2020 CHEVROLET SPARK Electrical System Problems

Vehicle caught on fire from the inside somewhere towards the driver side in dash. Instrument cluster and dash completely burnt. Entire inside interior of car burnt

The contact owns a 2020 Chevrolet Spark. The contact stated that after the vehicle was idle at a red light, while attempting to accelerate, the vehicle stalled. The contact attempted to restart the vehicle several times before the vehicle restarted. There were no warning lights illuminated. The contact took the vehicle to the dealer who was unable to identify the cause of the failure. The contact then took the vehicle to another dealer who stated that the battery might have failed. The battery and battery cables were replaced; however, the failure recurred. The manufacturer was made aware of the failure. The approximate failure mileage was 65,719.

Our car broke down on 07/08/2021 and went into the shop on 07/12/2021. It was eventually determined the engine had to be replaced. The car was in the shop until 09/02/2021. The following day during a test drive I noticed some minor, unusual response, almost unnoticeable, from the brakes, but there were no warning lights or messages. I connected a code reader and received the following codes: U0422, U0151, and C0800. I think all of them are sent by the ECU and involve communication problems with the ABS and the restraint systems, but yet, no warnings. I took it back to the shop. They found a shorted or bad Body Control Module, probably caused during the engine swap. If I hadn’t found those codes, perhaps the brakes or restraint systems may not have performed correctly in an accident. Obviously, the BCM can be defective and no warning lights are displayed,...

I SENT THIS UNIT TO THE DEALERSHIP TO HAVE A KEY PROGRAMMED BUT THEY CAN'T PROGRAM THE KEY. THEY SAID THEY NEED FURTHER INFORMATION TO PROGRAM A KEY. PLEASE ADVISE.