2006 DODGE RAM 3500 Visibility Problems

MULTIPLE OCCURRENCES OF MODE DOOR/BLEND DOOR/ RECIRCULATION DOOR FAILURE. DIVERTS AIR TO FLOOR AND WILL NOT ALLOW FOR DEFROSTING/ DE-ICING OF WINDSHIELD. WINSHIELD WILL ACCUMULATE ICE AND CAUSE WIPERS TO CEASE FUNCTION OR FOG WITHOUT ABILITY TO REMOVE OR WITHOUT WARNING. CHRYSLER CORPORATION HAS A "REVISED BLEND DOOR" DESIGN THAT ADDRESSES THIS PROBLEM, HOWEVER, RETROFIT IS NOTY COVERED BY RECALL AND EARLY REPLACEMENTS SIS NOT UTILIZED REVISED DOOR DESIGN. DOOR FOR RECIRCULATION WILL FALL OFF AND OBSTRUCT FAN MOTOR. IF FAN MOTOR IS ON, OBSTRUCTION CAN CAUSE FAN OVERHEAT AND POSSIBLE ELECTRICAL FIRE/ OR MELTING OF HOUSING CAUSING SMOKE AND NOXIOUS FUMES. MODE DOOR FAILURE PROHIBITS USE OF DEFROST/ DEFOG OF WINDSHIEL AND CAN HAPPEN WITHOUT WARNING.

TL* THE CONTACT OWNS A 2006 DODGE RAM 3500. THE CONTACT STATED THAT WHILE DRIVING 50 MPH IN RAINY WEATHER, THE WINDSHIELD WIPERS FAILED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE TOTALLY INTEGRATED POWER MODULE FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 74,300.

I WAS DRIVING DOWN THE STREET JUST ABOUT TO MAKE A LEFT HAND TURN SO I TURNED ON MY LEFT SIGNAL WHEN I DID THAT MY WINDSHIELD WIPERS STOPPED WORKING PLUS WITH MY LEFT SIGNAL ON IT WASN'T BLINKING TO THE LEFT IT WAS BLINKING TO THE RIGHT. SO WITHOUT MY WINDSHIELD WIPERS I HAD TO PULLOVER BECAUSE I COULDN'T SEE. I TURNED THE TRUCK OFF THEN BACK ON AND THE WINDSHIELD WIPERS STARTED WORKING AGAIN. BUT EVERYTIME I USE MY LEFT SIGNAL MY RIGHT ONE BLINKS AND MY WINDSHIELD WIPERS STOP WORKING. *TR

WHEN USING THE TURN INDICATOR, EITHER THE OPPOSITE INDICATOR COMES ON, OR NEITHER WORK. ALSO, THE WINDSHIELD WIPERS DON'T WORK PROPERLY. THEY SEEM TO OPERATE RANDOMLY (E.G., WORK AT HIGH SPEED WITH THE SWITCH IN THE OFF POSITION, OR DON'T WORK AT ALL WITH THE SWITCH IN ANY POSITION). IT APPEARS TO ME THAT THE MULTI-FUNCTION SWITCH IS DEFECTIVE. THIS PROBLEM NEARLY CAUSED AN ACCIDENT WHILE I WAS DRIVING AT HIGHWAY SPEEDS (60 MPH)DURING A RAINSTORM AND THE WIPERS WOULDN'T OPERATE. I HAD TO DRIVE TO THE SIDE OF THE HIGHWAY AND SHUT OFF THE IGNITION SWITCH TO RESOLVE THE PROBLEM. A LESS EXPERIENCED DRIVER MAY HAVE HAD MORE SEVERE CONSEQUENCES. *TR

TL* THE CONTACT OWNS A 2006 DODGE RAM 3500. THE CONTACT WAS DRIVING 65 MPH WHEN THE WINDSHIELD WIPER FAILED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO REPLACED THE WINDSHIELD WIPER MOTOR AND THE MULTI-FUNCTION SWITCH, BUT THE FAILURE WAS NOT CORRECTED. THE WINDSHIELD WIPER WAS NOT OPERABLE. THE MANUFACTURER DENIED ASSISTANCE WITH THE REPAIRS. THE FAILURE MILEAGE WAS 182,000 AND THE CURRENT MILEAGE WAS 184,000.

