2002 CHEVROLET MONTE CARLO Engine Problems

STARTED CAR AND HEARD A LOUD BOOM AND THEN SMOKE UNDER THE HOOD AND INTAKE COVER AND HARNESS ON FIRE

THE CAR'S FUEL GAGE STOPPED WORKING. THE CAR WOULDN'T TURN OVER WHEN I STARTED IT SO I GOT A NEW BATTERY SINCE IT SAID MY OLD ONE WAS BAD, BUT IT'S STILL NOT WORKING. THE SECURITY LIGHT IS ON AND I DON'T UNDERSTAND WHY AND IF THIS IS AFFECTING IT FROM TURNING ON

2002 CHEVROLET MONTE CARLO. CONSUMER WRITES IN REGARDS TO ENGINE FAILURE AND REQUESTS REIMBURSEMENT FOR ENGINE REPAIRS. *SMD THE CONSUMER STATED THE ENGINE FAILED WHEN OIL GOT ONTO THE ENGINE AND CAUGHT FIRE. THE CONSUMER HAD NOT RECEIVED A RECALL UNTIL AFTER THE FAILURE. THE CONSUMER HAD THE ENGINE REPLACED. THE CONSUMER WOULD LIKE TO BE REIMBURSED FOR THE COST OF THE ENGINE REPLACEMENT. *JS

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHEN THE VEHICLE WAS STARTED, THE CONTACT HEARD A LOUD POPPING SOUND. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE FROM THE ENGINE COMPARTMENT. THE FIRE DEPARTMENT WAS NOTIFIED AND WAS ABLE TO EXTINGUISH THE FIRE. THERE WERE NO INJURIES AND A FIRE REPORT WAS NOT FILED. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED PER NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE THE VEHICLE WAS UNDERGOING A ROUTINE INSPECTION, THE TECHNICIAN NOTICED THAT THE BACK COVER GASKET WAS LEAKING OIL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 21,571.

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, A STRONG BURNING FUEL ODOR WAS PRESENT INSIDE AND OUTSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRONT VALVE COVER GASKET NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 193,000.

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) AND STATED THAT THE PART NEEDED TO PERFORM THE RECALL REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNED A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH, WHEN THE VEHICLE BEGAN TO SMOKE BOTH INSIDE THE VEHICLE AND UNDER THE HOOD OF THE VEHICLE WITHOUT WARNING. THE CONTACT MERGED TO THE SHOULDER OF THE ROAD AND EXITED THE VEHICLE ALONG WITH ALL THE OTHER OCCUPANTS. A FIRE STARTED UNDER THE HOOD OF THE VEHICLE. THE CONTACT ATTEMPTED TO PUT OUT THE FIRE HOWEVER, WAS UNABLE TO LIFT THE HOOD OF THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED AND DEEMED TOTALED. THE TWO OCCUPANTS RECEIVED SMOKE INHALATION AND SLIGHT BURNS TO THEIR ARMS. NO MEDICAL ATTENTION WAS NEEDED. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHENEVER THE VEHICLE WAS STARTED, A BURNING ODOR WAS NOTICED FROM THE FRONT END OF THE VEHICLE. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE CONTACT TOOK THE VEHICLE IN FOR THE RECALL REPAIR AND INFORMED THE DEALER OF THE BURNING ODOR; HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 147,000. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT NOTICED THAT THE ENGINE WAS LEAKING OIL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CAUSE OF THE FAILURE WAS UNDETERMINED. THE MOTOR WAS REPLACED; HOWEVER, THE FAILURE PERSISTED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE HOOD WAS CONSTANTLY HOT AND THERE WERE STRONG FUMES OF FUEL AND BURNING OIL. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE DEALER AND MANUFACTURER REFUSED TO REMEDY THE VEHICLE BECAUSE THE TITLE WAS FOR A SALVAGED VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE ADDING ENGINE OIL TO THE VEHICLE, SMOKE FUMES APPEARED BEFORE THE ENGINE SUDDENLY CAUGHT FIRE. THE CONTACT EXTINGUISHED THE FIRE. THERE WERE NO REPORTS FILED. THE CONTACT DID NOT SUSTAIN ANY INJURIES. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 143,356.

