1997 BMW 740I — Problems, Recalls & Safety Data
N/A
Safety Rating
3
Owner Complaints
3
Recalls
2
Service Bulletins
0
Investigations
Overview of the 1997 BMW 740I
The 1997 BMW 740I has received a total of 3 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 3 recall campaigns affecting this vehicle, covering issues with STEERING:LINKAGES:DRAG:LINK:CONNECTION, SUSPENSION:FRONT:SPRINGS:COIL SPRINGS, VEHICLE SPEED CONTROL. 2 technical service bulletins have been issued by BMW of North America, LLC for this model year. The most commonly reported problems involve the Engine And Engine Coolingcooling Systemhoseslinespipingfittings (1 complaint), Engine And Engine Coolingcooling Systemradiator Assembly (1 complaint), and Fuel System Gasolinestoragetank Assembly (1 complaint).
Recalls for the 1997 BMW 740I
NHTSA has recorded 3 recalls for the 1997 BMW 740I, potentially affecting up to 439,150 vehicles.
Recall 10E021000 — STEERING:LINKAGES:DRAG:LINK:CONNECTION
| 150 vehicles affected
Defect: FCP GROTON IS RECALLING CERTAIN STEERING CENTER DRAG LINKS, P/N 32 21 1 096 057, SOLD FROM DECEMBER 1, 2009 THROUGH APRIL 9, 2010 AS REPLACEMENT EQUIPMENT FOR MODEL YEAR 1995 THROUGH 2001 BMW 740I, 740IL, AND 750IL PASSENGER VEHICLES. THE SHAFT OF THE STEERING CENTER TIE ROD MAY SHEAR OFF.
Consequence: THIS CONDITION WOULD RESULT, WITHOUT WARNING, IN IMMEDIATE AND COMPLETE LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN SERIOUS INJURY OR DEATH.
Remedy: FCP GROTON WILL NOTIFY OWNERS AND THE TIE ROD WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JUNE 1, 2010. OWNERS MAY CONTACT FCP GROTON TOLL-FREE AT 1-877-634-0063.
View full details →Recall 97V140000 — SUSPENSION:FRONT:SPRINGS:COIL SPRINGS
| 29,000 vehicles affected
Defect: VEHICLE DESCRIPTION: PASSENGER VEHICLES. ROAD GRIT AND GRAVEL ASSOCIATED WITH WINTER ROAD CONDITIONS CAN PENETRATE THE RUBBER OF THE LOWER FRONT SPRING MOUNTS AND ACCUMULATE IN THE MOUNTS CAUSING NOTCHES OR PITS TO DEVELOP. THESE NOTCHES CAN DEVELOP CRACKS RESULTING IN BREAKAGE OF A BOTTOM COIL OF THE SPRING.
Consequence: THE VEHICLE'S RIDE HEIGHT COULD BE AFFECTED CAUSING NOISE WHILE THE VEHICLE IS DRIVEN. THE VEHICLE'S DYNAMIC STABILITY CAN BE AFFECTED REDUCING THE DRIVER'S ABILITY TO MAINTAIN CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE BOTH FRONT SPRINGS AND LOWER SPRING MOUNTS.
View full details →Recall 97V131000 — VEHICLE SPEED CONTROL
| 410,000 vehicles affected
Defect: THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL...
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
View full details →Owner Complaints for the 1997 BMW 740I
3 complaints have been filed with NHTSA for the 1997 BMW 740I. Below is a breakdown by vehicle component.
