2006 CHEVROLET C4500 — Problems, Recalls & Safety Data
N/A
Safety Rating
7
Owner Complaints
3
Recalls
3
Service Bulletins
0
Investigations
Overview of the 2006 CHEVROLET C4500
The 2006 CHEVROLET C4500 has received a total of 7 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 3 recall campaigns affecting this vehicle, covering issues with TRAILER HITCHES, EQUIPMENT ADAPTIVE/MOBILITY, SUSPENSION. 3 technical service bulletins have been issued by General Motors, LLC for this model year. The most commonly reported problems involve the Engine And Engine Coolingenginediesel (2 complaints), Electrical System (1 complaint), and Engine And Engine Cooling (1 complaint).
Recalls for the 2006 CHEVROLET C4500
NHTSA has recorded 3 recalls for the 2006 CHEVROLET C4500, potentially affecting up to 725 vehicles.
Recall 08V344000 — TRAILER HITCHES
| 108 vehicles affected
Defect: KNAPHEIDE IS RECALLING 108 MY 2006-2008 PRO SERIES TRUCK BEDS EQUIPPED WITH AN ICC BUMPER WHICH INCLUDED A PROVISION FOR A BALL HITCH. THERE MAY BE AN INSUFFICIENT WELD ATTACHING THE HITCH CHANNEL TO THE SUPPORTING STRUCTURE.
Consequence: THIS COULD RESULT IN BENDING OF THE HITCH CHANNEL OR THE HITCH COULD BE PULLED OFF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: KNAPHEIDE WILL OFFER TWO REMEDIES TO ITS CUSTOMERS: (1) FOR THOSE CUSTOMERS WHO DO NOT USE THE HITCH, THE HITCH WILL BE REMOVED FROM THE TRUCK BED AND REPLACED WITH AN ICC BUMPER; OR (2) FOR THOSE CUSTOMERS WHO NEED...
View full details →Recall 08E004000 — EQUIPMENT ADAPTIVE/MOBILITY
| 250 vehicles affected
Defect: CERTAIN INTERMOTIVE WHEELCHAIR LIFT INTERLOCK, P/NO. ILIS605-H3 ILIS ACTIVATION KIT (INTERLOCK OPTION FOR GATEWAY 401) SOLD FOR USE AS AFTERMARKET FOR 2005 - 2008 CHEVY 560 (C4500 AND C5500 KODIAK) 6.6L DIESEL VEHICLES WHICH A PROTECTION DIODE WAS USED. THE DIODE CAN BE EXPOSED TO VOLTAGE SPIKES GREATER THAN WHAT IT CAN WITHSTAND. THE DIODE COULD FAIL, WHICH COULD PREVENT...
Consequence: SHOULD THE DIODE FAIL, IT WILL BE POSSIBLE TO MOVE THE VEHICLE WITH THE WHEELCHAIR DEPLOYED, WHICH COULD RESULT IN INJURY TO ANYONE USING THE LIFT.
Remedy: INTERMOTIVE WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 20, 2007. OWNERS CAN CONTACT INTERMOTIVE TOLL-FREE AT 1-800-969-6080. THIS RECALL ONLY PERTAINS TO AFTERMARKET INTERMOTIVE WHEELCHAIR LIFTS AND HAS NO RELATION TO ANY...
View full details →Recall 07E086000 — SUSPENSION
| 367 vehicles affected
Defect: CERTAIN LINK ULTRARIDE REAR AIR SUSPENSION SYSTEMS, MODEL 8M000070, SOLD FOR INSTALLATION AS AFTERMARKET EQUIPMENT ON GM CHASSIS MODELS 4500 AND 5500, AMBULANCES AND SHUTTLE BUSES. THE AXLE SIDE LATERAL CONTROL BRACKET OF THE SUSPENSION HAS CRACKED IN SOME CASES.
Consequence: IF THE LATERAL CONTROL ROD BRACKET FRACTURES, THE HANDLING OF THE VEHICLE WILL BE ADVERSELY AFFECTED, INCLUDING POSSIBLE LOSS OF VEHICLE CONTROL.
