1992 BMW 525IT — Problems, Recalls & Safety Data
N/A
Safety Rating
0
Owner Complaints
3
Recalls
0
Service Bulletins
0
Investigations
Overview of the 1992 BMW 525IT
The 1992 BMW 525IT has received a total of 0 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 3 recall campaigns affecting this vehicle, covering issues with VEHICLE SPEED CONTROL, AIR BAGS:FRONTAL, EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH.
Recalls for the 1992 BMW 525IT
NHTSA has recorded 3 recalls for the 1992 BMW 525IT, potentially affecting up to 665,000 vehicles.
Recall 97V131000 — VEHICLE SPEED CONTROL
| 410,000 vehicles affected
Defect: THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL...
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
View full details →Recall 96V110000 — AIR BAGS:FRONTAL
| 75,000 vehicles affected
Defect: THE AIR BAG CONTACT RING LOCKING TAB LOCATED IN THE STEERING WHEEL ASSEMBLY CAN BREAK WITHOUT WARNING.
Consequence: IF THIS HAPPENS, THE CONTACT RING WIRING COULD EVENTUALLY BREAK. THE AIR BAG READINESS INDICATOR LAMP (SRS OR AIRBAG) IN THE INSTRUMENT CLUSTER WILL ILLUMINATE, AND THE AIR BAG WOULD NOT DEPLOY IN THE EVENT OF A FRONTAL IMPACT VEHICLE COLLISION.
Remedy: DEALERS WILL REPLACE THE LOCKING TAB WITH ONE OF A DIFFERENT DESIGN.
View full details →Recall 96V111000 — EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
| 180,000 vehicles affected
Defect: THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.
View full details →Owner Complaints for the 1992 BMW 525IT
No complaints have been filed with NHTSA for the 1992 BMW 525IT.
Safety Rating for the 1992 BMW 525IT
NHTSA has not yet tested the 1992 BMW 525IT in its New Car Assessment Program.
Technical Service Bulletins for the 1992 BMW 525IT
No technical service bulletins have been reported for this vehicle.
NHTSA Investigations for the 1992 BMW 525IT
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the BMW 525IT
- 1992 BMW 525IT (current)
- 1993 BMW 525IT — 0 complaints
- 1994 BMW 525IT — 0 complaints
- 1995 BMW 525IT — 1 complaint