2015 CHEVROLET CITY EXPRESS — Problems, Recalls & Safety Data

The contact owns a 2015 Chevrolet City Express. The contact received notification of NHTSA Campaign Number: 25V676000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that upon exiting the vehicle on several occasions, the contact felt an electrical shock from the exterior of the front driver's side door. The contact had replaced the batteries; however, the failure persisted. Additionally, the contact stated that the vehicle was difficult to start. The contact stated that upon disconnecting the fuel pump fuse and connecting an aftermarket fuse to the vehicle, the vehicle was able to start. The contact switched the original and the aftermarket fuse as needed to start the vehicle. There was no warning light illuminated. The contact stated that the vehicle recently failed to start. The contact received a second recall notification, and the vehicle was towed to the dealer, where the contact was informed that a wiring harness needed to be replaced; however, the recall part was not yet available and needed to be ordered. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 107,000.

The contact owns a 2015 Chevrolet City Express. The contact’s spouse stated that while starting the vehicle, the message “Passenger Air Bag Off” was displayed. The vehicle was taken to the dealer; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 95,920.

The contact owns a 2015 Chevrolet City Express. The contact stated that while operating the vehicle, the front driver's and passenger’s side air bag warning lights remained illuminated. The contact stated that initially the front passenger’s side warning light was illuminated and one month later the front driver’s side air bag warning light remained illuminated. The cause of the failure has not yet been determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 33,000.

I had purchased a set of four Cooper Discoverer HT3 185/60R15C 94T C Tires on 09/11/20. Since that time, three of the four Tires have failed due to Sidewall Failure. Luckily, the scenarios did not result in "Blowouts" in which control of the vehicle would have been compromised. I returned to the National tire and Battery where the tires were purchased after the first incident and was told that the Sidewall Damage was my fault as I had obviously hit a curb. I informed the young man in charge that this was highly unlikely as it was the inner Sidewall of the Tire and no "Scuff Marks" were present. He declined to assist me in any warranty replacement as I did not purchase their "Road Hazard Insurance". His attitude and lack of assistance has ended my affiliation with NTB!07

My vehicle was never corrected for the Recall described below, from my recollection. My understanding is that the 2015 Chevrolet City Express van was recalled due to an issue with the passenger-side airbag sensor, which could incorrectly classify an adult passenger as a child or classify the seat as empty despite it being occupied. The defect: in affected vehicles, the front seat passenger Occupant Classification System (OCS) may incorrectly classify an adult passenger as a child or classify the seat as empty despite it being occupied. As a result, the passenger frontal air bag may be turned off and not deploy in the event of a crash. The hazards: if the passenger frontal air bag does not deploy as intended in the event of a crash, the passenger is at an increased risk of injury. Affected vehicle: Chevrolet 2015-2016 Chevrolet City Express [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).