Remedy: LINK WILL NOTIFY OWNERS AND PROVIDE REPAIR KITS FREE OF CHARGE AND WILL REIMBURSE FOR LABOR AND INSPECTION COSTS. THE RECALL BEGAN JUNE 7, 2007. OWNERS CAN CONTACT LINK TOLL-FREE AT 1-800-222-6283.
View full details →Owner Complaints for the 2006 CHEVROLET C4500
7 complaints have been filed with NHTSA for the 2006 CHEVROLET C4500. Below is a breakdown by vehicle component.
| Component | Complaints | Crashes | Fires | Injuries | Deaths |
|---|---|---|---|---|---|
| Engine And Engine Coolingenginediesel | 2 | 0 | 0 | 0 | 0 |
| Electrical System | 1 | 0 | 0 | 0 | 0 |
| Engine And Engine Cooling | 1 | 0 | 0 | 0 | 0 |
| Seats | 1 | 0 | 0 | 0 | 0 |
| Service Brakes Hydraulic | 1 | 0 | 0 | 0 | 0 |
| Wheelslugsnutsboltsstuds | 1 | 0 | 0 | 0 | 0 |
Most Recent Complaints
DRIVER HEARD A LOUD POP WHILE DRIVING ON THE HIGHWAY. PULLED OVER AND SAW COOLANT DRIPPING FROM THE UNDERSIDE OF THE VEHICLE. OPENING THE HOOD HE SAW THE FAN SHROUD WAS BROKEN. AFTER BEING TOWED WE REALIZED THAT THE FAN HAD BROKEN AND PIECES HAD HIT THE SHROUD SHREDDING IT AND SENDING A PIECE INTO THE RADIATOR. *TR
ACCELERATING FROM STOP LIGHT, 5:45 CST, 92 DEGREES/HUMID, 15MPH, 150' INTO INTERSECTION LOUD NOISE. COOLING FAN DISINTEGRATED & TOOK OUT ALL HOSES, RADIATOR & BOTH RADIATOR SHROUDS. CURRENTLY AT DEALER, LOWER RADIATOR HOSE NO LONGER MADE. *TR
RECENTLY, THE FAN EXPLODED ON MY 2006 CHEVROLET C-4500 AND DESTROYED THE COWLING AROUND THE FAN AND TORE HOLES IN THE RADIATOR AND HOSES INTO THE INTERCOOLER. I WAS PULLING A HEAVY 5TH WHEEL RV. GLAD IT DID NOT HAPPEN WHEN I WAS CHANGING THE FUEL FILTER A FEW DAYS BEFORE. UPDATED 09/23/10 *BF THE CONSUMER STATED THE FAN BLADE FAILED. THE OUTER RING CAME APART AND DESTROYED THE COWLING AROUND THE FAN AND MADE HOLES IN THE RADIATOR CAUSING ANTI-FREEZE TO LEAK OUT. UPDATED 09/24/10 *TR
TL*THE CONTACT OWNS A 2006 CHEVROLET C4500. THE CONTACT STATED THAT THERE WERE NUTS THAT HOLD THE BEARINGS AND WHEELS TOGETHER, INCLUDING A SPECIAL ONE FOR JUST THE WHEEL. ONE OF THE NUTS IS LOOSE AND MOVES BACK AND FORTH. THE FAILURE CHEWS AWAY AT THE TREAD OF THE SPINDLE THAT HOLDS THE AXLE. IF THE TREAD CONTINUES TO DISINTEGRATE, THE WHEEL COULD FALL OFF. THE MANUFACTURER STATED THAT THE EXTENDED WARRANTY DID NOT COVER THE HUB THAT NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 31,000.
