2002 FORD E-350 Engine Problems

HEAD ON VEHICLE STRIPPED BECAUSE OF THE WAY IT IS MADE. THERE WAS A RECALL ON REGULAR E350 BUT MINE IS AN RV. IT WAS IN MOTION WHEN THE SPARK PLUG POPPED OUT WHILE DRIVING DOWN THE HIGHWAY ON I-65 IN BIRMINGHAM ALABAMA.

THIS 350 ECONOLINE, 8CYL., EXTENDED BODY VAN WAS PURCHASED NEW, AND I AM THE ORIGINAL OWNER. THE VEHICLE HAS ONLY 120K MILES ON IT SINCE 2002. BEGINNING SEVERAL YEARS AGO, MY MECHANIC COMPLAINED OF SEVERE FRAME EROSION, HAVING HAD TO REINFORCE AND RE-WELD SEVERAL PARTS BACK ONTO THE FRAME, INCLUDING BUT NOT LIMITED TO THE BRACKETS WHICH SUPPORT THE REAR LEAF SPRINGS. (TWO OCURRANCES-- LEFT AND RIGHT SIDES). LAST WEEK, MY EMPLOYEE COMPLAINED OF SOME REAR END SWAYING AT MODERATE SPEED CORNERING. WE DISCOVERED A CROSS-TIE CONNECTION BETWEEN THE SIDE RAILS AT THE REAR OF THE VEHICLE'S FRAME HAD ROTTED AWAY, THUS CAUSING SOME UNWANTED FRAME MOVEMENT. IF IT WEREN'T FOR A HEAVY-DUTY TOWING PACKAGE I HAD PURCHASED WITH THE VEHICLE IN 2002, I BELIEVE THE LEFT AND RIGHT SIDES OF THE VEHICLE'S UNDER-FRAMING WOULD HAVE TWISTED AND SEPARATED FROM THE BODY YEARS AGO ! ALSO BEGINNING A FEW YEARS...

TL*THE CONTACT OWNS A 2002 FORD E-350. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT ABLE TO RESTART. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.

TL* THE CONTACT OWNS A 2002 FORD E-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED THREE TIMES OVER A PERIOD OF FOUR YEARS. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSIS OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.