2005 FORD E-450 Engine Problems

THIS VEHICLE IS A MOTORHOME, BUILD ON THE 2005 E450 CAB/CHASSIS WITH A GAS V10 ENGINE. WHILE DRIVING IN A SINGLE LANE CONSTRUCTION ZONE ON THE INTERSTATE THE ELECTRONIC THROTTLE BODY SYSTEM FAILED, AND THE ENGINE SUDDENLY STOPPED RESPONDING TO THE ACCELERATOR PEDAL. AS A RESULT THE VEHICLE SUDDENLY LOST POWER AND SLOWED TO A VERY VERY LOW SPEED (A FEW INCHES PER SECOND). AS TRAFFIC APPROACHED AND BUILT UP BEHIND I INCHED THE VEHICLE ONTO THE SHOULDER. THE VEHICLE WAS UNABLE TO MOVE UNDER IT'S OWN POWER ANY FURTHER AND REQUIRED A TOW. IT WAS AN EXTREMELY DANGEROUS SITUATION ON A CROWDED HIGHWAY, IN A CONSTRUCTION ZONE, WITH MY FAMILY.

2005 FORD E-450. CONSUMER WRITES IN REGARDS TO THROTTLE BODY FAILURE. *SMD THE CONSUMER STATED THE THROTTLE BODY FAILED, WITHOUT WARNING AND THERE WAS NO ACCELERATION. ALSO, THE CHECK ENGINE LIGHT ILLUMINATED. THE THROTTLE BODY WAS REPLACED AT A COST OF $ 682.

TL* THE CONTACT OWNS A 2005 FORD E-450 VAN. THE CONTACT STATED THAT ANTI-FREEZE WAS LEAKING ONTO THE ENGINE. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC WHERE HE WAS ADVISED THAT THE COOLANT HOSE WAS FRACTURED AT THE CONNECTION TO THE ENGINE AND CYLINDER HEADS. THE MECHANIC COULD NOT REPLACE THE HOSE DUE TO THE PART BEING ON BACK ORDER. THE MECHANIC HAD TO WELD THE HOSE TO STOP THE LEAK BUT THE REPAIR DID NOT REMEDY THE ISSUE. THE MANUFACTURER HAD NOT PRODUCED THE PART IN OVER A YEAR. THE FAILURE MILEAGE WAS 115,000.