1996 BUICK REGAL Engine And Engine Coolingcooling System Problems
2 NHTSA complaints on file
Engine And Engine Coolingcooling System Issues in the 1996 BUICK REGAL
2 engine and engine coolingcooling system complaints have been filed with NHTSA for the 1996 BUICK REGAL. Of these, 0 involved a crash, 0 involved a fire, and 0 resulted in injury.
2
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
All Engine And Engine Coolingcooling System Complaints
BUICK REGAL 1996.ENGINE AND ENGINE COOLING:COOLING SYSTEM HORTLY AFTER JUST 72,000 MILES, A LEAK DEVELOPED NEAR THE UPPER INTAKE MANIFOLD, CAUSING EXCESSIVE COOLANT LOSS (UP TO 1 GALLON PER WEEK).*AK I BELIEVE THIS TO BE A SAFTEY HAZARD RESULTING FROM A DESIGN FLAW. THE OWNER'S MANUAL INCLUDES SEVERAL WARNINGS THAT COOLANT CONTAINS ETHYLENE GLYCOL THAT WILL BURN IF IT COMES IN CONTACT WITH HOT ENGINE PARTS. I AM ALSO CONCERNED THIS PROBLEM MAY HAVE CAUSED ENGINE DAMAGE THAT WILL MANIFEST ITSELF LATER. I BELIEVE GM SHOULD ADDRESS THIS AS A SAFETY HAZARD BEFORE SOMEONE IS KILLED OR SEIOUSLY INJURED BY AN ENGINE FIRE. THANK YOU. DJS
THE ENGINE WAS NOT RUNNING PROPERLY WHICH CAUSED A CRACK IN UPPER INTAKE MANIFOLD FORCING EXCESSIVE COOLANT INTO THE TOP END OF THE ENGINE AND UPPER COMBUSTION CHAMBER. THIS IS AN ON-GOING PROBLEM WITH THE 1996 BUICK REGAL. THIS COULD HAVE RESULTED IN A FIRE AS INDICATED BY THE PREVIOUS RECALL NOTICE FOR THE SAME PROBLEM. AS A RESULT OF THIS INCIDENT, THE FOLLOWING SERVICE WAS REQUIRED: REPAIR ELECTRICAL FAILURE, CLEAN EXCESSIVE COOLANT FROM UPPER COMBUSTION CHAMBERS, REMOVE COOLANT FROM TOP END OF ENGINE, REPLACE UPPER INTAKE ASSEMBLE AND MANIFOLD, REPLACE SPARK PLUGS, PERFORM INJECTOR SERVICE, REPLACE THE PCV VALVE, OIL AND OIL FILTER. ALTHOUGH I HAVE AN EXTENDED WARRANTY, I WAS STILL CHARGED $557.17 FOR THE REPAIR. DUE TO THE NUMEROUS SERVICE BULLETINS, CONSUMER COMPLAINTS, AND PREVIOUS RECALL NOTICE FOR THE SAME SITUATION, THIS DEFECT SHOULD HAVE BEEN DETECTED ON MARCH 7, 2002. AT THAT TIME, I HAD THE...