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE, ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE JERKED AND THE COMPUTER TURNED ON AND OFF AS SMOKE EMITTED UNDER THE HOOD. THE CONTACT EXTINGUISHED THE FIRE. A POLICE AND A FIRE REPORT WERE NOT FILED AND THERE WERE NO INJURIES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE FAILURE MILEAGE WAS APPROXIMATELY 119,000.

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, FUMES OF SMOKE EMITTED FROM THE HOOD BEFORE IT CAUGHT ON FIRE. THE FAILURE RECURRED INTERMITTENTLY. THE CONTACT EXTINGUISHED THE FIRE. NO FIRE REPORT WAS FILED. THE CONTACT DID NOT SUSTAIN ANY INJURIES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE AN OFFER TO BUY THE VEHICLE WAS GIVEN BUT THE CONTACT DECLINED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) HOWEVER, THE PART FOR THE RECALL WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNED A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE BEGAN TO SMOKE UNDER THE HOOD AND STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE ENGINE CAUGHT FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND A POLICE REPORT WAS FILED FOR THE INCIDENT. THE CONTACT STATED THERE WERE NO INJURIES THAT REQUIRED MEDICAL ATTENTION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) AFTER THE FAILURE OCCURRED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 225,000. THE VIN WAS NOT AVAILABLE.

TWO ISSUES: (1) THE INTAKE MANIFOLD ON MY 2002 MONTE CARLO 3.8L V6 EXPLODED WHEN THE IGNITION KEY WAS TURNED, AND IT EXPLODED WITH SUCH FORCE THAT THE OIL CAP (SCREWED IN WITH THICK THREADS) WAS BLOWN OFF. HAD MY MECHANIC HAD HIS HEAD UNDER THERE WHEN HIS COUNTERPART TURNED THE KEY IT WOULD HAVE KILLED HIM AS SHRAPNEL FLEW EVERYWHERE. GM HAD A RECALL REGARDING THE EXPLODING OF INTAKE MANIFOLDS ON THIS EXACT ENGINE BUT IT ONLY WENT UP TO MDL YR 2000. THE CIRCUMSTANCES AND EFFECTS ARE IDENTICAL INCLUDING THE ENGINE MODEL. I HAVE PHOTOGRAPHS OF THE CARNAGE THIS EXPLOSION CAUSED BUT WOULD NEED YOUR EMAIL ADDRESS TO SEND THEM TO YOU. (2) AS THE NHTSA IS AWARE, GM HAS RECENTLY ISSUED A THIRD RECALL FOR LEAKING VALVE COVER GASKETS THAT HAVE STARTED FIRES IN THIS SAME VEHICLE. BY SHEER COINCIDENCE ON THE SAME DAY THAT GM ANNOUNCED...

AS THE NHTSA IS AWARE, GM HAS RECENTLY ISSUED A THIRD RECALL FOR LEAKING VALVE COVER GASKETS THAT HAVE STARTED FIRES IN THIS SAME VEHICLE. BY SHEER COINCIDENCE ON THE SAME DAY THAT GM ANNOUNCED THIS THIRD RECALL I PAID MY MECHANIC OVER $300.00 TO REPLACE THESE VALVE COVER GASKETS AND I WANT GM TO REIMBURSE ME FOR THIS. IT WAS POSING A FIRE HAZARD AND WE TRANSPORT OUR YOUNG GRANDCHILDREN IN THIS VEHICLE. I HAVE REPEATEDLY ASKED GM WHY I NEVER RECEIVED ANY RECALL NOTICES RELATIVE TO THE LEAKING VALVE COVERS. THEY HAVE NOT ANSWERED THIS QUESTION. I WANT GM TO REIMBURSE ME FOR THIS REPAIR.

