2003 CHEVROLET CAVALIER Engine And Engine Cooling Problems

WAS IN THE FAST LANE AND CAR SHUT OFF AND TRIED TO RESTART BUT IT WOULD NOT. WAS STUCK IN THE ROAD CARS HONKING CAR WOULD NOT RESTART. *TR

WAS AT A STOP LIGHT AND CAR JUST KONKED OUT AND WOULD NOT START AGAIN. I TRIED AND TRIED BUT TO NO AVAIL. HAD TO PUSH IT INTO A GAS STATION ABOUT 100 YARDS, NOT EASY AS A 50 YEAR OLD FEMALE (NO ONE STOPPED TO HELP ME, JUST SPED BY). I HAVE SEEN HUNDREDS OF COMPLAINTS ON-LINE THAT THIS HAS BEEN AN HABITUAL PROBLEM WITH THIS MAKE AND MODEL. IT ONLY HAS 71,000 MILES ON IT AND I JUST PURCHASED THE FIRST PART OF 2012???? WHAT IS UP? THIS MANY PROBLEMS SHOULD HAVE INVOLVED A RECALL! *TR

I HAVE A 2003 CHEVY CAVALIER STALLS : CHANGED THE FUEL PUMP , PRESSURE SOLENOID SWITCH ,TORQUE CONVERTER CLUTCH SOLENOID .TIRED OF THIS AND NO ONE DOING ANYTHING ABOUT IT STILL STALLS AND ALL EVERYONE CAN DO IS GUESS AT WHAT IT IS I HATE MY CAVALIER THE LAST THREE YEARS I HAD PROBLEMS WITH THE CATALYTIC CONVERTER GOT THAT FIXED AFTER THREE CONVERTERS HELP. *TR

TL*THE CONTACT OWNS A 2003 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE OCCURRED WHILE DRIVING OR AT A TRAFFIC LIGHT WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE WITHOUT INCIDENT WHENEVER THE FAILURE OCCURRED. THE MECHANIC REPLACED THE FUEL PUMP, BUT THE FAILURE OCCURRED AGAIN ALMOST ONE YEAR LATER. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 60,000. UPDATED 5/2/11 *CN UPDATED 05/13/11

ABS, TRAC OFF AND CHECK ENGINE LIGHTS STAY ON. THERE IS A TSB ON THIS BUT SINCE IT AFFECTS BRAKE OPERATION THIS SHOULD BE A MANDATORY RECALL. *TR

I WAS DRIVING MY CAVALIER TO PICK UP MY WIFE. AS I APPROACHED AN INTERSECTION, THE SYSTEM COMPLETELY SHUT OFF AND I COULD NOT RESTART THE CAR. I WAS ABLE TO STOP AT THE BEGINNING OF A LEFT TURN LANE AND PUT MY HAZARDS ON. WITH THE HELP OF MY PASSENGER AND A POLICE OFFICER, WE MOVED THE CAR ACROSS 2 LANES OF TRAVEL TO THE SHOULDER. THE CAR HAD 116,000 MILES AT THE TIME OF THE INCIDENT. THE ONLY WARNING BEFORE THE CAR LOST ALL POWER AND DRIVE-ABILITY WAS THE BATTERY LIGHT TURNING ON BRIEFLY. *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET CAVALIER. THE CONTACT STATED THAT INTERMITTENTLY WHILE IN IDLE THE VEHICLE STALLLED. AS A CONSEQUENCE, HIS RISK FOR A VEHICLE CRASH INCREASED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE TECHNICIANS HAVE BEEN UNABLE TO IDENTIFY THE CAUSE OF THE FAILURE. NO REPAIRS HAVE BEEN MADE. THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 92,000 AND THE CURRENT MILEAGE WAS 98,000.

