2011 BMW R 1200 RT — Problems, Recalls & Safety Data

This vehicle was subject to a recall under bulletin 16 0114. The issue was a fuel pump which cracked at flanges which leaked fuel onto the hot engine, which could cause safety issues with fire. My vehicle listed above, had the fuel pump replaced with 12,505 miles on it under the recall. The replacement fuel pump, which is apparently no better than the original that was replaced under recall, cracked again leaking fuel onto the hot motorcycle engine. This happened with 20,300 miles on the vehicle, which is less than 8000 miles later. BMW is refusing to replace under the recall or a warranty the fuel pump which means I am stuck with the bill. I believe that BMW should be replacing a defective part with a new design and better part not an old design faulty part. I would encourage you to issue another recall on the vehicles in question under bulletin 160114 in the interest of motorist safety.

The contact owns a 2011 BMW R1200 RT Motorcycle. The contact stated that while starting the motorcycle, fuel was spraying from the fuel line. There were no warning lights illuminated. The contact called the local dealer but the motorcycle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 20V471000 (Fuel System, Gasoline) however, the VIN was not included. The manufacturer was contacted but no additional assistance was provided. The approximate failure mileage was 37,528.

Development of a major fuel leak after starting motorcycle, leak is coming from the high pressure fitting on the fuel pump. Very dangerous as the fuel is dripping on the hot exhaust and pooling on top of the fuel pump. Risk of fire and possibility of fuel getting on pant leg and burning riders leg. I talked to a couple dealers in the Phoenix area and it’s more common than not.

The contact owns a 2011 BMW R 1200 RT. The contact received notification of NHTSA Campaign Number: 20V471000 (Fuel System, Gasoline). The dealer was contacted and informed that the parts were not available. The contact called back the same dealer on two separate occasions and was informed that parts were still unavailable. The manufacturer was notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2011 BMW R 1200 RT Motorcycle. The contact stated that fuel was leaking from motorcycle. There were no warning lights illuminated. The contact received notification of NHTSA campaign number: 20V471000 (Fuel System. Gasoline) however, the part to do the recall repair was unavailable. The contact called the local dealer who stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified however, no further assistance was provided. The failure mileage was approximately 17,000. Parts distribution disconnect.