2019 CHEVROLET SILVERADO 5500 — Problems, Recalls & Safety Data
N/A
Safety Rating
0
Owner Complaints
2
Recalls
8
Service Bulletins
0
Investigations
Overview of the 2019 CHEVROLET SILVERADO 5500
The 2019 CHEVROLET SILVERADO 5500 has received a total of 0 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 2 recall campaigns affecting this vehicle, covering issues with SERVICE BRAKES, HYDRAULIC:POWER ASSIST, SERVICE BRAKES, HYDRAULIC:BRAKE FLUID LOW WARNING:SWITCH/SENSOR/FLOAT. 8 technical service bulletins have been issued by General Motors, LLC for this model year.
Recalls for the 2019 CHEVROLET SILVERADO 5500
NHTSA has recorded 2 recalls for the 2019 CHEVROLET SILVERADO 5500, potentially affecting up to 63,359 vehicles.
Recall 25V768000 — SERVICE BRAKES, HYDRAULIC:POWER ASSIST
| 891 vehicles affected
Defect: General Motors, LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado Medium Duty 4500HD, 5500HD, and 6500HD vehicles. These vehicles were remedied under NHTSA Recall 25V390 with a brake jumper wire harness that was assembled without protective tape. A wiring harness that is missing protective tape can allow the wires to become damaged.
Consequence: Damaged brake jumper wires can result in power brake assist failure, increasing the risk of a crash.
Remedy: Dealers will remove the installed wire harness, apply protective tape, and reinstall the wire harness, free of charge. Owner notification letters are planned to be mailed December 22, 2025. Owners may contact GM customer assistance number at 1-866-467-9700. GM's number...
View full details →Recall 25V390000 — SERVICE BRAKES, HYDRAULIC:BRAKE FLUID LOW WARNING:SWITCH/SENSOR/FLOAT
| 62,468 vehicles affected
Defect: General Motors (GM) is recalling certain 2019-2024 Chevrolet Silverado Medium Duty 4500HD, 5500HD, and 6500HD vehicles. The brake pressure sensor assembly may leak brake fluid into the brake pressure switch and cause a short circuit.
Consequence: An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the brake pressure switch wire harness, free of charge. Owner notification letters were mailed September 11, 2025. Owners may contact GM...
View full details →Owner Complaints for the 2019 CHEVROLET SILVERADO 5500
No complaints have been filed with NHTSA for the 2019 CHEVROLET SILVERADO 5500.
Safety Rating for the 2019 CHEVROLET SILVERADO 5500
NHTSA has not yet tested the 2019 CHEVROLET SILVERADO 5500 in its New Car Assessment Program.
Technical Service Bulletins for the 2019 CHEVROLET SILVERADO 5500
General Motors, LLC has issued 8 technical service bulletins (TSBs) for the 2019 CHEVROLET SILVERADO 5500. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
N232395710 — STRUCTURE:BODY:BUMPERS
Customer Satisfaction Program. Certain vehicles may have been built with a black bumper when the customer ordered a chrome bumper. Dealers will provide the customer with a reimbursement check in the amount of $100.00 USD.
N222365910 — SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM
Customer Satisfaction Program. Certain vehicles, equipped with Valve-Air Suspension Air Release (RPO JPZ), were incorrectly invoiced with an Air Suspension Dump Valve and may have been built with the incorrect switch assembly. Dealers will issue a reimbursement check in the amount of $60 USD, replace the switch assembly, and disable...
23-NA-052 — POWER TRAIN
This informational bulletin provides a comparison sheet for the techs to aid while performing a transfer case teardown, if its cost efficient to repair or replace the t-case .
PIP5853A — POWER TRAIN
This PI communicates to dealers and technicians a possible diode issue in the TCCM, and how to properly diagnose for a diode issue.
N222359341 — ELECTRICAL SYSTEM
Product Emission Recall - General Motors has decided to conduct a Voluntary Emissions Recall on certain vehicles with a 6.6L diesel engine. In cold ambient temperatures when Diesel Emissions Fluid (DEF) in the DEF tank is frozen, the DEF tank pump may be activated before DEF has been sufficiently thawed...
PIP5834A — SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT
This Preliminary information communicates that the service 4wd message related to C119E can be diagnosed and repaired.
PIP5834 — POWER TRAIN:AUTOMATIC TRANSMISSION
This Preliminary information communicates that the service 4wd message related to C119E is under investigation for a repair.
PIP5834 — UNKNOWN OR OTHER
This Preliminary information communicates that the service 4wd message related to C119E is under investigation for a repair.
NHTSA Investigations for the 2019 CHEVROLET SILVERADO 5500
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the CHEVROLET SILVERADO 5500
- 2019 CHEVROLET SILVERADO 5500 (current)
- 2020 CHEVROLET SILVERADO 5500 — 0 complaints
- 2021 CHEVROLET SILVERADO 5500 — 0 complaints
- 2023 CHEVROLET SILVERADO 5500 — 3 complaints
- 2024 CHEVROLET SILVERADO 5500 — 0 complaints
Other CHEVROLET Models
- CHEVROLET MALIBU — 28,991 total complaints
- CHEVROLET SILVERADO 1500 — 22,175 total complaints
- CHEVROLET IMPALA — 15,197 total complaints
- CHEVROLET TAHOE — 12,511 total complaints
- CHEVROLET EQUINOX — 12,135 total complaints
- CHEVROLET BLAZER — 11,032 total complaints
- CHEVROLET SILVERADO — 10,928 total complaints
- CHEVROLET SUBURBAN — 10,375 total complaints