I OWN A 2003 CHEVROLET CAVALIER LS SEDAN WITH APPROXIMATELY 86,300 MILES ON IT. WITHOUT WARNING THE CAR DIED AND WOULD NOT START ON A BUSY JULY 4TH WEEKEND ALONG I-55 NORTH BOUND NEAR LITICHFIELD, IL. I T WOULD NOT RESTART, AND SUBSEQUENT INVESTIGATION RESULTED IN THE FACT FINDING THAT IT WAS THE FUEL PUMP. APPARENTLY THIS IS A MAJOR PROBLEM WITH THIS MAKE AND MODEL VEHICLE. I REQUEST THAT GM BE REQUIRED TO RECALL THIS MAKE AND MODEL TO ADDRESS THE PROBLEM AND REIMBURSE OWNERS FOR OUT OF POCKET EXPENSES. I HAVE ALWAYS OWNED AMERICAN CARS, BUT AN SERIOUS CONSIDERING A TOYOTA NEXT YEAR. *TR

TL*THE CONTACT OWNS A 2003 CHEVROLET CAVALIER. WHILE DRIVING 65 MPH, THE CONTACT STATED THAT THE VEHICLE SHUT OFF AND THE BRAKES FAILED. SHE THEN NOTICED THAT THE STEERING BECAME STIFF. SHE WAS ABLE TO SAFELY MANEUVER THE VEHICLE TO THE SHOULDER AND HAD IT TOWED TO HER DESTINATION. THE CONTACT DID NOT NOTICE ANY WARNINGS PRIOR TO THE FAILURE. SHE IS IN THE PROCESS OF TAKING THE VEHICLE TO THE DEALER FOR INSPECTION. THE MANUFACTURER ADVISED HER TO TAKE THE VEHICLE TO THE DEALER FOR INSPECTION. SHE WOULD NOT BE COMPENSATED FOR THE REPAIRS BECAUSE THERE WAS NO RECALL AVAILABLE. THE FAILURE MILEAGE WAS 79,000.

I PURCHASED MY 2003 CAVALIER BRAND NEW WITH 106 MILES ON IT (IT HAD TO BE DRIVEN FROM PITTSBURGH TO HARRISBURG). IN LATE SEPT. OR EARLY OCT. MY CAR BEGAN RATTLING AT STOP LIGHTS. THE DAY AFTER THE RATTLING STARTED, MY CAR STALLED AT MY PLACE OF BUSINESS AND WOULDN'T START AGAIN. A TRIPLE A MECHANIC WAS CALLED AND COULDN'T DETERMINE WHAT THE PROBLEM WAS EXCEPT HE THOUGHT IT WAS THE FUEL PUMP. AFTER HAVING THE VEHICLE TOWED TO A GARAGE, I WAS TOLD THAT OIL WAS NOT MAKING ITS WAY THROUGH MY ENGINE CAUSING FRICTION AND IN TURN CAUSING MY ENGINE TO EXPAND BREAKING MY TIMING CHAIN AND BASICALLY RENDERING THE ENTIRE ENGINE USELESS. THE MECHANIC ASKED ME IF MY CHECK ENGINE LIGHT OR OIL LIGHT WAS LIT ON MY DASHBOARD BECAUSE WITH A PROBLEM WITH THE OIL PUMP, ONE OF THOSE LIGHTS WOULD HAVE LIT UP, WHICH I...

MY 2003 CHEVY CAVALIER HAS BEEN EXPERIENCING INTERMITTENT STARTUP ISSUES AND OCCASIONAL "CHUGGING" WHILE DRIVING - SEEMED LIKE THE CAR WOULD LURCH AHEAD AT TIMES, HAS ALSO BRIEFLY STALLED AT LIGHTS. ON 10/11/08, THE CAR WOULD BRIEFLY TURN OVER AND START FOR LESS THAN A MINUTE, SHUT OFF, AND AFTERWARDS REFUSED TO START. HAD CAR TOWED FROM MY RESIDENCE TO MECHANIC SHOP WHO ALERTED ME THAT FUEL PRESSURE WAS LOW. FUEL ELECTRONICS WERE FUNCTIONING AS PER COMPUTER CHECK, TURNED OUT TO BE A BAD FUEL PUMP. CAR IS AT ~110,300 MILES. HAD SPARK PLUGS, FUEL FILTER, ENGINE BELT REPLACED IN MARCH & APRIL OF 2008. *TR

