2005 BMW 530I Electrical System Problems

MY IDRIVE SHOWED A MESSAGE INDICATING THAT THE AIRBAG IN THE PASSENGER SIDE WAS DEACTIVATED BECAUSE OF A SENSOR OR SIMILAR ISSUE. I TOOK THIS TO THE DEALER, ASKED FOR IT TO BE COVERED UNDER THE PREVIOUS SERVICE BULLETIN WHICH INDICATED THE SEAT MAT SENSOR WAS DEFECTIVE. THE DEALERSHIP INDICATED THEY WOULD NOT FIX IT. I CONTACTED BMW NORTH AMERICA AND THEY SAID THEY MIGHT FIX IT IF I PAID FOR THE ASSESSMENT. THE ASSESSMENT SUGGESTED THERE WAS A DEFECT IN DIFFERENT SENSOR. AND SUGGESTED THAT A BATTERY CABLE SHOULD BE REPLACED. ALL OTHER SYSTEMS IN THE CAR WORKS FINE. BOTH BMW AND THE DEALER REFUSED TO FIX THIS ISSUE. THERE HAVE BEEN NO OTHER REPORTED CASES OF THE BATTERY CABLE ACTUALLY CAUSING THE AIRBAGS TO BE DEACTIVATED. TODAY, THE AIRBAG IS STILL NOT WORKING, AND BMW HAS REFUSED TO FIX THE PROBLEM.

I HAVE XENON ADAPTIVE HEADLIGHTS OEM MADE BY HELLA. THE INSULATION ON ALL OF THE WIRING INSIDE THE HEADLIGHT ASSEMBLY IS FALLING OFF. YOU CANNOT TOUCH A WIRE WITHOUT THE INSULATION CRUMBLING OFF THE WIRING. NOW HAVING NUMEROUS FAULTS AND HID LIGHT ON DRIVERS SIDE IS NON FUNCTIONAL DUE TO WIRING SHORTS.

THE IDRIVE, KNOWN AS "CCC", UNIT USED TO WORK JUST FINE. IT CONTROL NAVIGATION, RADIO AND VEHICLE'S INFORMATIONS FOR OWNER. ONCE AWHILE THE SCREEN BLINK AND GO BLANK, AND THEN SOMETIME IT WORK JUST FINE. NOW IT JUST DON'T WORK ANYMORE. THE SCREEN NOW BLINK CONTINUOUSLY WHILE DRIVING. THIS IS CAUSING A MAJOR DISTRACTION FOR ME BEHIND THE WHEEL ESPECIALLY AT NIGHT. I STARTED RESEARCHING ONLINE AND NOTICE A LOT OF OWNERS WITH THIS MODEL ALSO HAVE THE SAME PROBLEMS. THEY REPLACED THE CCC UNIT AND UPDATE SOFTWARE INFORMATION AT THE DEALER AND IT FIXED THE ISSUES. I CALLED BMW MOMENTUM OF HOUSTON ABOUT THE CCC. THE COST IS $1,500.00 NOT INCLUDING LABOR. I BELIEVE THIS GRAND DEFECTS IS A MANUFACTURING DEFECTS. CAN YOU PLEASE INVESTIGATE INTO THIS MATTER SO THAT A RECALL CAN BE ISSUE.

THE MICRO POWER MODULE IN THE TRUNK WAS BURNT ON MY 2005 530I, NOW MY IDRIVE / AUDIO / NAV AND PDC HAS SHUT DOWN. CAR STARTS AND DRIVES NORMAL, EXCEPT THE PREVIOUSLY MENTIONED ACCESSORIES THAT NO LONGER WORK, WHO KNOW WHAT OTHER DAMAGES (IF ANY) RESULTED FROM A MPM MELTDOWN. I'VE READ SOME HORROR POSTS OF SIMILIAR EVENTS THAT CAUSED EVERYTHING ON THE VEHICLE TO SHORT OUT, WHICH MEANT THAT BASICALLY EVERYTHING CCC / M-ASK / TV MODULE / CD ETC. WHEN THIS HAPPENED ON MY VEHICLE, THE CAR WAS ACTUALLY SWITCHED OFF. IT WAS ONLY WHEN I GOT BACK TO THE CAR THE NEXT MORNING WHEN I GOT THIS STRONG ELECTRICAL BURN SMELL FROM THE TRUNK AREA. THE MPM PROBABLY SHORTED OUT DURING THE COURSE OF THE NIGHT. LUCKILY THE CAR DID NOT CAUGHT ON FIRE, CAUSE IT COULD HAVE THEN BURNED DOWN MY APARTMENTS AS WELL, AS...

