2008 CHEVROLET AVEO Power Train Problems

The contact owns a 2008 Chevrolet Aveo. The contact stated that while driving approximately 15 MPH, the transmission became unbolted and separated from the vehicle. Additionally, the engine separated from the motor mounts rendering the vehicle undrivable. The vehicle was later towed the local mechanic. The cause of the failure was not yet determined. The local dealer was notified of the failure. The manufacturer was not notified of the failure. The failure mileage was 121,000.

The left side mount-to-mount bracket bolt broke when accelerating normally from a stop. This is one of the bolts that holds the engine to the frame. This caused my shift stick to be thrown back on every acceleration. This is an obvious safety risk. I have not yet had this problem verified or confirmed by anyone. The car seemed to drive well and normal before and up to this incident.

TL* THE CONTACT OWNS A 2008 CHEVROLET AVEO. WHILE DRIVING APPROXIMATELY 15 MPH, THE VEHICLE SHUT OFF WITHOUT WARNING. THE VEHICLE RESTARTED AND WAS TAKEN TO ANTELOPE VALLEY CHEVROLET (877-385-0885, LOCATED AT 1160 MOTOR LN, LANCASTER, CA). THE DEALER REPLACED THE THROTTLE BODY. THE CONTACT ALSO STATED THAT THE VEHICLE LOST POWER IN THE MIDDLE OF TRAFFIC. THE CONTACT SHIFTED INTO PARK, SHUT OFF THE ENGINE, AND RESTARTED THE VEHICLE. WHEN THE VEHICLE WAS IN PARK, THE ENGINE REVVED AND JERKED WHEN IT WAS SHIFTED INTO DRIVE. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL TIMES, BUT THE VEHICLE RESTARTED EACH TIME. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE THROTTLE BODY AGAIN, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND STATED THAT THERE WAS NO RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.

TL* THE CONTACT OWNS A 2008 CHEVROLET AVEO. WHILE DRIVING AT UNKNOWN SPEEDS, THE TRUNK LID OPENED INDEPENDENTLY. ADDITIONALLY, THE GEAR SHIFTER FAILED TO ENGAGE IN GEAR. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 64,000. *JS

TL* THE CONTACT OWNS A 2008 CHEVROLET AVEO. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG AND THE CHECK ENGINE WARNING INDICATORS ILLUMINATED. IN ADDITION, THE HOLD BUTTON TO ACTIVATE THE FOUR WHEEL DRIVE FAILED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE SENSOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED TWICE. THE DEALER WAS UNABLE TO DIAGNOSE THE OTHER FAILURES; HOWEVER, ALL THE FAILURES RECURRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 125,000. UPDATED 12/20/16*LJ UPDATED 12/21/16.*JB

MY CAR STARTED TO SHAKE, SQUEAK, AND JERK. THIS HAS BEEN ONGOING FOR A FEW DAYS NOW, AFTER TAKING IT TO TWO DIFFERENT MECHANICS. I THEN LEARNED ABOUT THE SAFETY RECALLS FOR THE WHEEL BEARING, DRIVE TRAIN, AND PULLEY SYSTEM FOR THE ENGINE. I CALLED MY DEALERSHIP WHERE I PURCHASED THE USED CAR AND WAS TOLD THEY COULDN'T HELP ME WITH RECALLS. I THEN CALLED GM DIRECTLY AND WAS TOLD THERE WAS NO OPEN RECALL ON MY CAR. I FURTHER RESEARCHED AND FOUND THAT TO BE A LIE, YOUR DATA BASE ALONE STATES THERE IS ONE THAT MAY CAUSE THE CAR TO CATCH FIRE. THIS IS MY FIRST CAR TO PURCHASE AND WITH IT HAVING MAJOR SAFETY RECALLS AND NO ONE WANTING TO HELP, I DIDN'T KNOW WHO ELSE TO CONTACT. *TR

ON THE CHEVY AVEO, ALL MODEL YEARS, THE PARK LOCK SITCH , THAT ALSO MAKES THE BRAKE LIGHTS WORK , SOMETIMES DOESN'T FUNCTION . THIS MAKES IT IMPOSSIBLE TO SHIFT OUT OF PARK WHEN THE BRAKE PEDAL IS DEPRESSED, ALSO THE BRAKE LIGHTS DON'T COME ON. THEREFORE, WHEN DRIVING THE BRAKE LIGHTS SOMETIMES DON'T WORK, WHICH IS A VERY DANGEROUS SITUATION. *TR

MY GRANDMOTHER HAS SOUGHT HELP BECAUSE HERE KEY GETS EXTREMELY HOT. HER GEAR SHIFTER LOCKS UP AND SHE CANT MOVE IT. THE AIR BAG LIGHT POPS ON AND WONT GO OFF. ALSO SHE HAS ASKED MULTIPLE TIMES AT VARIOUS DEALERS ETC, ABOUT IT AND THEY TELL HER THERE ARE NO RECALLS OR ANYTHING KNOWN. WE KNOW THEIR ARE PROBLEMS WITH THE DAYTIME RUNNING LIGHT MODULE BUT NOBODY SEEMS TO HAVE ANY INFORMATION ON THIS... AS I SAID THIS IS FOR MY GRANDMOTHER. *TR

I PUT MY CAR IN PARK AND IT WILL NOT COME OUT OF PARK. I FOUND OUT IT WAS TORQUE LOCKED AND HAD TO FOLLOW ALL THE STEPS FROM MY MANUAL AND AT THE END IT SAYS GET FIXED ASAP. I HAVE READ THAT THERE ARE THE SAME THINGS HAPPENING TO ALOT OF AVEOS 2008 AND WHY IS THIS NOT ON THE RECALL. *TR