| Component | Complaints | Crashes | Fires | Injuries | Deaths |
|---|---|---|---|---|---|
| Engine And Engine Coolingcooling Systemhoseslinespipingfittings | 1 | 0 | 0 | 0 | 0 |
| Engine And Engine Coolingcooling Systemradiator Assembly | 1 | 0 | 0 | 0 | 0 |
| Fuel System Gasolinestoragetank Assembly | 1 | 0 | 0 | 0 | 0 |
Most Recent Complaints
CONSUMER COMPLAINED ABOUT A COOLING SYSTEM PROBLEM. THE HOSE THAT WAS CONNECTED TO THE RADIATOR MELTED FROM THE HEAT THAT CAME FROM THE ENGINE.*AK
THERE SEEMS TO BE A COMMON DEFECT IN THE '1995-'01 BMW 740 SERIES GAS TANK. THERE IS A PROBLEM THAT OCCURS THAT CREATES A VACCUM IN THE TANK WHICH THEN MAKES THE TANK IMPLODE. IT JUST CRUSH IN UPON ITSELF UNTIL IT POPS OR A SEAM BREAKS SOMEWHERE. THIS HAPPENED TO ME YESTERDAY WHILE I WAS DRIVING TO WORK AND HAD 17 GALLONS OF GAS SPEWING FROM UNDERNEATH THE CAR. I DIDN'T NOTICE IT UNTIL I WAS IN MY PARKING GARAGE WHICH IS IN A 49 STORY BUILDING. THE JERSEY CITY FIRE DEPARTMENT CAME THEN BROUGHT IN THEIR HAZMAT TEAM. THEY RECOVERED/CLEANED UP MAYBE 7 GALLONS WHILE IN THE GARAGE SO ABOUT 10 GALLONS SPILLED WHILE I WAS DRIVING. NEEDLESS TO SAY THIS WAS AN EXTREMELY DANGEROUS SITUATION THAT COULD HAVE BEEN PREVENTED IF BMW HAD RECALLED THE CAR ON THIS ITEM. IT HAS HAPPENED TO AT LEAST 6 OTHER PEOPLE ON THIS MESSAGE BOARD THAT I'M A PART OF: HTTP://BIMMER.ROADFLY.ORG/BMW/FORUMS/E38/ I'M JUST GLAD THAT NO ONE GOT HURT AND THAT MY 3 AND 1 YEAR OLD DAUGHTERS WERE NOT IN THE CAR. BUT IF SOMETHING IS NOT DONE SOON SOMEONE IS GOING TO DIE AS A RESULT OF THIS DEFECT.*AK
UPPER NIPPLE WITH HOSE CONNECTOR ON RADIATOR IS MADE OF PLASTIC AND BREAKS OFF WITH FRAGMENTS LEFT IN THE HOSE. THIS REALLY SHOULD NOT BE MADE OF PLASTIC AS INTENSELY HOT WATER PASSES THROUGH IT ALL THE TIME. THIS AMOUNTS TO AN EXPENSIVE REPAIR.*AK
Safety Rating for the 1997 BMW 740I
NHTSA has not yet tested the 1997 BMW 740I in its New Car Assessment Program.
Technical Service Bulletins for the 1997 BMW 740I
BMW of North America, LLC has issued 2 technical service bulletins (TSBs) for the 1997 BMW 740I. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
MSG0350 — EXTERIOR LIGHTING:TURN SIGNAL:SWITCH
CUSTOMERS MAY COMPLAIN THAT THE ILLUMINATION FOR THE BUTTONS ON THE MULTI FUNCTION STEERING WHEEL FLICKERS. *TW
MSG0149 — EXTERIOR LIGHTING:TURN SIGNAL:SWITCH
VEHICLES MAY HAVE A PROBLEM WITH THE DIMMER CIRCUIT - VEHICLES RELEASED FROM THE VPCS STARTING 10-04-96 HAVE DISABLED DIMMER SWITCHES. *TW
NHTSA Investigations for the 1997 BMW 740I
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the BMW 740I
- 1993 BMW 740I — 24 complaints
- 1994 BMW 740I — 9 complaints
- 1995 BMW 740I — 12 complaints
- 1996 BMW 740I — 1 complaint
- 1997 BMW 740I (current)
- 1998 BMW 740I — 12 complaints
- 1999 BMW 740I — 9 complaints
- 2000 BMW 740I — 18 complaints
- 2001 BMW 740I — 24 complaints