Other 1996 BUICK REGAL Problem Areas
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip
15 complaints
Air Bagsfrontal
12 complaints
Engine And Engine Coolingengine
11 complaints
Engine And Engine Coolingenginegasoline
10 complaints
Unknown Or Other
9 complaints
Air Bags
8 complaints
Engine And Engine Cooling
8 complaints
Service Brakes Hydraulicfoundation Components
8 complaints
Service Brakes Hydraulicfoundation Componentsdiscrotor
8 complaints
Steeringrack And Pinion
7 complaints
Fuel System Gasolinedeliveryfuel Pump
6 complaints
Fuel System Gasolinefuel Injection System
6 complaints
Vehicle Speed Control
6 complaints
Electrical System
5 complaints
Electrical Systemignition
5 complaints
Power Trainautomatic Transmission
5 complaints
Electrical Systemwiringfront Underhood
4 complaints
Engine And Engine Coolingexhaust Systemmanifoldheadermufflertail Pipe
4 complaints
Seat Beltsfrontanchorage
4 complaints
Service Brakes Hydraulic
4 complaints
Steering
4 complaints
Structurebody
4 complaints
Electrical System12v24v48v Battery
3 complaints
Engine And Engine Coolingexhaust System
3 complaints
Seatsfront Assemblyrecliner
3 complaints
Service Brakes Hydraulicfoundation Componentsdisc
3 complaints
Service Brakes Hydraulicfoundation Componentshoses Linespiping And Fittings
3 complaints
Steering Steering Wheelhandle Bar
3 complaints
Suspension
3 complaints
Tires
3 complaints
Electrical Systemalternatorgeneratorregulator
2 complaints
Electrical Systemhorn
2 complaints
Electrical Systemignitionswitch
2 complaints
Electrical Systemwiring
2 complaints
Engine
2 complaints
Equipmentelectrical
2 complaints
Exterior Lightingtail Lights
2 complaints
Exterior Lightingturn Signal
2 complaints
Fuel System Gasoline
2 complaints
Fuel System Gasolinestoragetank Assembly
2 complaints
Fuelpropulsion System
2 complaints
Latcheslockslinkageshoodlatch
2 complaints
Seat Belts
2 complaints
Seat Beltsfrontbuckle Assembly
2 complaints
Seat Beltsfrontretractor
2 complaints
Service Brakes
2 complaints
Service Brakes Airdiscrotor
2 complaints
Service Brakes Hydraulicfoundation Componentsdisccaliper
2 complaints
Steeringrack And Pinionpinion Shaft
2 complaints
Structure
2 complaints
Structurebodydoor
2 complaints
Suspensionfront
2 complaints
Suspensionfrontcontrol Armlower Ball Joint
2 complaints
Suspensionrearspringsleaf Spring Assembly
2 complaints
Vehicle Speed Controlaccelerator Pedal
2 complaints
Visibilitywindshield Wiperwasher
2 complaints
Air Bagsfrontaldriver Sideinflator Module
1 complaint
Air Bagssidewindow
1 complaint
Electrical Systemwiringfuses And Circuit Breakers
1 complaint
Electrical Systemwiringinteriorunder Dash
1 complaint
Engine And Engine Coolingexhaust Systememission Controlcrankcase Pcv
1 complaint
Equipmentelectricalradiotape Deckcd Etc
1 complaint
Fuel System Gasolinecarburetor System
1 complaint
Fuel System Gasolinedelivery
1 complaint
Fuel System Gasolinedeliveryhoses Linespiping And Fittings
1 complaint
Fuel System Otherstoragefuel Gauge System
1 complaint
Latcheslockslinkagestrunk Lidlock
1 complaint
Power Trainautomatic Transmissiongear Position Indication Prndl
1 complaint
Power Trainautomatic Transmissionlever And Linkagecolumn Shift
1 complaint
Power Trainautomatic Transmissiontorque Converter
1 complaint
Power Trainaxle Assemblyaxle Shaft
1 complaint
Seat Beltsfront
1 complaint
Seats
1 complaint
Service Brakes Airantilock
1 complaint
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slipabs Warning Light
1 complaint
Service Brakes Hydraulicfoundation Componentsdrum
1 complaint
Service Brakes Hydraulicfoundation Componentsdrumdrum
1 complaint
Service Brakes Hydraulicpedals And Linkages
1 complaint
Steeringcolumn
1 complaint
Steeringhydraulic Power Assist System
1 complaint
Steeringhydraulic Power Assistpower Steering Fluid
1 complaint
Steeringhydraulic Power Assistpump
1 complaint
Steeringrack And Pinionrack
1 complaint
Structurebodybumpers
1 complaint
Structurebodydoorhinge And Attachments
1 complaint
Suspensionfrontcontrol Armupper Ball Joint
1 complaint
Suspensionfrontspringscoil Springs
1 complaint
Suspensionfrontspringstorsion Bar
1 complaint
Suspensionrear
1 complaint
Tirestreadbelt
1 complaint
Vehicle Speed Controlsprings
1 complaint
Visibilitydefrosterdefoggerhvac System
1 complaint
Visibilityglass Siderear
1 complaint
Visibilitypower Window Devices And Controls
1 complaint
Visibilitysunmoon Roof Assembly
1 complaint
Visibilitywindshield
1 complaint
Wheels
1 complaint
Wheelshub
1 complaint