1994 CADILLAC SEVILLE — Problems, Recalls & Safety Data

THIS VEHICLE IS FACTORY EQUIPPED WITH A DELCO/BOSE SOUND SYSTEM. I WAS DRIVING DOWN MY DRIVEWAY AT 5 MPH. AFTER APPROXIMATELY 3 MINUTES AND 1/4 MILE, THE RADIO SOUND BECAME DISTORTED AND INTERRUPTED. THE VEHICLE'S VOLTAGE DISPLAY INDICATED 13.3 VOLTS, RATHER THAN THE NORMAL 14.2 OR ABOVE. I TURNED OFF THE RADIO. I NOTICED AN ODOR I IDENTIFIED AS "HOT ELECTRICAL." I IMMEDIATELY PULLED INTO A NEIGHBOR'S DRIVEWAY AND SHUT OFF THE VEHICLE'S IGNITION KEY. VISIBLE SMOKE WAS FLOWING INTO THE PASSENGER COMPARTMENT THROUGH THE AREA OF THE LEFT REAR RADIO SPEAKER UNDER THE REAR WINDOW. I OPENED THE ENGINE COMPARTMENT HOOD TO ACCESS THE BATTERY AND OPENED THE TRUNK. THE TRUNK LINER MATERIAL ON THE ROOF OF THE TRUNK BETWEEN THE SEAT BACK AND TRUNK OPENING WAS BURNING. THE FLAMES WERE SPREADING IN A CIRCULAR PATTERN CENTERED ON THE LEFT REAR SPEAKER. I PULLED THE BURNING MATERIAL FROM THE VEHICLE AS MY FRIEND BROUGHT ME A DRY CHEMICAL FIRE EXTINGUISHER. I PUT OUT THE FIRE AS ANOTHER FRIEND DISCONNECTED THE NEGATIVE BATTERY CABLE. THESE SPEAKERS HAVE AN ELECTRONIC MODULE MOUNTED TO THEM. THE MODULE WAS BURNED AND THE WIRES LEADING TO IT WERE BURNED AS FAR BACK AS THE TRUNK LINING MATERIAL HAD BURNED. I ISOLATED THE BURNED MODULE AND DAMAGED PORTION OF THE WIRES LEADING TO IT BY CUTTING THE WIRE HARNESS. I INSULATED THE WIRES AND CONNECTED THE BATTERY. THE VEHICLE STARTED NORMALLY. THE RADIO PLAYED NORMALLY THROUGH THE REMAINING SPEAKERS. THE VOLTAGE INDICATOR SHOWED NORMAL VOLTAGE, 14.2 - 14.3 VOLTS. I OBSERVED NO ANOMALIES OR WARNINGS. NO FUSES NOR CIRCUIT BREAKERS TRIPPED TO INTERRUPT THE POWER TO THE MODULE AND PREVENT THE FIRE. THE DAMAGE WAS LIMITED TO THE SPEAKER AND SURROUNDING TRUNK LINING MATERIAL. I AM SURE IF THIS ISSUE BEGAN AS I WAS DRIVING ON THE HIGHWAY WITHOUT IMMEDIATE ACCESS TO A FIRE EXTINGUISHER, THE RESULT WOULD HAVE BEEN A TOTAL LOSS OF THE VEHICLE. *TR

THE THROTTLE IS STILL OPEN AFTER RELEASING THE GAS PEDAL, CAUSING THE CAR TO CONTINUE MOVEMENT WHEN ATTEMPTING TO STOP. SIMILAR TO RECALL CAMPAIGN 93V164000. *NM

I OWN A 1994 CADILLAC 4 DOOR SEVILLE. I AM THE SECOND OWNER. RECENTLY WHILE ATTEMPTING TO TUNE UP THE VEHICLE, I DISCOVERED THAT THE PLASTIC COVER COVERING THE HEATER BLOWER MOTOR MOUNTED ON THE FIREWALL HAD LITERALLY BEGAN TO DISINTEGRATE. THIS EXPOSED THE INSIDE INSULATION WHICH IS WITHIN INCHES OF THE EXHAUST MANIFOLD AND COULD CAUSE A FIRE IF NOT PROTECTED. I HAVE TAKEN DIGITAL PHOTOS OF THE AREA AND CAN PRESENT THEM TO THE NHTSA AS SOON AS POSSIBLE. THE BLOWER MOTOR PLASTIC COVER JUST LITERALLY FALLS OFF THE FIREWALL..ITS CRACKS LIKE THE CHOCOLATE COVERING A CAKE SO TO SPEAK..TOUCH IT AND IT JUST FLAKES OFF IN CHUNKS LIKE YOU WERE BREAKING A CANDY BAR IN HALF. I HAVE ALSO SAVED SOME OF THOSE PIECES FOR YOUR PERUSAL. NOW THE PROBLEM IS THE MORE I DRIVE, THE MORE PLASTIC FALLS OFF THE PLASTIC HOUSING. I AM AFRAID THAT AFTER A WHILE I WON'T BE ABLE TO DRIVE THE CAR WITH OUT THE CHANCE OF A FIRE IN THAT AREA. *JB

DT: THE CONTACT STATED WHILE DRIVING HE FELT BOILING WATER HIT HIS FEET. HE HAD TO PULL THE VEHICLE OVER AND PARK IT. THIS CAUSED BURNS TO BOTH OF HIS FEET. HE IS A MECHANIC AND FEELS IT IS BECAUSE THE HEATER CORE BUSTED. HE HAS NOT BEEN ABLE TO TAKE THE VEHICLE TO REPAIR SHOP FOR REPAIRS BECAUSE OF THE BURNS TO HIS FEET. *AK

DT: THE CONTACT STATED THE FUEL PUMP WENT OUT IN 7-04. HE BOUGHT THE CAR IN 2000. WHEN HE DROPPED THE FUEL TANK TO GET TO THE FUEL PUMP HE NOTICED THE ELECTRICAL WIRES GOING INTO THE PUMP WERE BLACK. WHEN HE UNSCREWED THE PUMP HE NOTICED THAT ALL OF THE ELECTRICAL WERE WIRES WERE FRIED. HE TOOK THE FUEL PUMP TO A COUPLE OF CAR PARTS RETAIL PLACES, AND THEY TOLD HIM THEY HAD NEVER SEEN ANYTHING LIKE THAT. A MECHANIC AT A LOCAL DEALERSHIP TOLD THE CONTACT THAT WHEN RUN NINES THE CAR A LOT THE FUEL PUMP LOOKED LIKE THAT, THE WIRES WERE FRIED TOGETHER. THE MECHANIC IMPLIED THAT HE HAD SEEN A LOT OF FUEL PUMPS IN CADILLAC THAT LOOKED LIKE THAT. ALSO, TOLD THE CONTACT THAT BECAUSE THE FUEL TANK WAS SEALED IT WAS MORE THAN LIKELY IT WILL NOT CATCH ON FIRE.*AK