COMING HOME FROM MILWAUKEE AT 12:30 AM WITH SON AFTER SEEING RACE IN SLINGER, WI. ON INTERSTATE, CAR LOST COMPLETE ENGINE POWER AND BECAME DEAD. CLOSEST GM DEALERSHIP IN WATERTOWN, WI WENT OUT OF BUSINESS LAST YEAR (PER TOW TRUCK DRIVER). HAD TOWED TO DEALERSHIP WHERE THEY DIAGNOSED A BAD FUEL PUMP AND A PRICE OF OVER $800. CAME TO PICK UP WITH A TRAILER AND ASKED FOR HELP PUSHING CAR ON TRAILER. THEY SAID YOU COULD DRIVE IT UP AS THE MECHANIC TAPPED THE FUEL TANK AND IT STARTED. DROVE AROUND THE BLOCK A FEW TIMES LAST WEEK WITH NO PROBLEMS. I EXPLAINED THIS TO GM, TOLD THEM ABOUT THEIR POOR DESIGN AND THAT THIS IS NOT SAFE BECAUSE IT WILL FAIL AT ANY TIME AND COULD CAUSE A MAJOR ACCIDENT. WAS GIVEN CASE #71-648948392 (TOLD NO RECALLS WERE AVAILABLE PER MY VIN #). CHECKED ON INTERNET (TOPIX.COM) AND...

THE CAR STALLS AT LOW SPEEDS (UP TO 15 MPH) AND HAS BEEN INCREASINGLY DOING SO LATELY. I WAS NEARLY HIT BY A TRACTOR TRAILER WHEN THE CAR STALLED AS I WAS CROSSING A HIGHWAY. MY WIFE HAS BEEN NEARLY HIT SEVERAL TIMES AND I AM FEARING THAT IF A RECALL ISN'T GIVEN ON THESE CARS PEOPLE, INCLUDING MY WIFE AND I, MAY BE SERIOUSLY INJURED. WE ARE GOING TO TRY TO REPLACE THE FUEL PUMP TO SEE IF THIS HELPS THE PROBLEM. THE MILEAGE IS APPROXIMATELY 77,000. *TR

TL*THE CONTACT OWNS A 2003 CHEVROLET CAVALIER. WHILE DRIVING 35 MPH, THE VEHICLE BEGAN TO STALL WHENEVER THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE FELT AS IF IT WERE SLIPPING, WHICH EVENTUALLY LED TO IT STALLING OUT COMPLETELY. THE CONTACT DID NOT NOTICE ANY DIFFERENCES IN THE VEHICLE PRIOR TO THE FAILURES. THE VEHICLE HAD TO BE TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 67,000.

TL*THE CONTACT OWNS A 2003 CHEVROLET CAVALIER. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED IN THE MIDDLE OF TRAFFIC. THE VEHICLE WAS ABLE TO BE RESTARTED. THE FOLLOWING DAY, THE CONTACT ATTEMPTED TO START THE VEHICLE, BUT IT WOULD NOT START FOR APPROXIMATELY TEN MINUTES. THE FOLLOWING DAY, THE VEHICLE WOULD NOT RESTART AGAIN, BUT DID LATER IN THE DAY AND WAS DRIVEN INTO THE CONTACT'S DRIVEWAY. NO REPAIRS HAVE BEEN MADE. THE CURRENT AND FAILURE MILEAGES WERE 35,000.