PUT LEFT TURN SIGNAL ON AND TRUCK SIGNALS ALTERNATES BETWEEN LEFT AND RIGHT TURN. *TR

TL*THE CONTACT OWNS A 2006 DODGE RAM 3500. THE CONTACT STATED THAT THE FRONT WINDSHIELD WIPER DID NOT MOVE TO THE HIGHEST LEVEL WHEN USING IN INCLEMENT WEATHER. THE VEHICLE HAD NOT BEEN OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000. THE VIN WAS UNAVAILABLE.

WHEN I USE THE SWITCH TO BRIGHTEN OR DIM THE HEADLIGHTS THE WINDSHIELD WASHER TURNS ON AND STAYS ON FOR 3 TO 5 SECONDS. LATELY WHEN I TRY TO USE THE WINDSHIELD WIPERS THEY WORK ONLY SPORADICALLY. WHEN I PULL A TRAILER THE LEFT BLINKER OR BRAKE LIGHT WILL NOT WORK. I DRIVE A 2006 DODGE RAM DUALLY WITH THE CUMMINS ENGINE. *TR

THE FLAP THAT CONTROLS FRESH AIR VS. RE-CIRCULATED AIR BREAKS AND FALLS OFF. EVEN IF REPLACED IT QUICKLY BREAKS AGAIN. DODGE CHARGES $800 TO FIX THIS CHEAP PLASTIC PART ONLY FOR IT TO QUICKLY BREAK AGAIN. I FOUND THE PROBLEM BECAUSE OF THE NUMEROUS REPORTS FOUND ON THE WEB ABOUT DODGE AC LOW AIR FLOW. WHEN BROKE, THE FLAP FALLS ON TOP OF THE FAN MOTOR AND BLOCKS AIR CIRCULATION. MY CHILDREN HAVE BAD ALLERGIES AND I HAVE NO WAY OF TURNING OFF THE OUTSIDE AIR BECAUSE OF THE DEFECTIVE DESIGN IN THE FLAP. AFTER IT BREAKS IT BLOCKS THE AIR FLOW OF THE FAN MOTOR. I HAVE 3 CO-WORKERS WITH THE SAME MODEL VEHICLE. THEY HAVE ALL SINCE CHECKED THEIR FRESH AIR/RE-CIRCULATE AIR FLAPS AND THEY WERE ALL BROKE. THIS OBVIOUSLY IS A DESIGN FLAW NOT BEING ACKNOWLEDGED BY DODGE. IT'S HAZARDOUS TO MY CHILDREN HEALTH (AND MINE) NOT...

SEVERAL DAYS AGO MY TURN-SIGNAL, WINDSHIELD WIPER SWITCH STARTED MALFUNCTIONING AT TIMES. FOR EXAMPLE I WOULD ACTIVATE THE SIGNAL SWITCH FOR A LEFT TURN AND THE RIGHT TURN INDICATOR LIGHT WOULD GO ON. OR, WINDSHIELD WIPERS FAILED TO WORK OR DID NOT PERFORM THE SELECTED FUNCTION. I CONSIDER THIS A SAFETY HAZARD FOR OBVIOUS REASONS AND BECAUSE THIS IS THE SECOND SWITCH I HAD IN THIS TRUCK. A YEAR OR SO AGO I HAD THE SWITCH REPLACED BY DODGE FOR THE SAME COMPLAINT AND NOW IT IS HAPPENING AGAIN. *TR

BLEND DOOR BREAKAGE IN SIDE OF BLOWER UNIT FOR HEATER/AC. I HAVE HAD THIS HAPPEN TWO TIMES AND AS A RESULT HAVE ALMOST HAD AN AUTO ACCIDENT BOTH TIMES DUE TO NOT BEING ABLE TO DEFROST-DEFOG THE WINDSHIELD AND SIDE WINDOWS. *TR

2006 DODGE 3500 DUALLY. THE AIR CONDITIONER STARTED BLOWING LESS AIR AND EVENTUALLY MAKING A LOUD NOISE. DEALER STATED THE DOOR TO THE VENTING SYSTEM HAD BROKEN OFF AND WAS HITTING THE AIR CONDITIONING FAN. THIS HAPPENED AT AROUND 27,000 MILES. *JB