2008 FLEETWOOD BOUNDER DIESEL — Problems, Recalls & Safety Data
N/A
Safety Rating
3
Owner Complaints
8
Recalls
2
Service Bulletins
0
Investigations
Overview of the 2008 FLEETWOOD BOUNDER DIESEL
The 2008 FLEETWOOD BOUNDER DIESEL has received a total of 3 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 8 recall campaigns affecting this vehicle, covering issues with ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES, SUSPENSION, EQUIPMENT:OTHER:LABELS. 2 technical service bulletins have been issued by FLEETWOOD ENTERPRISES, INC. for this model year. The most commonly reported problems involve the Electrical System (1 complaint), Electrical System12v24v48v Batterycables (1 complaint), and Unknown Or Other (1 complaint).
Recalls for the 2008 FLEETWOOD BOUNDER DIESEL
NHTSA has recorded 8 recalls for the 2008 FLEETWOOD BOUNDER DIESEL, potentially affecting up to 25,452 vehicles.
Recall 09V056000 — ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
| 3,782 vehicles affected
Defect: FLEETWOOD IS RECALLING 3,782 MY 2006-2009 PROVIDENCE, EXCURSION, EXPEDITION, DISCOVERY AND BOULDER DIESEL MOTOR HOMES. THE BATTERY CABLE IS ROUTED TOO CLOSE TO A SHARP EDGE LOCATED ON TOP OF A SHELF INSTALLED OVER THE DRIVESHAFT.
Consequence: THIS CAN CAUSE ABRASION TO THE BATTERY CABLE INSULATION, LEADING TO AN ELECTRICAL SHORT AND POSSIBLY A FIRE.
Remedy: DEALERS WILL RE-ROUTE THE CABLE AWAY FROM THE SHARP EDGE LOCATION. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE RECALL BEGAN ON MAY, 26 2009. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.
View full details →Recall 08V269000 — SUSPENSION
| 2,506 vehicles affected
Defect: DAIMLER TRUCKS IS RECALLING 2,506 MY 2008 XC MOTOR HOME CHASSIS AND THOMAS BUILT HDX SCHOOL AND TRANSIT BUSES EQUIPPED WITH SAF-HOLLAND ADL SERIES REAR SUSPENSIONS. IN SOME INSTANCES THE TRANSVERSE BEAM WAS NOT PROPERLY WELDED WHICH COULD RESULT IN A FAILURE OF THE WELD.
Consequence: IF THE WELD FAILS, VEHICLE STABILITY WHILE CORNERING COULD BE AFFECTED RESULTING IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A CRASH. IN ADDITION, THE TRANSVERSE BEAM COULD DROP TO THE GROUND CAUSING SPARKS THAT COULD CAUSE A FIRE HAZARD.
Remedy: DAIMLER TRUCKS IS WORKING WITH SAF-HOLLAND TO HAVE A VISUAL INSPECTION OF THE ADL TRANSVERSE BEAM PERFORMED. IF A WELD DEFECT IS IDENTIFIED, SAF-HOLLAND WILL PROVIDE A SERVICE REPLACEMENT KIT THAT CONTAINS A NEW TRANSVERSE BEAM, ALL NECESSARY INSTALLATION HARDWARE,...
View full details →Recall 08V292000 — EQUIPMENT:OTHER:LABELS
| 226 vehicles affected
Defect: FLEETWOOD IS RECALLING 226 MY 2008-2009 AMERICAN ALLEGIANCE, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION, BOUNDER, BOUNDER DIESEL, DISCOVERY, EXCURSION, EXPEDITION, FIESTA LX, PACE ARROW, PROVIDENCE, REVOLUTION LE, SOUTHWIND, CLASS A MOTOR HOMES, AND ICON, JAMBOREE, JAMBOREE GT, JAMBOREE SPORT, PULSE, TIOGA, AND TIOGA RANGER CLASS C MOTOR HOMES. THESE MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF THE CODE...
Consequence: OVERLOADING MAY HAVE AN ADVERSE AFFECT ON MOTOR HOME HANDLING, INCREASING THE RISK OF A CRASH.
Remedy: FLEETWOOD WILL MAIL A CORRECTED FEDERAL CERTIFICATION LABEL ALONG WITH INSTALLATION INSTRUCTIONS TO THE AFFECTED MOTOR HOME OWNERS. OWNERS WHO DO NOT FEEL COMFORTABLE INSTALLING THIS LABEL CAN TAKE THEIR MOTOR HOME TO ANY FLEETWOOD DEALER AND THE DEALER WILL...