I HEAR LOUD BANGS COMING FROM THE REAR SECTION OF THE VEHICLE AND TOOK IT TO A LOCAL MECHANIC. HE INFORMED ME THAT THE AXLE HOUSING BUSHINGS WERE WORN CAUSING MOVEMENT SIDE TO SIDE IN THE HOUSING. WHEN HE CALLED A DEALER TO PURCHASE BUSHINGS THE PARTS PERSON SAID HE COULD NOT SELL THE BUSHINGS BUT HAD TO SELL THE COMPLETE HOUSING BECAUSE THERE WERE PROBLEMS WITH THE PARTS AND IT WAS REDESIGNED. IF THEY KNEW ABOUT A DESIGN FLAW WHY DID THEY NOT ISSUE A RECALL FOR THE PARTS. ESTIMATED COST FOR NEW REAR AXLE IS $1,000.00 PLUS LABOR VERSES REPLACING BUSHING FOR AROUND $70.00 PLUS LABOR. *TR

WE WERE ON OUR WAY TO THE LOCAL MARKET, GOING ABOUT 10 MILES AN HOUR, WE STARTED LEAVING ONE STORE TO THE NEXT...AS I PULL OUT TO THE LIGHT I START TO HEAR A RATTLE ..THEN A LOUD EXPLOSION UNDER THE HOOD..SPARKS AND FIRE SHOT OUT AND THE ENGINE DIED AND WE COASTED ABOUT 20 FEET AND PARKED IT.....I GET OUT AND LOOK UNDER THE HOOD..THE ENGINE HAD DROPPED 8 INCHES FROM THE FRAME AND IS MERELY 3 INCHES FROM THE CONCRETE ......THE ENGINE PULLEYS ARE PUSHED UP TO THE SIDE OF THE CAR AND I BELIEVE EVERYTHING ATTACHED TO THE ENGINE IS BENT ONE WAY OR ANOTHER AND WHEN IT DROPPED IT BUSTED THROUGH THE SUSPENSION!!!! WE HAD IT TOWED TO CLARK'S AUTOMOTIVE IN HUNTINGTON WEST VIRGINIA 25703 (304-522-3876). EVERYONE WE TALKED TO HAD NEVER SEEN THAT HAPPEN BEFORE! THANK YOU!! *TR

I BOUGHT A 2008 CHEVROLET AVEO LS BRAND NEW. REAR DRUMS OF BACK BRAKE REPLACED AT 4,000 MILES. ROTORS TURNED AT 3,000 MILES ROTORS TURNED DOWN AT 14,000MILESS. ROTORS TURNED AT 22,000MILES ROTORS REPLACED AT 7,500 MILES . ROTORS /BRAKE SHOES NEEDING REPLACED AT 23,500 MILES TIRES WORE OUT AT 14,000 MILES DEALER SAID LACK OF ROTATION. SHOWED DOCUMENTATION ON ROTATION/BALANCE BECAUSE BALANCE WAS AN ISSUE EVERY 1,000 MILES OR SO. DEALER SAID NO DEFECT FOUND TIRE MANUFACTURE WOULDN'T REPLACE, NEITHER WOULD CHEVY BRAND NEW TIRES AT 15,500 MILES MY COST!!! VALVEPAN GASKET NEEDING REPLACED 20,000 MILES. *TR

PURCHASED NEW 2008 AVEO IN APRIL 2007 WHICH HAS EXCESSIVE VIBRATION. I TOOK INTO DEALERSHIP AND WAS ADVISED IT WAS DUE TO THE AC CAUSING EXTRA WORK FOR THE MOTOR. SINCE IT WAS SUMMER TIME I WENT ON MY WAY AND DEALT WITH THIS VIBRATION (WHICH ONLY HAPPENS WHILE IN DRIVE) IT IS NOW JANUARY AND NO AC IS BEING USED. I TOOK THE CAR BACK IN TO THE DEALERSHIP AND WAS TOLD YES THERE IS EXCESSIVE VIBRATION AND WE WILL LOOK INTO IT 4 HOURS LATER THEY CALLED TO LET ME KNOW THEY CANNOT FIND THE PROBLEM AND EVEN CONTACTED THE GM ADVISORS AND ARE ALL IN AGREEMENT WITH THIS ISSUE HOWEVER SINCE THERE IS NOT SERVICE BULLETIN OR RECALL REGARDING THIS I WILL HAVE TO JUST DEAL WITH IT AND WAIT AND SEE IF SOMETHING COMES UP WITH A FIX. I CANNOT BELIEVE I AM HAVING TO JUST...

ABOUT 300 HUNDRED MILES AGO NOW 2008 CHEVY AVEO LT WITH 1740 MILES AS OF NOW AND STILL DRIVING. MY WIFE AND I FEELING A VIBRATIONS ON THE CAR EVERY TIME WE STOP AT THE TRAFFIC LIGHT. WHEN CAR SHIFT TO DRIVE IT VIBRATE A WHOLE LOTS FOR PASSENGER TO NOTICE AND I TOOK THE CAR TWICE TO DEALER AND THEY SAID THE CAR IS FINE WITH READING FROM COMPUTER. I TOOK IT SECOND TIME AND THEY CHECK THE MOTOR MOUNTS AND TRANSMISSION MOUNTS ( VISUAL INSPECTIONS I THINK) BUT THEY SAID EVERYTHING IS FINE BUT EVEN THE SERVICE MANAGER SAYS ITS NORMAL FOR VIBRATIONS BUT NOT SO WHEN I WAS SITTING IN THE BACK SEAT WHERE I COULD STILL FEEL THE VIBRATIONS. I LIKE TO KNOW IF THE IS A LEMON OR A DEFECTIVE PART OR WHAT? PLEASE LET ME KNOW WHAT YOU THINK AND WHO TO CONTACT? I...