2022 CHEVROLET SILVERADO 6500 — Problems, Recalls & Safety Data
N/A
Safety Rating
0
Owner Complaints
1
Recall
12
Service Bulletins
0
Investigations
Overview of the 2022 CHEVROLET SILVERADO 6500
The 2022 CHEVROLET SILVERADO 6500 has received a total of 0 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There has been 1 recall campaign affecting this vehicle, covering issues with SERVICE BRAKES, HYDRAULIC:BRAKE FLUID LOW WARNING:SWITCH/SENSOR/FLOAT. 12 technical service bulletins have been issued by General Motors, LLC for this model year.
Recalls for the 2022 CHEVROLET SILVERADO 6500
NHTSA has recorded 1 recall for the 2022 CHEVROLET SILVERADO 6500, potentially affecting up to 62,468 vehicles.
Recall 25V390000 — SERVICE BRAKES, HYDRAULIC:BRAKE FLUID LOW WARNING:SWITCH/SENSOR/FLOAT
| 62,468 vehicles affected
Defect: General Motors (GM) is recalling certain 2019-2024 Chevrolet Silverado Medium Duty 4500HD, 5500HD, and 6500HD vehicles. The brake pressure sensor assembly may leak brake fluid into the brake pressure switch and cause a short circuit.
Consequence: An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the brake pressure switch wire harness, free of charge. Owner notification letters were mailed September 11, 2025. Owners may contact GM...
View full details →Owner Complaints for the 2022 CHEVROLET SILVERADO 6500
No complaints have been filed with NHTSA for the 2022 CHEVROLET SILVERADO 6500.
Safety Rating for the 2022 CHEVROLET SILVERADO 6500
NHTSA has not yet tested the 2022 CHEVROLET SILVERADO 6500 in its New Car Assessment Program.
Technical Service Bulletins for the 2022 CHEVROLET SILVERADO 6500
General Motors, LLC has issued 12 technical service bulletins (TSBs) for the 2022 CHEVROLET SILVERADO 6500. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
24-NA-115 — ELECTRICAL SYSTEM
Information on Low Beam Headlamp Bulb Diagnosis/Replacement (Inspect Bulb and Connector).
PIP5935B — ENGINE AND ENGINE COOLING
Communicates the need for restriction on 2019 through 2023 6.6L L5D engines
N222384940 — ENGINE AND ENGINE COOLING
Service Update. On certain vehicles, the air compressor coolant outlet port may cause a slow coolant leak at the air compressor on the engine. Dealers are to inspect, and if necessary, replace the automatic level control air compressor.
04-06-04-051H — ENGINE AND ENGINE COOLING
This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
N222365910 — SUSPENSION:REAR:SPRINGS:AIR SUSPENSION SYSTEM
Customer Satisfaction Program. Certain vehicles, equipped with Valve-Air Suspension Air Release (RPO JPZ), were incorrectly invoiced with an Air Suspension Dump Valve and may have been built with the incorrect switch assembly. Dealers will issue a reimbursement check in the amount of $60 USD, replace the switch assembly, and disable...
N222374570 — EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Customer Satisfaction Program - Certain vehicles may have incorrect instructions in the Owner Manual regarding the front spring U-bolt Service torque specification. Dealers will print and insert the revised Owner Manual page(s) for all vehicles. On certain vehicles, dealers will verify the front spring u-bolt torque and, if necessary, replace...
23-NA-027 — ENGINE AND ENGINE COOLING
This technical bulletin provides a procedure to test and replace the high-pressure fuel injector electrical connectors if found the cause of the MIL.
23-NA-008 — ENGINE AND ENGINE COOLING
This technical bulletin provides repair information to correct a customer concern of DEF Pump Controller Update with DTCs P105A and/or P208A Set.
23-NA-008 — ELECTRICAL SYSTEM
This technical bulletin provides repair information to correct a customer concern of DEF Pump Controller Update with DTCs P105A and/or P208A Set.
N222359341 — FUEL SYSTEM, DIESEL
Population expansion for emission recall. Certain vehicles with a 6.6L diesel engine. In cold ambient temperatures when Diesel Emissions Fluid (DEF) in the DEF tank is frozen, the DEF tank pump may be activated before DEF has been sufficiently thawed by the heater. If this condition occurs, the control system...
Showing 10 of 12 technical service bulletins.
NHTSA Investigations for the 2022 CHEVROLET SILVERADO 6500
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the CHEVROLET SILVERADO 6500
- 2019 CHEVROLET SILVERADO 6500 — 0 complaints
- 2020 CHEVROLET SILVERADO 6500 — 0 complaints
- 2021 CHEVROLET SILVERADO 6500 — 3 complaints
- 2022 CHEVROLET SILVERADO 6500 (current)
- 2023 CHEVROLET SILVERADO 6500 — 0 complaints
- 2024 CHEVROLET SILVERADO 6500 — 0 complaints
- 2025 CHEVROLET SILVERADO 6500 — 0 complaints
Other CHEVROLET Models
- CHEVROLET MALIBU — 28,991 total complaints
- CHEVROLET SILVERADO 1500 — 22,175 total complaints
- CHEVROLET IMPALA — 15,197 total complaints
- CHEVROLET TAHOE — 12,511 total complaints
- CHEVROLET EQUINOX — 12,135 total complaints
- CHEVROLET BLAZER — 11,032 total complaints
- CHEVROLET SILVERADO — 10,928 total complaints
- CHEVROLET SUBURBAN — 10,375 total complaints