L ENGINES ("E-SERIES"), AND MY 2011 FORD E-450 CUTAWAYS. THE VALVES INSTALLED IN THE SERVICE PORT OF THE...
Consequence: A GAS LEAK IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: AS OF MAY 27, 2011, ROUSH HAD NOTIFIED ALL OWNERS OF RECORD BY TELEPHONE AND SHIPPED TO THEM REPLACEMENT VALVES FREE OF CHARGE. OWNERS MAY CONTACT ROUSH AT 1-734-466-6255.
View full details →Recall 11V307000 — FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
| 15 vehicles affected
Defect: ROUSH PERFORMANCE PRODUCTS IS RECALLING CERTAIN 2011 FORD E-SERIES VANS EQUIPPED WITH 5.4 OR 6.8 LITER ENGINES THAT HAVE BEEN ALTERED BY ROUSH TO OPERATE USING THE ROUSH LIQUID PROPANE AUTOGAS FUEL SYSTEM. A VALVE IN THE SYSTEM MAY HAVE BEEN MISMACHINED ALLOWING A PROPANE LEAK.
Consequence: A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A VEHICLE FIRE.
Remedy: ROUSH WILL REPLACE THE DEFECTIVE VALVE WITH A CORRECTLY MACHINED ONE. ALL THE AFFECTED VEHICLES HAVE BEEN REPAIRED, THEREFORE, AN OWNER NOTIFICATION LETTER WILL NOT BE ISSUED FOR THIS CAMPAIGN. OWNERS MAY CONTACT ROUSH AT 1-734-466-6255.
View full details →Recall 11V246000 — SEATS:FRONT ASSEMBLY:POWER ADJUST
| 192 vehicles affected
Defect: FORD IS RECALLING CERTAIN MODEL YEAR 2011 E-150, E-250, E-350 AND E-450 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." IT MAY BE POSSIBLE THAT UNDER UNUSUALLY HIGH LOADS, SUCH AS DURING A CRASH, THE DRIVER POWER SEAT TRACK WORM GEAR MAY FRACTURE.
Consequence: IN THE EVENT OF A CRASH OR OTHER CIRCUMSTANCES OF SEVERE LOADING, THE WORM GEAR COULD FRACTURE AND ALLOW THE SEAT TO SHIFT UNRESTRAINED FORWARD OR BACKWARD INCREASING THE RISK AND/OR SEVERITY OF INJURIES TO THE DRIVER.
Remedy: DEALERS WILL INSPECT THE DRIVER'S SEAT TRACK ASSEMBLY, AND IF NECESSARY, REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 4, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
View full details →Owner Complaints for the 2011 FORD E-450
10 complaints have been filed with NHTSA for the 2011 FORD E-450. Below is a breakdown by vehicle component.
| Component | Complaints | Crashes | Fires | Injuries | Deaths |
|---|---|---|---|---|---|
| Fuelpropulsion System | 3 | 0 | 1 | 0 | 0 |
| Electrical System | 2 | 0 | 1 | 0 | 0 |
| Engine | 1 | 0 | 0 | 0 | 0 |
| Fuel System Diesel | 1 | 0 | 0 | 0 | 0 |
| Tires | 1 | 0 | 0 | 0 | 0 |
| Vehicle Speed Control | 1 | 0 | 0 | 0 | 0 |
| Wheels | 1 | 0 | 0 | 0 | 0 |
Most Recent Complaints
WHILE DRIVING STRAIGHT ON A CITY STREET AND AGAIN ON AN INTERSTATE, THE VEHICLE SHUT OFF. A DIAGNOSTIC REPORT DETERMINED THAT THE FUEL PUMP CIRCUIT WIRING HARNESS WAS BAD. THE VEHICLE HAS 23,000.
WHILE DRIVING STRAIGHT ON A CITY STREET AND AGAIN ON AN INTERSTATE, THE VEHICLE SHUT OFF. A DIAGNOSTIC REPORT DETERMINED THAT THE FUEL PUMP CIRCUIT WIRING HARNESS WAS BAD. THE VEHICLE HAS 23,000.
TL* THE CONTACT OWNS A 2011 FORD E-450. THE CONTACT STATED THAT THE AIR FILTER FAILED TO FUNCTION PROPERLY. THE PLASTIC CAP BECAME UNGLUED AND WAS SUCKED INTO THE INTAKE, PREVENTING AIR FROM ENTERING THE ENGINE. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE VEHICLE WAS NOT DIAGNOSED BY A DEALER. THE CONTACT, AN INDEPENDENT MECHANIC, REMOVED THE FRAM AIR FILTER TO DIAGNOSE AND REPAIR THE VEHICLE. THE AIR FILTER MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.
