2012 BMW K 1600 GTL Electrical System Problems

UNABLE TO LOWER WIND SCREEN. LEFT HAND SWITCH FAILED, SCREEN STUCK IN LOWER POSITION SUBJECTING RIDER AND PASSENGER TO HEAVY RAIN AND WIND DURING CROSS COUNTRY TRIP. THE SWITCHES ON THE BMW K1600 MOTORCYCLES OFTEN FAIL, E.G. BIKE TURNS OFF, CRUISE CONTROL DOESN'T WORK, TURN SIGNAL INOPERABLE. DEALER, MORTON'S BMW TELLS ME THESE SWITCHES CONTINUE TO FAIL ON NUMEROUS K1600S. SWITCHES ARE NOT AVAILABLE AFTER 6 WEEKS OF BEING "ON ORDER" *JB

I WAS TRAVELING AT HIGHWAY SPEED ON A BUSY INTERSTATE, WHEN I WENT TO PASS A CAR. I TWISTED THE THROTTLE AND THE BIKE BEGAN TO GAIN SPEED NORMALLY, AND THEN SUDDENLY IT LOST ALL POWER. I WAS ABLE TO GET OUT OF THE WAY OF OTHER TRAFFIC AND COAST ONTO THE SHOULDER, WHERE I DISCOVERED THE ENGINE WAS ACTUALLY STILL RUNNING, BUT THE THROTTLE CONTROL WAS COMPLETELY INOPERATIVE. AN INDICATOR LIGHT ON THE DASH WAS ILLUMINATED, WHICH, ACCORDING TO THE MANUAL, MEANT THE ENGINE HAD GONE INTO "EMERGENCY OPERATION MODE." AFTER SHUTTING THE BIKE OFF AND RESTARTING A FEW TIMES, IT RETURNED TO NORMAL OPERATION. WHEN I TOOK IT TO THE DEALER TO HAVE THE PROBLEM CHECKED OUT, THEY SAID THE HISTORY CONFIRMED THAT THE BIKE HAD LOST ELECTRONIC THROTTLE CONTROL FOR THE FLY-BY-WIRE SYSTEM, BUT WAS FUNCTIONING PROPERLY NOW. THEY WERE UNABLE TO SUGGEST ANY POSSIBLE CAUSES OR...

TURN SIGNALS WILL NOT TURN OFF BY SWITCH ONCE ACTIVATED. THIS CAUSES AN UNSAFE CONDITION, AS TRAFFIC COULD ENTER FROM THE RIGHT OR LEFT ASSUMING THE MOTORCYCLE OPERATOR INTENDS TO TURN, CAUSING THE POTENTIAL FOR A BROADSIDE COLLISION WHICH WOULD LIKELY CAUSE INJURY OR DEATH TO THE MOTORCYCLE OPERATOR. THE TURN SIGNAL FIRST PRESENTED THIS DEFECT DURING A RELATIVELY HOT DAY (90 DEGREE) AND DURING COOLER WEATHER WORKED NORMALLY. NOW THE CONDITION IS MORE RECURRING EVEN AT LOWER TEMPERATURES. THE TURN SIGNAL SWITCH IS PART OF THE LEFT MULTI-FUNCTION SWITCH HOUSING. *JS

MY BMW K1600GTL HAS EXPERIENCED 3 FAILURES OF THE MULTI-PURPOSE ELECTRICAL CONTROL SWITCH ON THE LEFT HANDLEBAR AND 1 FAILURE OF THE MULTI-PURPOSE SWITCH ON THE RIGHT HANDLEBAR. THE LEFT HANDLEBAR FAILURES WERE THE HIGH/LOW BEAM SWITCH 2 TIMES AND THE MENU BUTTON 1 TIME. THE RIGHT HANDLEBAR FAILURE WAS THE MODE SWITCH THAT CONTROLS ENGINE MAPPING FOR ROAD, DYNAMIC AND RAIN. I WAS TOLD BY TWO BMW MOTORCYCLE DEALERSHIP EMPLOYEES THAT THESE FAILURES ARE VERY COMMON AND BMW DENIES THERE IS A PROBLEM. THE ISSUE WITH THESE SWITCHES ARE SAFETY RELATED BECAUSE FAILURE OF THE FUNCTIONS THEY PROVIDE CAN LEAD TO AN UNSAFE CONDITION, E.G., TURN SIGNAL, HIGH/LOW BEAM, HORN, WIND SCREEN HEIGHT, ENGINE MAPPING, ENGINE KILL SWITCH, ETC.