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE BEGAN TO SMOKE. THE CONTACT DISCOVERED OIL ON THE MOTOR AND LEAKING ONTO THE GROUND. THE CONTACT MENTIONED THAT THERE WAS OIL LEAKING FROM THE TOP AND SIDE OF THE MOTOR. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 170,000.

WENT TO START CAR ONE DAY. TURNED KEY AND HEARD LOUD POP. RUSHED TO LIFT GOOD AND TOP OF MOTOR ON FIRE. LUCKILY HAD EXTINGUISHER RIGHT INSIDE GARAGE DOOR AND IMMEDIATELY EXTINGUISHED. PLASTIC INTAKE COVER WAS BLOWN APART IN MULTIPLE PIECES. AFTER SEARCHING ON THE INTERNET I FOUND THERE HAVE BEEN MANY OF THIS SAME INCIDENT, SOMEWHERE CLAIMING THAT IT COMES FROM A FAULTY FUEL SHIFT OF VALVE OR SOMETHING. IF YOU NOTICE WITH LOW MILES, THIS CAR IS BARELY DRIVEN AND ALWAYS BABIED. *TR

WHEN WARM FROM A STANDING STOP THE TRANSMISSION WILL SHUDDER UNDER HARD ACCELERATION . ALSO UP SHIFTS BECOME ERRATIC AND VERY HARSH.

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHEN THE IGNITION WAS TURNED TO THE ON POSITION, THE VEHICLE DID NOT START UNLESS THE CONTACT WAITED FOR TEN MINUTES. THE CONTACT STATED THAT THE KEY WAS REMOVED WHILE THE IGNITION WAS TURNED TO THE ON POSITION AND THE ENGINE REMAINED RUNNING. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000.

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE DRIVING 25 MPH, THE CHECK ENGINE LIGHT ILLUMINATED AND HALF OF THE AIR BAG WAS EXPOSED ON THE PASSENGER SIDE WHEN THE VEHICLE WAS PURCHASED. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT WAS REFERRED TO THE MANUFACTURER. THE APPROXIMATE FAILURE MILEAGE WAS 156,000.

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 55 MPH, THE VEHICLE HAD A SUDDEN LOSS OF POWER AND STALLED. AS A RESULT, THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO A DITCH. THE CONTACT DID NOT SUSTAIN ANY INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT INSPECTED OR DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO RESPOND AND STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTARTED AFTER MULTIPLE ATTEMPTS. IN ADDITION, THE ENTIRE INSTRUMENT PANEL FAILED. ON ONE OCCASION, THE VEHICLE COASTED PAST A STOP SIGN AND ANOTHER VEHICLE CRASHED INTO THE FRONT DRIVER SIDE OF THE VEHICLE. A POLICE REPORT WAS FILED AND THE CONTACT SUSTAINED NECK INJURIES THAT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO A DEALER BUT THE FAILURE WAS UNABLE TO BE DETERMINED. THE CONTACT RECEIVED NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFUSED TO COMPENSATE THE CONTACT. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

WE HAVE BEEN HAVING PROBLEMS WITH OUR CAR STARTING. THE BATTERY HAS BEEN REPLACED. WE HAVE DISCONNECTED THEN RECONNECTED THE BATTERY, SOMETIMES THIS WORKS TO START THE CAR OTHER TIMES IT DOES NOT. THE POWER LOCKS NO LONGER WORK. ONE DAY THE SECURITY LIGHT COMES ON, SOMETIMES ITS NOT YESTERDAY, WE COULDN'T EVEN GET THE CAR TO START. TODAY, THE CAR WAS RUNNING AND THE CLUSTER GAUGES WERE NOT EVEN WORKING. WE BOUGHT THIS CAR BRAND NEW OUT OF THE SHOWROOM. WHAT A LEMON IT TURNED OUT TO BE. SADLY, IT NOW SITS IN OUR DRIVEWAY AS IT IS NOT DEPENDABLE TO DRIVE ANYWHERE. THERE IS A RECALL TO REPLACE THE KEY RINGS, AND AN INSET IN THE KEY SLOT OR A COVER ON THE KEY HEAD INSTEAD GM SHOULD BE RECALLING THESE MODELS TO REPLACE THE IGNITIONS, SINCE THERE ARE OTHER PEOPLE POSTING ONLINE ABOUT THESE SAME ISSUES. *TR

