2010 BMW Z4 — Problems, Recalls & Safety Data

The contact owns a 2010 BMW Z4. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms tools are not available

BMW HAS ACKNOWLEDGED A KNOWN ISSUE CAUSING FAILURE OF THE HIGH PRESSURE FUEL PUMP. THE BMW TECHNICAL BULLETIN IS (SI B 13 03 09). THIS EXTENDS THE WARRANTY OF THE PART TO 10 YEARS. THE PROBLEM IS THAT THE FAILURE IS NOT WELL DOCUMENTED BY THE VEHICLE ISSUE LOGGING SYSTEM, AND THAT OTHER ISSUES WITH THE CAR ARE CITED AS A REASON TO NOT PERFORM THE PART REPLACEMENT. BMW N. AMERICA AND BMW OF AUSTIN DO NOT, AND CAN NOT PROVIDE A TEST TO CHECK THE VEHICLE'S FUEL SYSTEM INDEPENDENTLY. THIS PUTS DRIVERS, PASSENGERS AND ANYONE ELSE AT RISK SHOULD THE PART FAIL SUDDENLY AFTER EXHIBITING PARTIAL FAILURES. THE COMPLAINT SHOULD ALSO NOTE THAT BMW DOES NOT PROVIDE AN EASY WAY TO REPORT THIS IMPORTANT SAFETY ISSUE AS THERE IS NO FIXED PROCESS TO DOCUMENT THE ISSUES.

TL* THE CONTACT OWNS A 2010 BMW Z4. WHILE DRIVING 40 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE RESTARTED. THE FAILURE PERSISTED. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 13V044000 (ELECTRICAL SYSTEM). THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING, BUT THE FAILURE COULD NOT BE DUPLICATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 10,000.

DURING A COLD, DRIVING RAIN STORM, WITH DRIVER & 1 PASSENGER, STARTED TO DRIVE. (VERY 1ST DRIVE IN THIS CAR WITH COLD WEATHER) WHAT A SURPRISE: WINDSHIELD IMMEDIATELY FOGGED UP. TURNED ON DEFOGGER, WINDSHIELD THEN FOGGED UP 100% AS WELL AS ALL OTHER WINDOWS - AS VISIBILITY DISAPPEARED, I STOPPED THE CAR & OPENED THE WINDOWS WITH THE BLOWER ON. NO HEAT COULD BE USED. THIS PROCESS WAS REPEATED OVER THE NEXT 1 TO 1-1/2 HOURS IN ORDER TO CONTINUE DRIVING. ISSUE WAS REPORTED TO BMW MANY TIMES OVER. I HAD TO LEARN THAT DESPITE COLD AMBIENT TEMPERATURES W-W/O RAIN, SNOW, ETC. - THE A/C MUST BE TURNED ON IN ORDER TO NOT FOG THE WINDOWS. BMW: THERE'S NOTHING TO FIX, THAT'S THE WAY IT IS. THE AMBIENT AIR IS DIRECTED THROUGH A PORTION OF THE ENGINE COMPARTMENT, THIS HEATS UP THE AIR. BMW STATED THAT I MAY VOID THE WARRANTY IF I MODIFY THE SYSTEM TO CORRECT THIS PROBLEM. THIS HAS CONTINUED TO OCCUR. ON A DRIVE ON CA'S COAST HIGHWAY, WITH TEMPS IN THE LOW 50'S - ONE MUST STILL RUN THE A/C & NO HEAT. BMW ASKED: WHAT DO YOU HAVE AGAINST RUNNING THE A/C ALL THE TIME? IN ADDITION TO IMPAIRED VISIBILITY - THIS RESULTS IN CONSTANT, VERY LOW MPG WITH THE A/C ALWAYS ON. WHEN BMW PROVIDED MPG'S TO FED. AGENCIES, I BELIEVE THAT BMW'S A/C'S WERE NOT ON & THESE CARS DEMAND PREMIUM FUEL. I SPOKE WITH A NATIONALLY KNOWN, RESPECTED TESTER/ADVISERS OF MANY VEHICLES - IT WAS CONFIRMED TO ME THAT THE MPG TESTS ARE CONDUCTED WITHOUT THE A/C'S BEING TURNED ON. *TR

TL* THE CONTACT OWNS A 2010 BMW Z4. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V176000 (ENGINE). THE DEALER COULD NOT REPAIR THE VEHICLE FOR EIGHT MONTHS BECAUSE THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.