ON TWO OCCASIONS, OVER THE PAST 2 YEARS, WHILE DRIVING ON AN INTERSTATE, I HAVE HAD THE "WRENCH" LIGHT COME ON, ON THE DASH DISPLAY. THIS IS CAUSED BY ME USING THE CRUISE CONTROL, BUT WHEN I HIT THE BRAKE TO RELEASE THE CRUISE CONTROL, THEN STEP ON THE GAS PEDAL TO BRING IT BACK UP TO SPEED, THE LIGHT APPEARS AND I GO INTO "LIMP MODE". ONCE I PULL OVER AND STOP THE ENGINE, APPARENTLY THIS RE-SETS THE SYSTEM, AND THE VEHICLE DRIVES OKAY. I HAVE BEEN TOLD BY A FORD TECH THAT THIS IS THE ELECTRONIC THROTTLE CONTROL AND THAT IT MAY BE NORMAL, BUT I FEEL IT IS TOO SENSITIVE. I AM WONDERING IF IT SHOULD HAVE A RECALL ON IT.
THIS VEHICLE WAS CONVERTED TO AN AMBULANCE BY WHEELD COACH. THE AMBULANCE CAUGHT FIRE AND SPREAD TO THE BUILDING IN WHICH IT WAS PARKED AND UNOCCUPIED. A PARAMEDIC SMELLED SOMETHING COMING FROM THE BAY, AND, WHEN HE WENT TO INVESTIGATE, HE SAW SMOKE AND FIRE DRIPPING FROM UNDERNEATH THE AMBULANCE. AN INVESTIGATOR DETERMINED THAT THE LUG CONNECTION AT THE ALTERNATOR WAS IMPROPERLY INSTALLED BY WHEELED COACH. THE CONNECTION PRODUCED A HIGH RESISTANCE CONNECTION, PRODUCING TEMPERATURES SUFFICIENT TO IGNITE A COMPETENT FUEL SOURCE AND/OR CAUSED THE BATTERY CABLE INSULATION TO FAIL, PRODUCING ELECTRICAL ARCING THAT PROVIDED A COMPETENT IGNITION SOURCE TO CAUSE THE FIRE. *TR
Safety Rating for the 2011 FORD E-450
NHTSA has not yet tested the 2011 FORD E-450 in its New Car Assessment Program.
Technical Service Bulletins for the 2011 FORD E-450
Ford Motor Company has issued 2 technical service bulletins (TSBs) for the 2011 FORD E-450. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
16-0057 — POWER TRAIN
Some 2009-2016 E-Series, F-Super Duty, 2009-2015 F-53 Motorhome and 2011-2015 F-59 Stripped Chassis vehicles equipped with a TorqShift® transmission and a transmission built on or before 12/15/2015 may exhibit a MIL with DTCs P0751, P0730 and/or P2700
15-0116 — POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
FORD 2011-2016 F-250,350,450,550: SOME VEHICLES MAY EXPERIENCE MULTIPLE DIAGNOSTIC CODES STORED IN THE POWER CONTROL MODULE MEMORY DUE TO CRYSTALS DEVELOPING ON THE INJECTOR NOZZLE. *LJ
NHTSA Investigations for the 2011 FORD E-450
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the FORD E-450
- 2006 FORD E-450 — 26 complaints
- 2007 FORD E-450 — 15 complaints
- 2008 FORD E-450 — 10 complaints
- 2009 FORD E-450 — 2 complaints
- 2010 FORD E-450 — 6 complaints
- 2011 FORD E-450 (current)
- 2012 FORD E-450 — 6 complaints
- 2013 FORD E-450 — 16 complaints
- 2014 FORD E-450 — 5 complaints
- 2015 FORD E-450 — 8 complaints
- 2016 FORD E-450 — 22 complaints
Other FORD Models
- FORD F-150 — 45,660 total complaints
- FORD EXPLORER — 42,140 total complaints
- FORD ESCAPE — 34,654 total complaints
- FORD FOCUS — 29,539 total complaints
- FORD FUSION — 28,243 total complaints
- FORD TAURUS — 23,867 total complaints
- FORD WINDSTAR — 19,456 total complaints
- FORD EDGE — 17,247 total complaints