MY FATHER N LAW, N I WERE GOING TO SEE A FAMILY MEMBER 12MILES AWAY FROM HIS HOME, WHEN WE STOPPED. AT THE CONVENIENCE STORE FOR SNACKS, ETC... WE LITERALLY COULDN'T HAVE BEEN OUT OF CAR 5 MIN, WHEN STORE CLERK YELLS HEY SOMEONE'S (CHEVYS) SMOKING? WE SAW IT WAS HIS N WENT TO INVESTIGATE THE PROBLEM I WENT STRAIGHT TO DRIVER SIDE OF VEHICLE N POPPED THE TRUNK(THINKING IT WASN'T MORE THAN A BLOWN RADIATOR HOSE) LORD N HEAVEN WAS I WRONG, THE ENGINE LOOKED AS IF IT WERE ALL ON FIRE...I IMMEDIATELY PUSHED HOOD DOWN N RAN FOR AN EXTINGUISHER LUCKILY THE STORE HAD A GOOD ONE. THIS RECALL AS THE COUNTRY N STATE N MANUFACTURERS, CALL IT IS SERIOUSLY DEADLY, TO B 100 PERCENT HONEST IT IS FLAT OUT WRONG. SOMETHING THIS DEADLY SHOULD B NOTIFIED TO ALL CURRENT OWNERS, OF THE VEHICLES. I SERIOUSLY DOUBT HE...

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE CONTACT MENTIONED THAT AFTER SEVERAL ATTEMPTS THE VEHICLE WAS RESTARTED AND RESUMED NORMAL OPERATION. THE FAILURE RECURRED WHENEVER THE VEHICLE WAS DRIVEN FOR A SHORT DISTANCE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE CAM SENSOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 75,000.

DRIVING ON HWY 31 IN MCHENRY IL 60050 IGNITION TURNED OFF WITH NO WARNING. LOST ALL POWER STEERING BRAKES CAR STOPPED BY RUBBING INTO CURB. WAS NEARLY REAR ENDED BY A PICK UP TRUCK WHICH HAD NO WARNING THAT I WAS SUDDENLY STOPPING TRYING TO MANEUVER OF TRAFFIC. WITH THE CURB AND NO POWER I HAD NO WAY TO GET OFF THE ROAD. *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE STARTING THE VEHICLE, THE ENGINE COMPARTMENT EXPLODED AND CAUGHT ON FIRE. THE CONTACT SUSTAINED INJURIES TO THE ACHILLES TENDON AFTER ATTEMPTING TO EXTINGUISH THE FIRE. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE VEHICLE WAS BEING DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 117,000.

I WAS DRIVING (WITH MY CHILDREN IN CAR) AND THE CAR JUST SHUT OFF. I HAD NO POWER BRAKES OR POWER STEERING. LUCKILY, ONE CHILD WAS IN DRIVERS ED & KNEW TO PUT CAR IN NEUTRAL & WE COASTED TO A STOP. ONCE I CALMED DOWN, I DROVE MY MONTE SS TO THE DEALER AND DESCRIBED WHAT HAPPENED. THE KEPT CAR FOR A WEEK AND INSISTED THERE WAS NOTHING WRONG! I DRIVE 1-3 HRS FOR WORK DAILY AND I DIDN'T TRUST THE VEHICLE ON INTERSTATE. I PURCHASED ANOTHER VEHICLE 6 DAYS LATER BUT GAVE THIS CAR TO MY CHILD FOR IN TOWN DRIVING. I WAS NEVER THE WISER UNTIL I HEARD ABOUT THE RECALL YESTERDAY & IT'S DESCRIPTION. THE MONTE SHOULD BE INVOLVED IN RECALL TOO. I WAS PREPARING TO PURCHASE A NEW IMPALA BUT NOW I BELIEVE GM IS STILL NOT BEING HONEST ABOUT ALL THE MAKES & MODELS...

