2003 CHEVROLET TRAILBLAZER EXT Fuelpropulsion System Problems

TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER EXT. THE CONTACT STATED THAT FUEL WAS LEAKING NEAR THE BOTTOM REAR OF THE VEHICLE. THE CONTACT INSPECTED UNDERNEATH THE VEHICLE AND NOTICED THAT THE CHECK VALVE WAS FRACTURED. JOE LUNGHAMER CHEVROLET (475 SUMMIT DR, WATERFORD TWP, MI 48328, 1-(248) 683-7100) WAS NOTIFIED AND STATED THAT THE VEHICLE WOULD NEED TO BE DIAGNOSED AND THERE WAS NO FUEL SYSTEM RECALL. THE MANUFACTURER ISSUED EXTENDED WARRANTY CAMPAIGN NUMBER: 14423, BUT THEY HAD NOT PROVIDED A RECALL REMEDY TO PREVENT THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS OUT OF WARRANT. THE FAILURE MILEAGE WAS NOT AVAILABLE.

HAS A BAD GAS SMELL LEAKING GAS SOMEWHERE

THE CHECK ENGINE LIGHT WENT ON AND THERE WAS A STRONG GAS ODOR. GAS HAD ALSO PREVIOUSLY SPILLED OUT WHEN FUELUNG.

PLASTIC WELD CONNECTING FUEL FILL PIPE TO FUEL TANK HAS CRACKED.CONTACTED GM ABOUT THIS ISSUE & WAS INFORMED THAT THIS VEHICLE HAD JUST MISSED THE CAMPAIGN TO FIX THIS PROBLEM BY ONE MONTH. WHY IS THIS CAMPAIGN (07099) A LIMITED TSB & NOT A SAFETY RECALL? VEHICLE WOULD NOT PASS STATE EMISSIONS INSPECTION. TECHNICIAN REPAIRED LEAK WITH EPOXY THAT SEALED LONG ENOUGH TO PREVENT VAPOR LEAKAGE TO PASS EMISSION TEST.NOW THAT HAS FAILED AND ONCE AGAIN VEHICLE WILL NOT PASS EMISSIONS. MORE IMPORTANTLY THE FUEL VAPORS EMITTING FROM VEHICLE MAKE IT UNSAFE AND IMPOSSIBLE TO PARK IN AN ENCLOSED AREA.THIS IS NOT DUE TO A WORN PART OR CORROSION,THIS IS DUE TO A FAULTY DESIGN THAT EVENTUALLY WILL CAUSE AN EXPLOSION.WORSE YET GM OFFERS NO DISCOUNT ON THIS VERY EXPENSIVE TANK ASSEMBLY TO CORRECT THIS PROBLEM.I CAN NOT THINK OF A MORE DANGEROUS CONDITION THAT HAS BEEN SO IGNORED.PERHAPS WHEN...

THE VEHCLE HAS AVERY STRONG SMELL OF GASOLINE INSIDE AND OUT AND IS ALSO STARTING HARD. *TR

I HAVE A 2003 CHEVROLET TRAILBLAZER EXT. ON 03/07/2013 IT STARTED TO LEAK FUEL WHILE PARKED IN THE GARAGE, I TOOK IT TO BEARDMORE CHEVROLET IN BELLEVUE,NEBRASKA TO HAVE IT CHECKED OUT. SERVICE WRITER TOLD ME THERE HAVE BEEN PROBLEMS WITH THE FUEL TANK FILLER NECK CRACKING AND LEAKING ALONG WITH THE FUEL PUMP LEAKING AND POOLING FUEL ON TOP OF THE TANK, THEY INFORMED ME THAT GM HAD A SERVICE LETTER OUT THAT COVERED FULL REPLACEMENT OF TANK,PUMP AND LINES AT NO CHARGE FOR 10YEARS OR 150,000 MILES, I HAVE 81260 MILES AND AN IN SERVICE DATE OF 03/26/03 SO I WAS 10 DAYS OUT OF WARRANTY ON THE REPAIR. DEALER CALLED GM FOR ME AND GOT APPROVAL TO REPAIR THE TRAILBLAZER WITH ME PAYING 500.00 OF THE 2200.00 REPAIR. I TOOK THE DEAL AS THEY COULD HAVE JUST DENIED THE WHOLE CLAIM. SO PEOPLE IF YOU SMELL FUEL...

JUST LIKE SO MANY OF THE OTHER PEOPLE WHO HAVE FILED COMPLAINTS. MY TRUCK TO HAS A VERY STRONG GAS SMELL. I HAVE BEEN TOLD TO REPLACE THE CAP. I HAVE BEEN TOLD TO REPLACE THE FUEL LINE OR FILTER. NOTHING WORKS. IT IS PUZZLING TO ME THAT CHEVROLET IS AWARE OF THIS PROBLEM BUT HAS NOT SENT OUT A RECALL NOTICE TO HAVE THE PROBLEM FIXED. THIS IS A VERY DANGEROUS SITUATION IN WHICH I DRIVE MY FAMILY AROUND AND MY YOUNGEST DAUGHTER LIKES TO RIDE IN THE VERY BACK (THIRD ROLE SEATING). IT IS SCARY TO THINK WHAT COULD HAPPEN. CHEVROLET NEEDS TO FIX THE PROBLEM OR A CLASS ACTION LAWSUIT NEEDS TO BE STARTED. SIMPLE AS THAT. *TR