MY BMW K1600GTL HAS EXPERIENCED FOUR (4) FAILURES OF THE ELECTRICAL CONTROL SWITCHES ON THE HANDLEBARS. THE FIRST FAILURE WAS ON THE LEFT SIDE CAUSING THE LEFT TURN SIGNAL TO NOT FUNCTION. THE SECOND FAILURE WAS OF THE REPLACED LEFT HANDLEBAR CLUSTER CAUSING THE HIGH BEAM (HEADLIGHTS) TO NOT FUNCTION. THE THIRD SWITCH FAILURE WAS AGAIN ON THE LEFT SWITCH CLUSTER ON THE TURN SIGNAL CANCEL SWITCH CAUSING THE TURN SIGNALS TO FUNCTION FOR 0.2 MILES UNTIL THEY SELF CANCELED. THIS WAS THE MOST HAZARDOUS SITUATION AS OTHER VEHICLES WOULD ATTEMPT TO PULL IN FRONT OF ME THINKING I WAS SIGNALING FOR A TURN. THE MOST RECENT FAILURE HAS BEEN THE RIGHT HANDLEBAR SWITCH CLUSTER AND FAILURE OF THE CENTRAL LOCKING SYSTEM. THIS FAILURE IS NOT SIGNIFICANT, BUT THIS SWITCH CLUSTER ALSO CONTROLS THE ENGINE MANAGEMENT MODES AS WELL AS THE START/ENGINE KILL SWITCHES. FAILURE OF EITHER ONE OF THOSE...

THREE (3) K1600 GTL SUDDEN ENGINE CUTOFF EVENTS THAT I EXPERIENCED ON JUNE 14, AND JUNE 16, 2013. THIS DOCUMENTS A SIGNIFICANT SAFETY CONCERN ON MY 2012 BMW K1600GTL. IN THREE SEPARATE EVENTS, MY K1600GTL ENGINE SHUTDOWN AT FULL SPEED (75 MPH, 55 MPH) WHILE ON THE THROTTLE WITH NO ADVANCE NOTICE. ALL THREE EVENTS WERE 'ON THE THROTTLE' EVENTS - NOT COASTING. THE BIKE ENGINE SHUTDOWN ABRUPTLY AND THE BIKE JOLTED FORWARD. I HAD TO TAKE EVASIVE ACTION DURING ALL THREE EVENTS TO GET TO THE SIDE OF THE ROAD. I CONSIDER THEM TO BE SIGNIFICANT NEAR MISSES THAT COULD HAVE CAUSED A CRASH. IMMEDIATELY UPON GETTING THE BIKE OFF THE ROAD, THE BIKE WOULD NOT START IMMEDIATELY. HOWEVER, AS SOON AS I SWITCHED THE IGNITION KEY TO OFF, THEN ON, THE BIKE STARTED RIGHT UP AND I WAS ABLE TO RIDE. THE DEALER INDICATED THE FIX WAS A...

LEFT AND RIGHT HANDLEBAR CONTROLLER QUITS FUNCTIONING. THE LEFT CONTROLLER HOUSES THE HORN, TURN SIGNALS, CRUISE CONTROL, BRIGHT LIGHTS, FOG LAMPS, TRACTION CONTROL, HAZARD WARNING FLASHERS, AND THE DAMPING ON THE MOTORCYCLE AMONG OTHER THINGS THAT ARE NOT SO HAZARDOUS SUCH AS RADIO VOLUME AND WIND SHIELD HEIGHT. RIGHT HANDLEBAR CONTROLLER HOUSES THE ENGINE CUTOFF SWITCH, RIDING MODE (RAIN, DRY, DYNAMIC) WHICH CONTROLS THE RESPONSIVE OF THE BIKE, AND LESS CRITICAL ITEMS SUCH AS THE POWER LOCKS FOR LUGGAGE COMPARTMENTS. THESE HAVE BEEN REPLACED FIVE TIMES ON MY BIKE SINCE BEING PUT SERVICE JULY 2012 AND TRAVELING 13K MILES -- GOT TO GIVE THE CREDIT FOR TRYING BUT ENGINE CUTTING OUT, HORN QUITTING, BLINKERS QUITTING, ETC IS PROBABLY A HIGHWAY SAFETY ISSUE. BELOW ARE TWO LINKS, ONE IS A VIDEO OF THE BIKE STALLING ON A MAJOR AND CROWDED INTERSTATE -- ILLUSTRATES THE DANGER. 2D IS ANOTHER LINK SHOWING COMPLAINTS...