View full details →Recall 08V013000 — ELECTRICAL SYSTEM:WIRING
| 376 vehicles affected
Defect: ON CERTAIN MOTOR HOMES EQUIPPED WITH A FIELD EFFECT TRANSISTOR (FET) BOARD BUILT BY MAGNUM ENERGY, INC., THE CIRCUITRY INSIDE CERTAIN INVERTERS CAN CAUSE AN INOPERATIVE CONDITION RESULTING IN OVERHEATING OF THE INVERTER.
Consequence: OVERHEATING OF THE INVERTER MAY RESULT IN A POTENTIAL FIRE.
Remedy: DEALERS WILL INSPECT AND REPLACE THE INVERTER FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 19, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
View full details →Recall 07V503000 — EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
| 46 vehicles affected
Defect: ON CERTAIN MOTOR HOMES, THE SLIDE-OUT ROOM MAY ACTIVATE WHILE TRAVELING, CAUSING THE OVERALL VEHICLE WIDTH TO INCREASE.
Consequence: THE WIDE VEHICLE WIDTH COULD LEAD TO COLLISIONS WHILE TRAVELING OR SLIDE-OUT ROOM IMPACT TO ADJACENT OBJECTS WHILE THE MOTOR HOME IS PARKED.
Remedy: DEALERS WILL INSPECT AND IF NECESSARY, RELOCATE CERTAIN ELECTRICAL COMPONENTS AND SEAL ASSOCIATED COMPARTMENTS FROM THE ELEMENTS. THE RECALL BEGAN ON JANUARY 11, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-322-8216.
View full details →Recall 07V504000 — EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
| 133 vehicles affected
Defect: ON CERTAIN MOTOR HOMES, THE SLIDE-OUT ROOM MAY ACTIVATE WHILE TRAVELING, CAUSING THE OVERALL VEHICLE WIDTH TO INCREASE. WATER CAN SHORT OUT THE ELECTRONIC CONTROL RELAY FOR THE SLIDE-OUT ROOM CONTROL MECHANISM.
Consequence: THE WIDE VEHICLE WIDTH COULD LEAD TO COLLISIONS WHILE TRAVELING OR SLIDE-OUT ROOM IMPACT TO ADJACENT OBJECTS WHILE THE MOTOR HOME IS PARKED.
Remedy: DEALERS WILL INSPECT AND IF NECESSARY, RELOCATE CERTAIN ELECTRICAL COMPONENTS AND SEAL ASSOCIATED COMPARTMENTS FROM THE ELEMENTS. THE RECALL BEGAN ON JANUARY 11, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-322-8216.
View full details →Recall 07V306000 — STEERING
| 18,000 vehicles affected
Defect: FREIGHTLINER IS RECALLING CERTAIN SCHOOL BUS CHASSIS, HEAVY TRUCKS, VAN CHASSIS, RV MOTORHOME CHASSIS MANUFACTURED FROM JANUARY 5 TO MAY 17, 2007, EQUIPPED WITH AXLE ALLIANCE COMPANY (AAC) FRONT AXLES. DURING THE FRONT AXLE ASSEMBLY, THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE SPINDLE MAY BE OVER OR UNDER TIGHTENED.
Consequence: INCORRECTLY TIGHTENED STEERING ARM FASTENERS MAY FATIGUE AND FRACTURE WHICH COULD CAUSE A CRASH WITHOUT WARNING.
Remedy: THOMAS BUILT WILL NOTIFY OWNERS, INSPECT THE FASTENERS, AND REPLACE THE STEERING ARM IF NECESSARY. THE RECALL BEGAN ON DECEMBER 21, 2007. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.
View full details →Recall 09V175000 — ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
| 383 vehicles affected
Defect: FLEETWOOD IS RECALLING 311 MY 2008-2009 PROVIDENCE, EXCURSION, EXPEDITION, DISCOVERY AND BOUNDER DIESEL MOTOR HOME. THE BATTERY CABLE MAY BECOME DISLODGED AND COME IN CONTACT WITH THE DRIVER SHAFT CAUSING ENTANGLEMENT OR ABRASION TO THE BATTERY CABLE.