TL*THE CONTACT OWNS A 2003 CHEVROLET CAVALIER. WHILE DRIVING 30 MPH, THE VEHICLE SHUT OFF IN THE MIDDLE OF THE ROAD WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE FUEL PUMP FAILED AND MADE THE REPLACEMENT. A FEW DAYS AFTER THE REPAIR, THE HEADLIGHTS STOPPED WORKING AND THE ELECTRICAL SYSTEM WAS REWIRED. RECENTLY, THE ENGINE FAILED AND THE VEHICLE WAS TOWED TO THE DEALER. THE CONTACT DOES NOT YET KNOW THE CAUSE OF THE FAILURE AND THE VEHICLE IS STILL AT THE DEALER FOR REPAIR. THE FAILURE MILEAGE WAS 73,000. UPDATED 06/16/08 *BF

ON AT LEAST 10 OCCASIONS, MY CAR HAS STALLED UPON DECELERATION. HAS HAPPENED ON HIGHWAY, STOPPING AT LIGHTS AND WHILE SLOWING DOWN TO TURN. MY CAR HAS 15,000 MILES ON IT. CANNOT DETERMINE SOURCE OF PROBLEM. *TR

TL*THE CONTACT OWNS A 2003 CHEVROLET CAVALIER. THE CONTACT HAD TO MAKE SEVERAL ATTEMPTS TO START THE VEHICLE. ONCE STARTED, THE VEHICLE WOULD NOT ACCELERATE PROPERLY. ON TWO OCCASIONS, WHILE DRIVING BETWEEN 35-55 MPH, THE ENGINE FAILED. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 73,000 AND FAILURE MILEAGE WAS 65,000.

2003 CAVALIER ENGINE STALL ON RED LIGHTS/ COMING TO STOP/ TURNING CORNERS AT LOW IDLE SPEEDS CAUSING A LOSS IN POWER STEERING AND ABS. CHECK ENGINE LIGHT ACTIVE, IMMEDIATE RESTART IS AVAILABLE, HOWEVER WHILE TURNING HAS NEARLY CAUSED ACCIDENTS. BELIEVED TO BE CAUSED DUE TO FAULTY WIRING TO INTAKE TEMP SENSOR. *TR

YESTERDAY MY HUSBAND WAS DRIVING HOME FROM WORK AND CAME TO A STOP LIGHT AS HE SLOWED DOWN THE ENGINE JUST CUT OFF. THIS SAME THING HAPPENED LAST YEAR ONCE AND THE CAR DEALER LINDSAY CHEVROLET SAID IT WAS NOT A PROBLEM. I AM NOW FINDING THAT HARD TO BELIEVE. *TR

CHECK ENIGINE LIGHTS AND ETC. *AK

1. VEHICLE MADE A MOANING NOISE WHEN TURNING AT APPROXIMATELY 55,000 KMS (AND 3 YEARS OLD). REPLACED POWER STEERING PUMP AND STEERING RACK. 2. RANDOM CLUNKING FROM THE FRONT END AT APPROX. 56,000 KMS. REPLACED FRONT BEARINGS AND TRANSMISSION MOUNT. 3. CAR LOST POWER, HAD TO BE TOWED TO DEALERSHIP. DEALER COULDN'T FIND A PROBLEM, INSISTED THE CAR WAS FINE. I INSISTED ON THEM TAKING IT OUT AGAIN. CAR BROKE DOWN, HAD TO BE TOWED BACK TO DEALER AGAIN. REPLACED CATALYTIC CONVERTER AND FUEL IGNITION SWITCH. 4. BURNED THROUGH 4L OF OIL AND PUFFED OUT BLACK SMOKE. DEALER COULDN'T LOCATE PROBLEM. HAPPENED AGAIN APPROX. 2000 KMS LATER. FAULTY PISTON RINGS, ENGINE REPLACED ENTIRELY. AT 61,000 KMS. NOW AT OVER $11,000 CDN WARRANTY REPAIRS ON A WELL MAINTAINED LOW MILEAGE CAR. 5. RANDOM CLUNKING NOISE IN FRONT IS BACK. GOING TO DEALER TOMORROW. WARRANTY: EXPIRED. *JB

