2006 BMW 525I Electrical System Problems

I WAS ON MY WAY TO WORK AND HAD DRIVEN ONLY 4 1/2 MILES AT 6:55AM ON THURSDAY, AUGUST 15, 2019. I WAS ABOUT 1/2 FROM WORK ON A CITY STREET WHEN SMOKE BEGAN COMING OUT THE AIR VENTS AND STEERING COLUMN. A SMELL OF PLASTIC, ELECTRICAL FILLED THE CAR AND I PULLED INTO THE NEAREST PLACE WHEN THE SMOKE WAS QUICKLY INCREASING. MY SON AND I JUMPED OUT OF THE CAR AND CALLED 911. THE FIRE DEPARTMENT ARRIVED ALMOST IMMEDIATELY, AND UPON PULLING UP, BEFORE THEY COULD GET OUT OF THE TRUCK, THE DRIVER'S SIDE CURTAIN AIRBAG EXPLODED, THE FIREMEN HEARD THE EXPLOSION. BY THE TIME THEY PULLED THEIR HOSES AND LIFTED THE HOOD, SMOKE WAS HEAVILY COMING FROM THE CAR. WHEN THE AIRBAG EXPLODED, A LARGE PIECE OF PLASTIC SHRAPNEL WAS BLOWN TO THE PASSENGER SIDE OF THE CAR AND STUCK BETWEEN THE WINDSHIELD AND THE WINDOW AND...

TL* THE CONTACT OWNS A 2006 BMW 525-I. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WITH THE ENGINE TURNED OFF, SMOKE STARTED EMERGING FROM THE ENGINE COMPARTMENT. THE HOOD WAS OPENED AND A FIRE WAS DISCOVERED COMING FROM THE PASSENGER SIDE. THE FIRE DEPARTMENT WAS CALLED AND THEY EXTINGUISHED THE FIRE. THE POLICE WAS PRESENT AND A REPORT WAS ISSUED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSTIC. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 307,726.

BECAUSE OF POOR QUALITY OF FIBER OPTICS WIRING USED ON THE HEADLIGHT THEY TEND DRY ROT RESULTING IN A BURNT OUT HEADLIGHT. WHICH CAN BECOME A SAFETY HAZARD.

MY BMW APPEARS TO THE HAVE AN ISSUE WITH THE PASSENGER AIR BAG SENSOR, BUT THE VIN ISN'T INCLUDE IN THE RECALL LIST. KINDLY REQUEST RECALL, AS THE VEHICLE HASN'T BEEN IN AN ACCIDENT, BUT PASSENGER AIR BAG LIGHT REMAINS ON.

MAIN HEADLIGHT FAILURE DURING NIGHT DRIVING CAUSE BY ELECTRICAL SHORT CIRCUIT, DUE TO HEADLIGHT INTERNAL ELECTRICAL WIRING INSULATION FAILURE. INTERNAL ELECTRICAL WIRING INSULATION SEEMS NOT TO MEET SAE, NEC, ASME, ETC. CODES AND STANDARD FOR THE USES, LIKE ENGINE ELECTRICAL WIRING, SUBJECT TO HEAT EXPOSURE FROM HEADLIGHT BULB GENERATION. MAJOR SAFETY ISSUES CAN RESULT FROM SUDDEN HEADLIGHT FAILURE WITHOUT PREVIOUS NOTICE, WHICH CAN CAUSE ACCIDENT AT DARK ROADS. HEADLIGHT FAILURE OCCURS WHILE DRIVING IN A DARK ROAD AT NIGHT.

WHILE I WAS DRIVING ON A STREET ROAD MY STIRRING WHEEL GOT STUCK AND I LOST CONTROL OF MY CAR SWERVED INTO OTHER LANE AND NEARLY CAUSED AN ACCIDENT. I PUSHED THE WHEEL BACK HARD AND BOUGHT MY CAR ON THE SIDE OF THE ROAD . A MECHANIC FOUND THAT NEARLY TWO INCHES OF WATER HAD ACCUMULATED IN THE TRUNK OF MY CAR, THE WATER DAMAGE CAUSED ELECTRICAL FAILURE MAKING THE CAR TO BECOME INOPERABLE. BY SHODDY CONSTRUCTION. THE MODULES, ARE INSTALLED IN THE SPARE TIRE WELL AND INSUFFICIENTLY PROTECTED FROM MOISTURE, MAKING THEM ESPECIALLY PRONE TO WATER DAMAGE THAT CAN BE CAUSED THROUGH THE NORMAL AND ORDINARY USE OF THE VEHICLE. MY LIFE WAS PUT IN DANGER BECAUSE OF THIS SHODDY CONSTRUCTION BY BMW. WHEN I NOTIFIED THEM, THEY DENIED AND REFUSED TO PAY OR FIX. THEY LITERALLY PUT MY LIFE AS WELL AS OTHER DRIVERS LIFE IN DANGER,...

TL* THE CONTACT OWNS A 2006 BMW 525I. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE MICRO POWER MODULE NEEDED TO BE REPLACED. IN ADDITION, THE TECHNICIAN DISCOVERED THAT THE MICRO POWER MODULE WIRES WERE MELTED AND BURNED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 139,000.