THIS HAS BEEN HAPPENING TO OTHER 2005 BMW 530I OWNERS. WHILE BRAKING VEHICLE IDRIVE GAVE WARNING THAT REAR DRIVER SIDE BRAKE LIGHT FAILED AND THEN THAT THE REAR LIGHT HAD A MALFUNCTION. UPON LOOKING AT THE WIRING HARNESS ATTACHED TO THE TAILLIGHT BULB CARRIER, THE BROWN WIRE IS BURNT OUTSIDE OF THE HARNESS. THE RUBBER COATING OF THE WIRE IS BURNT THROUGH AND THE WIRE IS EXPOSED. THE PLASTIC WIRE HARNESS IS BURNT AND MELTED. THE TAILLIGHT BULB CARRIER IS ALSO BURNT AND MELTED. EXACTLY WHAT HAS HAPPENED TO MY CAR. THE GROUND WIRE HAS WAY TOO MUCH CURRENT ON IT RESULTING IN MELTING AND POSSIBLE FIRE. *TR

FRONT PASSENGER SEAT OCCUPANT MAT IS MALFUNCTIONING IN MY 2005 BMW 530I. THERE WAS A RECALL IN ACTION NUMBER EA08001 IN WHICH BMW AGREED TO EXTEND THE WARRANTY OR COMPLETE THE REPAIR OF THE PROBLEM. WHEN I WENT TO THE BMW SERVICE FACILITY, THEY WOULD ONLY FIX THE ISSUE IF I PAID. I CALLED BMW USA AND THEY TOLD ME THAT MY SPECIFIC VIN NUMBER IS NOT INCLUDED IN THE REPAIR/EXTENDED WARRANTY. EVEN THOUGH MY VEHICLE IS EXPERIENCING THE PROBLEM, THEY TELL ME MY VIN IS NOT INCLUDED. THEREFORE, MY PASSENGER SEAT AIRBAGS DO NOT WORK. I REPORTED THIS PROBLEM ORIGINALLY IN 2012 TO BMW. *TR

WHILE BRAKING VEHICLE IDRIVE GAVE WARNING THAT REAR DRIVER SIDE BRAKE LIGHT FAILED AND THEN THAT THE REAR LIGHT HAD A MALFUNCTION. UPON LOOKING AT THE WIRING HARNESS ATTACHED TO THE TAILLIGHT BULB CARRIER, THE BROWN WIRE IS BURNT OUTSIDE OF THE HARNESS. THE RUBBER COATING OF THE WIRE IS BURNT THROUGH AND THE WIRE IS EXPOSED. THE PLASTIC WIRE HARNESS IS BURNT AND MELTED. THE TAILLIGHT BULB CARRIER IS ALSO BURNT AND MELTED.

MUCH LIKE THE OTHER COMPLAINTS, I JUST COPIED AND PASTED THIS FROM ANOTHER COMPLAINANT. THE PASSENGER RESTRAINT SYSTEM MALFUNCTION ALARM CAME ON THE IDRIVE. THE DEALER SAYS THAT THE VEHICLE IS NOT COVERED UNDER RECALL. HOWEVER, THE RECALL ID #73368 EXACTLY MATCHES THE DESCRIPTION OF MY PROBLEM. THEREFORE, WE BELIEVE THAT OUR VEHICLE SHOULD BE COVERED. PLEASE ADVISE HOW TO GET THIS RESOLVED AS SOON AS POSSIBLE SO THAT I CAN GET THE CAR FIXED. WE ARE CONCERNED BECAUSE IT'S A SERIOUS SAFETY ISSUE WHEN THE FRONT AIR BAGS WILL NOT COME ON IN CASE OF AN ACCIDENT. I WENT AS FAR AS TO SPEAK WITH BMW DIRECTLY AND THEY SAID IT ONLY GOES TO THE 2004 MODELS, AND THEN TO THE 2006 MODELS....YEA, WHATEVER. IT'S A SAFETY RECALL, THEY SHOULD HONOR IT, AND BMW IS COMPLETELY INFLEXIBLE WHEN IT COMES TO THEIR CUSTOMERS. IT'S A SHAME NOT ONLY WILL...

MY 2005 BMW 530I HAS A MICROPROCESSOR UNIT LOCATED IN THE SPARE TIRE SUMP IN THE TRUNK. WATER GOT INTO THE TRUNK AND SHORTED OUT THIS UNIT. THIS IS A POOR PLACE TO LOCATE SUCH A VITAL PART, AS THIS PARTICULAR MICROPROCESSOR CONTROLS THE VEHICLE'S IDRIVE SYSTEM (BMW'S INTEGRATED SYSTEM WHICH INCLUDES THE RADIO, HEAT/AIR SETTINGS, DIAGNOSTICS, ETC). BMW WILL ONLY FIX THIS ITEM AS PART OF A NEW CAR WARRANTY. REPAIRS CAUSED BY THE POOR PLACEMENT OF THIS UNIT CAN COSTS INTO THE THOUSANDS IF CONDUCTED BY A BMW DEALERSHIP. IF THE MICROPROCESSOR SHORTS OUT WHILE IN OPERATION IT COULD CATCH FIRE. *TR

FIRST, THE BATTERY. SECOND, THE MODULE THAT CONTROLS THE RADIO, CD, CONTROLS ON THE STEERING WHEELS, INFO SCREEN, ALMOST EVERYTHING STOPPED WORKING. THIRD, RIGHT AFTER I HAD THIS FIXED, AN ERROR MESSAGE CAME UP THAT THE PASSENGER RESTRAINT SYSTEM FAILED AND MAY EFFECT AIRBAGS. ALL THIS IN A FIVE MONTH PERIOD. *TR