1996 CHEVROLET IMPALA Electrical Systemwiring Problems
2 NHTSA complaints on file
Electrical Systemwiring Issues in the 1996 CHEVROLET IMPALA
2 electrical systemwiring complaints have been filed with NHTSA for the 1996 CHEVROLET IMPALA. Of these, 0 involved a crash, 0 involved a fire, and 0 resulted in injury.
2
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
All Electrical Systemwiring Complaints
(1) WHILE TRAVELING THRU LAUGHLIN, NV TRAVELING WEST ON HWY 163, CAR ABRUPTLY QUITS. FUEL PUMP FUSE BLOWN. SUSPECT DYING FUEL PUMP. INSTALL NEW FUSE, TRAVEL ANOTHER 30 MILES UP HWY 95...CAR DIES AGAIN. THIS TIME, NO BLOWN FUSE. FUEL PUMP WILL NOT RUN. TOW VEHICLE TO FINAL DESTINATION (LAS VEGAS). (2) PULLED THE TANK, REMOVED THE SENDING UNIT FOR PUMP REPLACEMENT. QUICKLY NOTICED THE PROBLEM. THE FUEL PUMP WIRING INSIDE THE TANK HAD SHORTED OUT. INSULATION BURNT COMPLETELY OFF OF THE PRIMARY PUMP POWER WIRE AND SHORTED INTO THE FUEL QUANTITY GROUND WIRE. CONNECTOR AT TOP OF SENDING UNIT MELTED. (3) REPLACE SENDING UNIT, FUEL PUMP, STRAINER AND FUEL FILTER. *AK
#521159
|
ELECTRICAL FAILURES : WIRING CHAFFED, VSS SIGNAL (NOT SET TO ECM).
Other 1996 CHEVROLET IMPALA Problem Areas
Steeringhydraulic Power Assist System
9 complaints
Visibilitydefrosterdefoggerhvac Systemheater Core
9 complaints
Tires
6 complaints
Fuel System Gasolinestoragetank Assembly
5 complaints
Power Train
5 complaints
Power Traindrivelinedifferential Unit
5 complaints
Electrical System12v24v48v Battery
3 complaints
Fuel System Gasolinedelivery
3 complaints
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip
3 complaints
Steeringhydraulic Power Assistpump
3 complaints
Suspensionfrontcontrol Arm
3 complaints
Unknown Or Other
3 complaints
Visibilitydefrosterdefoggerhvac System
3 complaints
Wheels
3 complaints
Electrical System
2 complaints
Engine And Engine Coolingengine
2 complaints
Engine And Engine Coolingenginegasoline
2 complaints
Fuel System Gasolinedeliveryfuel Pump
2 complaints
Power Trainaxle Assemblyaxle Shaft
2 complaints
Seat Beltsfront
2 complaints
Steeringhydraulic Power Assisthose Piping And Connections
2 complaints
Suspensionfrontcontrol Armlower Ball Joint
2 complaints
Vehicle Speed Control
2 complaints
Air Bagsfrontal
1 complaint
Electrical Systemalternatorgeneratorregulator
1 complaint
Electrical Systemhorn
1 complaint
Electrical Systemwiringfront Underhood
1 complaint
Electrical Systemwiringinteriorunder Dash
1 complaint
Engine And Engine Cooling
1 complaint
Engine And Engine Coolingcooling System
1 complaint
Engine And Engine Coolingcooling Systemhoseslinespipingfittings
1 complaint
Engine And Engine Coolingcooling Systemradiator Assembly
1 complaint
Engine And Engine Coolingexhaust System
1 complaint
Engine And Engine Coolingexhaust Systememission Controlgas Recirculation Valve Egr Valve
1 complaint
Exterior Lightingheadlights
1 complaint
Fuel System Gasolinestoragetank Assemblyfiller Pipe And Cap
1 complaint
Fuel System Otherstoragefuel Gauge System
1 complaint
Power Trainautomatic Transmission
1 complaint
Power Trainautomatic Transmissioncooling Unit And Lines
1 complaint
Seat Beltsfrontanchorage
1 complaint
Seat Beltsfrontbuckle Assembly
1 complaint
Seat Beltsfrontretractor
1 complaint
Seatsfront Assemblypower Adjust
1 complaint
Service Brakes Hydraulic
1 complaint
Service Brakes Hydraulicfoundation Componentsdifferential Proportional Valve
1 complaint
Service Brakes Hydraulicfoundation Componentsdisc
1 complaint
Service Brakes Hydraulicfoundation Componentsdisccaliper
1 complaint
Steeringlinkagesarmidler And Attachment
1 complaint
Steeringrack And Pinionpinion Shaft
1 complaint
Structure
1 complaint
Structurebodydoor
1 complaint
Suspensionfrontcontrol Armlower Arm
1 complaint
Suspensionfrontspringscoil Springs
1 complaint
Suspensionfrontstabilizer Bar
1 complaint
Suspensionrear
1 complaint
Tiressidewall
1 complaint
Tirestreadbelt
1 complaint
Visibilitydefrosterdefoggerhvac Systemrear Window
1 complaint
Visibilitywindshield Wiperwasherlinkages
1 complaint
Wheelsrim
1 complaint