TRUCK HAS OPTIONAL AIR SUSPENSION SEATS. SEAT RELIES ON COMPRESSOR AND TANK TO BE RAISED OTHERWISE SEAT WILL REMAIN IN LOWEST POSITION. THIS MAY LEAVE DRIVER IN TOO LOW A POSITION TO DRIVE COMFORTABLY AND SEE THE ROAD EFFECTIVELY. TRUCK HAS REPEATEDLY HAD COMPRESSOR, RELAY, PRESSURE SWITCH FAILURES. DEALER HAS REPLACED COMPRESSOR, RELAY, AND PRESSURE SWITCH IN ORDER TO FIX SYSTEM PROBLEMS WHERE COMPRESSOR WHICH RUNS ERRATICALLY, EXCESSIVELY OR NOT AT ALL. LATEST REPAIR INVOLVED REPLACEMENT WITH A SUPPOSEDLY HEAVIER DUTY RELAY. TRUCK IS NOW OUT OF 2 YEAR WARRANTY AND THE COMPRESSOR HAS FAILED AGAIN. MANUFACTURER SHOULD BE REQUIRED TO FIX PROBLEM ONCE AND FOR ALL. THEY WARRANTY REPLACEMENT PARTS FOR 1 YEAR, WHICH IS JUST BEFORE PARTS FAIL THE NEXT TIME. ONCE WARRANTY IS OVER THEY ARE SUPPOSEDLY NO LONGER RESPONSIBLE RATHER THAN FIXING THE SOURCE OF THE PROBLEM ONCE AND FOR ALL INSTEAD OF "BAND AIDING IT" TEMPORARILY UNTIL THE WARRANTY EXPIRES. THIS IS A KNOWN FLAW AND IS LISTED AS A "NOTICE" TO CUSTOMERS AS A POTENTIAL PROBLEM. I HAVE ALSO HAD THE POWER WINDOW SWITCHES REPLACED ONCE AFTER THE VEHICLE WAS 1 1/2 YEARS OLD AND NOW 1 YEAR AFTER THAT, NOW OUT OF WARRANTY, THEY HAVE FAILED AGAIN. THIS IS JUST PAST THEIR 1 YEAR PARTS WARRANTY. I AM NOW UNABLE TO OPEN THE PASSENGER WINDOW. *TR
Safety Rating for the 2006 CHEVROLET C4500
NHTSA has not yet tested the 2006 CHEVROLET C4500 in its New Car Assessment Program.
Technical Service Bulletins for the 2006 CHEVROLET C4500
General Motors, LLC has issued 3 technical service bulletins (TSBs) for the 2006 CHEVROLET C4500. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
3479 — SERVICE BRAKES, HYDRAULIC
LOCATION OF AUXILIARY BRAKE CONTROL HARNESS/WIRE U86 OPTION. *TT UPDATED 12/2/08. *PE
3504 — ENGINE AND ENGINE COOLING:ENGINE:DIESEL
HARD START HOT ONLY AFTER THE ENGINE HAS REACHED OPERATING TEMPERATURE AND THEN SHUT OFF. *TT
3661 — POWER TRAIN:AUTOMATIC TRANSMISSION
LCT1000 INTERMITTENT NO DRIVE ENGAGEMENT WHEN COLD. *TT
NHTSA Investigations for the 2006 CHEVROLET C4500
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the CHEVROLET C4500
- 2003 CHEVROLET C4500 — 7 complaints
- 2004 CHEVROLET C4500 — 3 complaints
- 2005 CHEVROLET C4500 — 3 complaints
- 2006 CHEVROLET C4500 (current)
- 2007 CHEVROLET C4500 — 0 complaints
- 2008 CHEVROLET C4500 — 0 complaints
- 2009 CHEVROLET C4500 — 0 complaints
Other CHEVROLET Models
- CHEVROLET MALIBU — 28,991 total complaints
- CHEVROLET SILVERADO 1500 — 22,175 total complaints
- CHEVROLET IMPALA — 15,197 total complaints
- CHEVROLET TAHOE — 12,511 total complaints
- CHEVROLET EQUINOX — 12,135 total complaints
- CHEVROLET BLAZER — 11,032 total complaints
- CHEVROLET SILVERADO — 10,928 total complaints
- CHEVROLET SUBURBAN — 10,375 total complaints