DT: THE CONTACT OWNS A 2003 CHEVROLET CAVALIER. SAFETY DEFECT IS AUTOMATIC TRANSMISSION. VEHICLE ROLLS BACK WHILE ON A HILL. WHILE IT IS IN DRIVE IT ACTS AS IF IT WAS STANDARD TRANSMISSION. HAPPENED ON AND OFF SINCE 2003. *AK THE CONSUMER STATED THE VEHICLE IDLES TOO LOW WHICH CAUSED THE VEHICLE TO ROLL BACKWARDS. *JB

WHILE DRIVING 30 MPH VEHICLE STALLED. CONSUMER MANAGED TO PULL OVER, AND HAD THE VEHICLE TOWED. DEALERSHIP REPAIRED THE PROBLEM. *AK

FIRE IN DRIVER SIDE ENGINE COMPARTMENT OF CHEVROLET CAVALIER. DRIVER STATED VEHICLE SHUT OFF IN TRAFFIC. UPON RE-STARTING, NOTICED SMOKE COMING FROM UNDER ENGINE HOOD, DRIVER SIDE. DRIVER GOT OUT AND SAW FLAMES IN AREA OF DRIVER SIDE ENG. COMPT. *AK

1. BOTH BRAKE LIGHTS WENT OUT W/IN MONTH OF EACH OTHER. IN THE MONTHS OF JULY AND AUGUST. 2. BRAKES NOISY, SEPTEMBER 3. TRUNK WOULD NOT OPEN, OCTOBER 4. BRAKES NOISY, AGAIN, NOVEMBER 5. CAR TURNS OFF IN THE MIDDLE OF AN INTERSECTION AFTER MAKING A COMPLETE STOP AND TRYING TO SPEED UP. FREAKING OUT, I PRESSED THE GAS AND MOVED THE KEY IN THE IGNITION, THEN PUT CAR IN PARK AND GOT IT TO START, NOVEMBER. IT JUST SEEMS TO ME THAT I HAVE A DISFUNCTIONAL CAR THAT WHEN I DONT HAVE SOMETHING WRONG WITH ONE THING I HAVE TO GO IN TO THE DEALER FOR ANOTHER. ITS A NEW CAR AND ITS COSTING ME MORE PROBLMES AND INCONVINIENCES THAN THE OLD '96 I HAD TILL I BOUGHT THIS ONE.

AFTER ENGINE WARMS UP ON HOT DAY, ENGINE STALLS WHEN CLUTCH IS DEPRESSED AS WHEN COASTING TO A STOP. ENIGINE WILL RESTART, BUT ACCELLERATOR MUST BE DEPRESSED TO REV THE ENGINE IN ORDER TO PREVENT STALLING. IF VEHICLE IS PARKED FOR SEVERAL MINUTES, THEN RESTARTED, PROBLEM WITH STALLING IS GONE. THIS PROBLEM IS VERY INTERMITTENT. THE SAME PROBLEM IS DESCRIBED IN OID NUMBERS 10049266, 10039337 AND 10037496.

WHEN THE CLUTCH IS DEPRESSED AFTER HIGHWAY DRIVING AT 55-70MPH FOR 30-60 MINUTES, THE ENGINE RPM RATE INCREASES FROM AROUND 2500 TO 3500 INSTEAD OF FALLING TO 1000 (NORMAL IDLE). IF THE CLUTCH IS RE-ENGAGED THEN THE RPM RATE RETURNS TO THE NORMAL RANGE FOR THE GEAR/SPEED OF TRAVEL. IF THE CAR IS BRAKED TO A COMPLETE STOP, THE RPM RATE FALLS TO THE NORMAL IDLE RATE AFTER 20-40 SECONDS OF STANDSTILL. THE BEHAVIOR HAS BEEN OBSERVED EVERYTIME EXTENDED HIGHWAY DRIVING IS COMPLETED. THE PROBLEM HAS BEEN REPORTED TO THE DEALERSHIP AND THE ON-BOARD DIAGNOSTIC SHOWS NO PROBLEM AND THE DEALERSHIP CAN NOT RECREATE THE PROBLEM.