Consequence: THIS COULD LEAD TO AN ELECTRICAL SHORT WHICH MAY RESULT IN A FIRE OR UN-COMMANDED VEHICLE SHUTDOWN WHICH MAY RESULT IN A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL INSPECT AND REPLACE DAMAGE BATTERY CABLES AND SECURE THE BATTERY CABLE HARNESS ABOVE THE DRIVE SHAFT FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2009. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
View full details →Owner Complaints for the 2008 FLEETWOOD BOUNDER DIESEL
3 complaints have been filed with NHTSA for the 2008 FLEETWOOD BOUNDER DIESEL. Below is a breakdown by vehicle component.
| Component | Complaints | Crashes | Fires | Injuries | Deaths |
|---|---|---|---|---|---|
| Electrical System | 1 | 0 | 0 | 0 | 0 |
| Electrical System12v24v48v Batterycables | 1 | 0 | 0 | 0 | 0 |
| Unknown Or Other | 1 | 0 | 0 | 0 | 0 |
Most Recent Complaints
Magnum Energy Management System isn’t working properly. While charging House Batteries when connected to 50amp shore power it goes to fault stating overtemp and shuts house appliances down. Also when my VIN# is searched I receive results stating it’s a 2008 Fleetwood Diesel Expedition. I purchased this new from Camping World of Roanoke, VA. Can you verify the VIN to my Bounder?
Magnum Energy Management System isn’t working properly. While charging House Batteries when connected to 50amp shore power it goes to fault stating overtemp and shuts house appliances down. Also when my VIN# is searched I receive results stating it’s a 2008 Fleetwood Diesel Expedition. I purchased this new from Camping World of Roanoke, VA. Can you verify the VIN to my Bounder?
TL* THE CONTACT OWNS A 2008 FLEETWOOD BOUNDER DIESEL RV. THE CONTACT RECEIVED RECALL NOTIFICATION NUMBER 09V056000, ELECTRICAL SYSTEM BATTERY CABLES; HOWEVER, THE MANUFACTURER IS NO LONGER IN BUSINESS. THE LEGAL HEIR OF THE BUSINESS REFUSED TO HONOR THE REMEDY OUTLINED IN THE RECALL. THE CURRENT MILEAGE WAS 7,500. UPDATED 10/20/09 *CN
Safety Rating for the 2008 FLEETWOOD BOUNDER DIESEL
NHTSA has not yet tested the 2008 FLEETWOOD BOUNDER DIESEL in its New Car Assessment Program.
Technical Service Bulletins for the 2008 FLEETWOOD BOUNDER DIESEL
FLEETWOOD ENTERPRISES, INC. has issued 2 technical service bulletins (TSBs) for the 2008 FLEETWOOD BOUNDER DIESEL. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
07163 — SERVICE BRAKES, ELECTRIC
ACCUMULATION OF MOISTURE INSIDE THE ELECTRIC LEVELER MOTOR BRAKE BOOT. THIS CAUSES CORROSION OF THE LEVELER BRAKE AND SUBSEQUENT SEIZURE OF THE LEVELER MOTOR. FLEETWOOD. *KB UPDATED 7/6/09. *PE
RB-71221 — ELECTRICAL SYSTEM
FLEETWOOD: CIRCUITRY INSIDE CERTAIN MAGNUM INVERTERS CAN CAUSE AN INOPERATIVE CONDITION, OVERLOAD, AND RISK OF FIRE. *PE
NHTSA Investigations for the 2008 FLEETWOOD BOUNDER DIESEL
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the FLEETWOOD BOUNDER DIESEL
- 2003 FLEETWOOD BOUNDER DIESEL — 2 complaints
- 2005 FLEETWOOD BOUNDER DIESEL — 7 complaints
- 2006 FLEETWOOD BOUNDER DIESEL — 3 complaints
- 2007 FLEETWOOD BOUNDER DIESEL — 2 complaints
- 2008 FLEETWOOD BOUNDER DIESEL (current)
- 2009 FLEETWOOD BOUNDER DIESEL — 0 complaints
Other FLEETWOOD Models
- FLEETWOOD BOUNDER — 460 total complaints
- FLEETWOOD SOUTHWIND — 238 total complaints
- FLEETWOOD PACE ARROW — 216 total complaints
- FLEETWOOD DISCOVERY — 148 total complaints
- FLEETWOOD PROWLER — 120 total complaints
- FLEETWOOD TIOGA — 95 total complaints
- FLEETWOOD FLAIR — 84 total complaints
- FLEETWOOD JAMBOREE — 77 total complaints