WENT OUT TO START CAR. TURNED ON KEY, SET RADIO. THEN TURNED KEY TO START ENGINE WITH A RESULTING LOUD EXPLOSION FROM UNDER HOOD. IN HURRY TO GET UP HOOD AND EXTINGUISH FIRE EXPERIENCED BURNS ON HANDS FROM LIFTING HOOD AND A FUEL LINE THAT WAS SQUIRTING FUEL/FLAMES. FIRE EXTINGUISHER EXTINGUISHED FLAMES. UPPER INTAKE MANIFOLD IS BLOW APART WITH MULTIPLE SENSORS DESTROYED. THANK GOD THIS HAPPENED AT HOME WITH AN EXTINGUISHER HANDY AND NOT DRIVING DOWN THE ROAD WITH NO TIME TO SLOW DOWN. *TR

MY 2002 CHEVY MONTE CARLO HAS BEEN EXPERIENCING ELECTRICAL PROBLEMS SINCE I HAVE OWNED IT. THE CRUISE CONTROL COMES ON WITHOUT BEING SELECTED AND THEN THE HEATING/COOLING SYSTEMS GOES OFF AND ON BY ITSELF. THE TURN SIGNAL GOES ON AND OFF. SOMETIMES IT WILL WORK SOMETIMES IT WILL NOT. THE FUEL GAUGE DOES NOT REGISTER CORRECTLY GOES UP AND DOWN SO I AM NEVER SURE WHAT IS IN THE TANK. OCCASIONALLY THE CAR WILL NOT START AT ALL EVEN THOUGH THE LIGHTS WORK, THE RADIO PLAYS, AND EVERYTHING ELSE WILL OPERATE INSIDE THE CAR. I WILL SIT AND WAIT A WHILE. AFTER ABOUT 15-25 MINUTES I WILL TRY TO START IT AND THEN IT WILL START UP. THIS HAS BEEN HAPPENING MORE AND MORE. I HAVE TALKED TO OTHER CHEVY MONTE CARLO OWNER AND THEY HAVE HAD THE SAME PROBLEMS WITH THEIR CAR. *TR

THE PLASTIC INTAKE MANIFOLD CRACKED AND THE ANTIFREEZE WENT INTO THE OIL AND THE ENGINE BLEW UP IN THE MIDDLE OF RUSH HOUR TRAFFIC. *TR

I STARTED THE CAR UP AND I HEARD A POP AND SAW A BLUE FLAME. AFTER REPAIRING THE CAR COSTING $3240.74 IT ONCE AGAIN CAUGHT ANOTHER FIRE PLEASE HELP. *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT AS HE ATTEMPTED TO START THE VEHICLE, THE INTAKE MANIFOLD EXPLODED WITHOUT WARNING. A FIRE ERUPTED AND THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. THE VEHICLE WAS TOWED TO THE DEALER AND WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND LODGED A REPORT FOR THE FAILURE. THE FAILURE MILEAGE WAS 127,000.

I HAVE A 2002 MONTE CARLO SS I GO OUT TO START MY CAR AND IT WON'T START FOR ABOUT 15 MINUTES. THE SECURITY LIGHT COMES ON TO. WHEN I TURN THE KEY IT DOES NOTHING MY LIGHTS AND EVERYTHING WORK IT JUST WON'T START. IF THERE IS ANYWAY I COULD GET HELP PLEASE LET ME KNOW OR LET ME KNOW WHAT I CAN DO TO FIX THIS. THANK YOU! *TR