2019 CHEVROLET duplicate SILVERADO 5500 — Problems, Recalls & Safety Data
N/A
Safety Rating
3
Owner Complaints
2
Recalls
29
Service Bulletins
0
Investigations
Overview of the 2019 CHEVROLET duplicate SILVERADO 5500
The 2019 CHEVROLET duplicate SILVERADO 5500 has received a total of 3 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 2 recall campaigns affecting this vehicle, covering issues with SERVICE BRAKES, HYDRAULIC:BRAKE FLUID LOW WARNING:SWITCH/SENSOR/FLOAT, ENGINE. 29 technical service bulletins have been issued by General Motors, LLC for this model year. The most commonly reported problem area is the Engine (2 complaints).
Recalls for the 2019 CHEVROLET duplicate SILVERADO 5500
NHTSA has recorded 2 recalls for the 2019 CHEVROLET duplicate SILVERADO 5500, potentially affecting up to 380,842 vehicles.
Recall 25V390000 — SERVICE BRAKES, HYDRAULIC:BRAKE FLUID LOW WARNING:SWITCH/SENSOR/FLOAT
| 62,468 vehicles affected
Defect: General Motors (GM) is recalling certain 2019-2024 Chevrolet Silverado Medium Duty 4500HD, 5500HD, and 6500HD vehicles. The brake pressure sensor assembly may leak brake fluid into the brake pressure switch and cause a short circuit.
Consequence: An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the brake pressure switch wire harness, free of charge. Owner notification letters were mailed September 11, 2025. Owners may contact GM...
View full details →Recall 19V328000 — ENGINE
| 318,374 vehicles affected
Defect: General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 4500, 5500 and 6500 vehicles and 2017-2019 Chevrolet Silverado 2500 and 3500 vehicles and GMC Sierra 2500 and 3500 vehicles equipped with Duramax 6.6 liter diesel engines and an optional engine-block heater. The engine block heater cord or the terminals that connect the heater cord to the block heater may...
Consequence: A short-circuit may damage the engine components and increase the risk of fire.
Remedy: GM will contact owners, dealers will replace the engine block heater, free of charge. Additionally, in Chevrolet Silverado 2500 and 3500 vehicles, dealers will install a new rerouted heater cord. The recall began December 11, 2019. Owners may contact GM...
View full details →Owner Complaints for the 2019 CHEVROLET duplicate SILVERADO 5500
3 complaints have been filed with NHTSA for the 2019 CHEVROLET duplicate SILVERADO 5500. Below is a breakdown by vehicle component.
| Component | Complaints | Crashes | Fires | Injuries | Deaths |
|---|---|---|---|---|---|
| Engine | 2 | 0 | 0 | 0 | 0 |
| Visibilitywiper | 1 | 0 | 0 | 0 | 0 |
Most Recent Complaints
The contact owns a 2019 Chevrolet Silverado 5500. The contact stated while driving at various speeds, the vehicle loss motive power and stalled. The failure recurred on several occasions with the check engine warning light illuminated. The contact was unable to restart the vehicle. The vehicle was taken to the local dealer however, the mechanic was unable to determine the cause of the failure. The manufacturer was notified of the failure. The failure mileage was 7.
2ND TIME WATER LINE BREAKS SAME AS THE ONE INSTALLED 1 MONTH PRIOR
THIS TRUCK IS BEING USED IN A BOX TRUCK APPLICATION WITH STANDARD 8' WIDE BOX, 16' LONG. THE SIDE MIRRORS THAT COME ON THE 2019 SILVERADO 5500HD DO NOT EXTEND OUT FAR ENOUGH TO SEE SAFELY ALONG THE SIDE OF THE STANDARD 8' BOX. IT IS VERY HARD TO SEE TRAFFIC ON EITHER SIDE AND EXTREMELY DIFFICULT TO BACK UP SAFELY. I NOR THE DEALERSHIP HAS BEEN ABLE TO GET ANY HELP WITH THIS SAFETY ISSUE FROM CHEVROLET FOR OVER A YEAR NOW. I HAVE BEEN TOLD BY A DOT OFFICER THAT I MUST GET THE MIRRORS TO EXTEND OUT FAR ENOUGH TO CLEAR THE BOX IN MY REAR VIEW. I FEEL CHEVROLET SHOULD MAKE THIS A RECALL ISSUE FOR THE SAFETY OF EVERY 5500/6500 TRUCK USED WITH A STANDARD 8' BOX APPLICATION. MY DEALERSHIP SAID CHEVROLET PUT THE EXACT SAME MIRRORS ON THE 2020 MODEL AS WELL. PLEASE HELP!
