2006 DODGE GRAND CARAVAN Engine Problems

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING 45 MPH, THE OIL PRESSURE AND AN UNKNOWN WARNING INDICATOR ILLUMINATED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE COULD NOT BE DUPLICATED. ON NOVEMBER 9, 2019, WHILE DRIVING 55 MPH, WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS LOSING SPEED, BUT WAS ABLE TO BE PULLED OVER TO THE SIDE OF THE ROAD. IN ADDITION, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE CONTACT CALLED THE POLICE DUE TO HER DISABLED HUSBAND BEING IN THE COLD FOR OVER TWO HOURS. A POLICE REPORT WAS FILED. HE WAS TRANSPORTED TO THE HOSPITAL, BUT THERE WERE NO INJURIES OR MEDICAL ATTENTION NEEDED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND THEN TOWED TO AN INDEPENDENT MECHANIC. THE...

I'VE TAKEN THE VEHICLE TO PEPBOYS TWICE BECAUSE ALTHOUGH THE GAS GAUGE WAS WORKING, THE VEHICLE WOULD CLICK THE GAS NOZZLE OFF AND WOULD NOT ACCEPT FUELING. PEPBOYS REPLACED THE IN-TANK PUMP AS A REMEDY TWICE. DODGE/CHRYSLER SAID IT WAS THE BREATHER TUBE. WHO'S RIGHT?

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING AT 35 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 141,000.

AFTER FILLING FUEL TANK, PULLED INTO TRAFFIC AND THE VAN STALLED 30 SECONDS LATER. WAS ABLE TO PULL OUT OF TRAFFIC AND RESTART. THIS HAPPENS NOW EVERY TIME THE FUEL TANK IS FILLED. WITHIN A MINUTE OR TWO OF LEAVING THE GAS STATION, THE ENGINE WILL AT LEAST HESITATE AND MANY TIMES STALLS COMPLETELY. *TR

AFTER FUELING, THE VEHICLE WITH SURGE AND OFTEN STALL WITH NEED FOR RESTART. VERY FREQUENTLY IT DOES THIS WHEN TAKING OFF FROM A STOP SIGN WHICH CAN CAUSE A STALL IN THE MIDDLE OF AN INTERSECTION. *TR

AFTER FILLING UP WITH GAS ENGINE STALLED APPROXIMATELY 1/2 MILE FROM THE GAS STATION. HAD TO COAST TO SIDE OF THE ROAD WITHOUT POWER STEERING. PLACED ENGINE IN PARK, TURNED OF KEY AND RESTARTED. ENGINE RAN ROUGH HAD TO DEPRESS ACCELERATOR FOR ADDITIONAL GAS. ONCE RESTARTED ENGINE RAN FINE FOR THE REST OF THE TRIP. THIS SAME PROBLEM ALSO OCCURRED IN EARLY JANUARY 1/03/2015 AFTER FILLING UP WITH GAS. NOT ONLY IS THIS AN INCONVENIENCE, BUT VERY DANGEROUS IN HEAVY TRAFFIC SCENARIOS. *TR

INVESTIGATION: DP 14-002; PROMPTED BY: DEFECT PETITION; DATE OPENED: 09/05/2014; INVESTIGATOR: [XXX]; REVIEWER: [XXX]; APPROVER: [XXX]; SUBJECT: ENGINE STALL AFTER REFUELING. PLEASE INCLUDE ME IN THE ABOVE MENTIONED COMPLAINT/INVESTIGATION # DP 14-002. AFTER REFUELING, MY ENGINE STALLS ABOUT 1 TO 2 MINUTES AFTER STARTING ALMOST EVERY TIME I FILL-UP WITH FUEL. WHEN THE FUELING NOZZLE TRIPS FOR THE FIRST TIME, I DO NOT ATTEMPT TO CONTINUE ADDING MORE FUEL AND POSSIBLY OVERFILLING THE FUEL TANK. I HAVE BEEN CAUGHT IN HEAVY TRAFFIC AT TIMES WITH THE ENGINE STALLING AND IT TAKES 2 TO 3 ATTEMPTS TO RESTART THE VEHICLE. THIS IS VERY DANGEROUS! NOW AFTER REFUELING, I PULL AWAY FROM THE PUMPS AND PARK OUT OF THE WAY AND ALLOW THE ENGINE TO STALL. AFTER ATTEMPTING TO RESTART SEVERAL TIMES, THE ENGINE WILL MISFIRE FOR ABOUT 30 TO 45 SECONDS, THEN THE ENGINE WILL SMOOTH OUT AND RUN FINE UNTIL...

ENGINE UNEXPECTEDLY STALLS SHORTLY AFTER REFUEL. *TR

OVER THE LAST SEVERAL WEEKS MY 2006 DODGE GRAND CARAVAN WITH A 3.8 LITER ENGINE WILL STALL OUT SEVERAL TIMES AFTER REFUELING. IT WILL RESTART & STALL SEVERAL TIMES BEFORE THE PROBLEM SEEMS TO RECTIFY ITSELF. ALL POWER ASSISTED STEERING IS LOST AND THE VEHICLE BECOMES DIFFICULT TO STEER SAFELY. POWER BRAKING IS ALSO AFFECTED. THERE HAVE BEEN A COUPLE OF OCCASIONS WHERE I HAVE BEEN TURNING INTO TRAFFIC AND HAD THE VEHICLE STALL. ONE TIME I WAS UNABLE TO COMPLETE THE TURN AND STAY IN MY LANE. ON ONE OCCASION I BREACHED THE LANE TO MY LEFT. WHILE TRAFFIC WAS TRAVELING IN THE SAME DIRECTION I WAS, ANOTHER MOTORIST HAD TO SLAM ON THE BRAKES TO AVOID HITTING ME. *TR

