1999 DODGE CARAVAN Structurebody Problems

7 NHTSA complaints on file

Check any vehicle history by VIN - Free vehicle history report

Structurebody Issues in the 1999 DODGE CARAVAN

7 structurebody complaints have been filed with NHTSA for the 1999 DODGE CARAVAN. Of these, 0 involved a crash, 0 involved a fire, and 1 resulted in injury.

Complaints

Crashes

Fires

Injuries

Deaths

All Structurebody Complaints

#10524685 | July 13, 2013

WHILE REPLACING REAR BRAKE DRUMS IN MY GARAGE, IT BECAME NECESSARY TO JACK THE VEHICLE TO RAISE THE REAR LEFT SIDE AND REMOVE THE REAR LEFT WHEEL. I BROKE THE LUG NUTS LOOSE WHILE THE VEHICLE WAS ON THE GROUND, THEN, USING THE JACK SUPPLIED WITH THE VEHICLE, I FOLLOWED THE PROCEDURE OUTLINED IN THE OWNER'S MANUAL TO POSITION THE JACK IN THE RECOMMENDED LOCATION TOWARD THE LEFT REAR AT THE IDENTIFIED JACKING LOCATION. I RAISED THE VEHICLE JUST ENOUGH TO REMOVE THE WHEEL. AS I WAS SPINNING THE LUG NUTS OFF, THE CAR FELL OFF THE JACK. THIS OCCURRED BECAUSE RUST HAD COMPROMISED THE STRUCTURAL METAL AT THE JACKING LOCATION AND THE WEIGHT, WHILE THE CAR WAS BEING RAISED, CRUSHED THE WEAKENED STEEL. FORTUNATELY, I WAS NOT TOO CLOSE AND WAS NOT CAUGHT UNDER THE WHEEL OR OTHER BODY PART. UPON CLOSE INSPECTION IT BECAME APPARENT THAT THE STRUCTURE...

#10487221 | December 3, 2012

DURING AN INSPECTION OF OUR VAN IT WAS NOTED THAT THE DRIVERS SIDE STRUT TOWER IS RUSTING THROUGH. AFTER LOOKING INTO THIS ISSUE ON LINE I NOTICED MANY CASES WITH EXACTLY THE SAME PROBLEM. I AM TRYING TO DETERMINE IF THERE IS ANY RECOURSE TO GET THIS CONDITION REPAIRED. ALSO I AM TRYING TO DETERMINE IF THERE IS SOME TYPE OF WARNING BEFORE THIS CONDITION FAILS RESULTING IN AN ACCIDENT. *TR

#10346473 | July 31, 2010

1999 DODGE CARAVAN, SHOCK TOWER RUST, THIS IS NOT JUST COSMETIC RUST, THIS IS SERIOUS STRUCTURAL PROBLEM WHERE THE SUSPENSION CAN FAIL BY BREAKING UP THROUGH THE SHOCK TOWER AND COLLAPSE THE FROM END OF THE VEHICLE. THIS IS A DEFECT BY CHRYSLER AND THEY SHOULD PAY FOR THE REPAIR. I HAVE TWO DODGE CARAVANS AND BOTH HAVE THE SAME SHOCK TOWER RUST PROBLEMS. EVEN THE DODGE DEALERS KEEP MANY REPAIR KITS IN STOCK BECAUSE OF THE LARGE DEMAND. AS THE DODGE CARVANS GET OLDER, THERE WILL BE AN INCREASED NUMBER OF FAILURES AND POSSIBLE SAFETY ISSUES. THE VEHICLES ARE ONLY 10 YEARS OLD, AND HAVE THIS TYPE OF PROBLEM IS JUST WRONG. *TR

#10343872 | July 18, 2010

1999 DODGE CARAVAN. STRUT TOWERS RUSTED OUT NOT ONLY THE CAP BUT THE WHOLE TIRE ON THE DRIVER SIDE. IF THIS SHOULD FAIL IT COULD BE DISASTROUS. I JUST NOTICED THIS A WEEK OR SO AGO. *TR

#10312357 | February 20, 2010

VEHICLE SHOCK TOWERS RUSTING AWAY. FAILURE OCCURS IN MOST OF THESE VEHICLES. VEHICLE IS RENDERED UNSAFE AND COULD CAUSE BODILY HARM TO OCCUPANTS IF CATASTROPHIC FAILURE OCCURS. *TR

#10272594 | June 1, 2009

TL*THE CONTACT OWNS A 1999 DODGE CARAVAN. THE CONTACT STATED THAT THE BODY OF THE VEHICLE WAS SEPARATING FROM THE STRUT MOUNTS. HE FEELS THAT THE STRUT MOUNTS WILL DETACH SOON AND CAUSE THE VEHICLE TO CRASH. THE CURRENT AND FAILURE MILEAGES WERE 155,000. UPDATED 06/08/09 *BF UPDATED 06/09/09.*JB

#843707 | July 29, 1999

WHILE TRYING TO GET INTO THE VAN, DRIVER FELL DOWN AGAINST A METAL STRIP THAT WAS FLAT AGAINST VEHICLE DUE TO NO SUPPORT (NO STEP TO BE USED / HANDLE TO GRAB). VEHICLE WAS A RENTAL. *ML

Other 1999 DODGE CARAVAN Problem Areas

← Back to 1999 DODGE CARAVAN overview