Safety Rating for the 2019 CHEVROLET duplicate SILVERADO 5500
NHTSA has not yet tested the 2019 CHEVROLET duplicate SILVERADO 5500 in its New Car Assessment Program.
Technical Service Bulletins for the 2019 CHEVROLET duplicate SILVERADO 5500
General Motors, LLC has issued 29 technical service bulletins (TSBs) for the 2019 CHEVROLET duplicate SILVERADO 5500. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
PIT5894C — WHEELS
This Preliminary information communicates Some customers may comment on a vibration while driving. The cause of the condition may be that the wheel and tire assemblies require Road Force balance. Please open a Tac case and provide the following information. Check the valve stems are they pointing at each other (lined...
00-03-10-006P — WHEELS
This service bulletin provides information for dealers/technicians on Tire Radial Force Variation (RFV).
PIT6141 — SERVICE BRAKES
This Preliminary information communicates information on where to install check ball and cap if it separates from the brake booster pump motor.
N212327100 01 — ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
Emission Recall. General Motors has decided to conduct a voluntary emissions recall involving certain vehicles. The Vehicle Emissions Control Information (VECI) label may contain an incorrect certification group identifier. Since a new label can be easily installed, and to reduce customer inconvenience, the label will be sent directly to customers...
20NA212 — ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
This technical bulletin provides repair information to correct a customer concern of IPC Gauges Inoperative or Fluctuate, No Crank, Start then Stall.
20NA030 — SUSPENSION
This service bulletin provides a procedure to correct a customer concern of Rear Air Suspension Inoperative.
PIT5719A — SERVICE BRAKES, HYDRAULIC
This Preliminary information communicates information on the brake booster pump running at all times even with ignition off. Dealer is to disconnect the brake pipe pressure switch to verify it concern is corrected, if so dealer is to replace the switch. GM Engineering is currently root causing this concern.
N202300240 — POWER TRAIN
Customer Satisfaction Program - certain vehicles may have a condition of a transfer case fluid leak below the front input shaft bearing retainer or at the idler pulley bearing retainer. Dealers are to inspect and if necessary, replace two o-rings on the transfer case.
19NA164 — ENGINE
This technical bulletin provides a procedure to index the front drive shaft rear yoke to correct the customers concern.
PIP5687 — FUEL SYSTEM, GASOLINE
This Preliminary information communicates A vehicle may have a concern of the SES light on The technician may find P11CC set alone If this is the first occurance of this code being set with no other codes set, it may be caused by inproper learning of the fuel system adaptation. Please...
Showing 10 of 29 technical service bulletins.
NHTSA Investigations for the 2019 CHEVROLET duplicate SILVERADO 5500
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the CHEVROLET duplicate SILVERADO 5500
- 2019 CHEVROLET duplicate SILVERADO 5500 (current)
Other CHEVROLET Models
- CHEVROLET MALIBU — 28,991 total complaints
- CHEVROLET SILVERADO 1500 — 22,175 total complaints
- CHEVROLET IMPALA — 15,197 total complaints
- CHEVROLET TAHOE — 12,511 total complaints
- CHEVROLET EQUINOX — 12,135 total complaints
- CHEVROLET BLAZER — 11,032 total complaints
- CHEVROLET SILVERADO — 10,928 total complaints
- CHEVROLET SUBURBAN — 10,375 total complaints