AFTER FILLING THE TANK WITH GAS, THE VAN ENGINE RUNS ROUGH AND THEN STALLS OUT. THIS HAS HAPPENED NUMEROUS TIMES OVER THE PAST THREE TO FOUR YEARS. WHEN IT HAPPENED ON TUES, OCTOBER 7, 2014, I HAD JUST PULLED OUT OF THE GAS STATION AND WAS GETTING READY TO CROSS A BUSY INTERSECTION WHEN THE CAR STALLED. I HAD TO QUICKLY PUT IT IN TO PARK AND RESTART. SCARED ME TO DEATH. AGAIN, THIS HAS HAPPENED AT LEAST FIFTY TIMES TO ME. WE HAVE TAKEN IT TO THE DEALERSHIP AND THEY CAN NEVER GET THE PROBLEM TO HAPPEN FOR THEM WHICH MAKES SENSE BECAUSE IT IS ONLY GOING TO HAPPEN AFTER REFUELING. *TR

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN SXT. WHILE ATTEMPTING TO SHIFT THE VEHICLE INTO PARK, THE VEHICLE ACCELERATED UNEXPECTEDLY. AS A RESULT, THE VEHICLE CRASHED INTO THE REAR OF ANOTHER PARKED VEHICLE. THE CONTACT SUFFERED FROM HIP PAIN. AN INDEPENDENT MECHANIC CLEANED THE THROTTLE PLATE. THE VEHICLE SUSTAINED SEVERE FRONT END DAMAGE AND WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 102,000. UPDATED 05/18/2015 *JS

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING 40 MPH, THE VEHICLE STALLED. THE BRAKE PEDAL WENT STRAIGHT TO THE FLOORBOARD WHEN IT WAS DEPRESSED AND THE CONTACT STOPPED THE VEHICLE USING THE EMERGENCY BRAKE. THE VEHICLE WAS ABLE TO BE RESTARTED AND RESUMED NORMAL OPERATION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE HAD NOT RECURRED. THE FAILURE MILEAGE WAS 69,000. UPDATED 08/28/14*LJ THE CONSUMER STATED WHILE DRIVING THE VEHILCE LOST ENGINE POWER, BRAKES, AND STEERING. UPDATED 09/2/2014 *JS

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE STALLED INTERMITTENTLY ON MULTIPLE OCCASIONS. ADDITIONALLY, THE VEHICLE JERKED VIOLENTLY AND WAS EXTREMELY DIFFICULT TO STEER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FAILURE WAS UNABLE TO BE REPLICATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. UPDATED 8/14/14*CN UPDATED 8/27/2014 *JS

FOR NO APPARENT REASON, THE ENGINE SHUTS OFF WHILE DRIVING. THE CLOCK REMAINS ON, BUT ACCESSORIES SUCH AS THE HEATER ALSO SHUT OFF, AND I HAVE NO POWER ASSIST WITH STEERING. SO FAR, IT'S HAPPENED WITHIN 5 MINUTES OF START-UP; THE OUTSIDE TEMPERATURES WERE BELOW FREEZING, BUT THE ENGINE HAS NOT ALWAYS BEEN COLD. 1/17/07 APPROX. 5 MIN. AFTER I'D BEEN DRIVING, AT ABOUT 30MPH, I REALIZED THE NOISY FAN FOR THE HEATER TURNED OFF. I THOUGHT MAYBE THE NEW VAN HAS A FEATURE I DIDN'T KNOW ABOUT, WHERE IT REACHES A SET TEMPERATURE THEN SHUTS OFF AUTOMATICALLY? THEN I REALIZED THE RADIO HAD ALSO GONE QUIET. I TRIED TO ACCELERATE BUT IT WASN'T RESPONDING, SO I WENT TO PULL OFF ON THE SHOULDER AND DISCOVERED I DIDN'T HAVE POWER STEERING, EITHER. FORTUNATELY, I WAS ABLE TO BRAKE. I TURNED THE KEY TO THE OFF POSITION, RESTARTED THE VAN, AND...

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THERE WAS AN EGR AND ELECTRICAL PROBLEM THAT RECURRED. THE ENGINE LIGHT ILLUMINATED WHEN SHE WAS DRIVING ON MULTIPLE OCCASIONS. THE REAR RIGHT PASSENGER DOOR WOULD NOT LOCK OR CLOSE PROPERLY. THE LEFT BRAKE LIGHT AND LEFT TURN SIGNALS WERE REPAIRED MULTIPLE TIMES. THE FAILURE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE EGR VALVE SYSTEM, THE LEFT BRAKE LIGHT, LEFT TURN SIGNAL LIGHT, FRONT WIPERS, FRONT BRAKE PADS, AND ROTORS NEEDED TO BE REPLACE. THE VEHICLE ALSO NEEDED A MAJOR TUNE UP. ALL OF THE REPAIRS WERE MADE MINUS THE EGR VALVE SYSTEM AND THE REAR PASSENGER SIDE DOOR WHICH THE DEALER WAS UNABLE TO REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70867.

VEHICLE QUITS WHILE DRIVING IN THE RAIN AND LOSES ABILITY TO STEER. *TR