2006 BMW 5 SERIES Electrical System Problems

NAVIGATION DISPLAY REBOOTS CONSTANTLY. WORKS PERIODICALLY. THIS DISPLAY GIVES ME ACCESS TO ALL OF THE CARS FEATURES INCLUDING WARNINGS AND MALFUNCTIONS WITH THE VEHICLE. IF THE DISPLAY WORKS WHEN THE CAR IS ON IT MAY NOT WORK IF YOU TURN OFF THE CARD AND TURN IT BACK ON.

HEAD LIGHTS ANGLE LIGHTS WIRES GETTING VERY DRY FROM THE HEAT OF THE LIGHT AND THE INSULATION COMING OFF THE OPTICAL WIRES, LIGHTS GO OUT, POSSIBLE SHORTING AND BECOME VERY UNSAFE.

STEERING WHEEL MALFUNCTION LOCKS PREVENTING THE VEHICLE TO START STEERING WHEEL LOCKS WHILE DRIVING

AIR CONDITIONING STOP WORK CAUSING MOTOR TO HEAT

A MESSAGE ON THE VEHICLE DISPLAY SCREEN INDICATED THAT THE RIGHT-SIDE LOW BEAM HEADLIGHT WAS MALFUNCTIONING. I REMOVED THE HEADLIGHT ASSEMBLY TO REPLACE THE BULB AND FOUND THE WIRING INSULATION IS CRUMBLING TO THE TOUCH, RESULTING IN A SHORT CIRCUIT. THE HEADLIGHT BULB IS NOT ACTUALLY BURNED OUT. THERE ARE MANY COMPLAINTS ABOUT THIS ON THE BMW FORUMS BUT BMW AND THE HEADLIGHT MANUFACTURER, HELLA, REFUSES TO ACKNOWLEDGE THE PROBLEM OR DO ANYTHING ABOUT IT. *TR

SINCE 2011, I HAVE NEEDED TO HAVE MY, 2006 BMW 530XI, VEHICLE SERVICED. SERVICED FOR TRUNK LEAKAGE, BATTERY CABLE REPLACEMENT, SUNROOF/MOONROOF NON-DRAINAGE ISSUES AND PASSENGER AIRBAG SENSOR ISSUES. I HAVE PAID PERHAPS THREE - TO FIVE THOUSAND DOLLARS FOR ALLEGED REPAIRS. NONE OF THOSE REPAIRS WERE PERMANENT AND THE ISSUES CONTINUED ON/OFF UNTIL 5/10/14. ON THAT DAY/DATE I DROVE THE CAR SEVERAL HOURS SHOPPING AND PREPARING FOR MOTHER'S DAY. WHEN I STOPPED THE ENGINE IN MY DRIVEWAY THE CAR SHUT OFF BUT I COULD NOT REMOVE THE KEY FOB FROM THE IGNITION. THERE WAS NO POWER THROUGHOUT THE VEHICLE, E.G. NO DASH LIGHTING, NO INTERNAL LIGHTING, NO ALARM LIGHT FLASHING AND NO ABILITY TO LOCK DOORS OR OPEN THE TRUNK. NEITHER BMW-N.A. NOR DEALERSHIP ACCEPT ANY RESPONSIBILITY FOR THE WATER LEAKAGE OR OTHER REPAIR ISSUES, EVEN THOUGH SOME MANUFACTURER RECALLS WERE ANNOUNCED TO THE PUBLIC FOR THESE ISSUES, THOSE WERE...

ONE DAY WHILE DRIVING, MY CAR HAD AN ALERT COME ON THE I DRIVE SAYING THE PASSENGER RESTRAINT SYSTEM WAS MALFUNCTIONING. IT STAYED ON A FEW MONTHS AND THEN WENT AWAY FOR A FEW MONTHS. NOW THE PROBLEM IS OCCURRING AGAIN. *TR

TL* THE CONTACT OWNS A 2006 BMW 5 SERIES. THE CONTACT STATED THAT THE BATTERY FAILED TWICE. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE BATTERY UNDER WARRANTY. THE FAILURE RECURRED WITHIN ONE MONTH. THE CONTACT REPLACED THE BATTERY AND DID NOT NOTIFY THE DEALER OR THE MANUFACTURER. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT 40,936.

ON FEB. 21, 2011 THE ELECTRICAL SYSTEM SHOWED A MASSIVE MALFUNCTION WARNING ON MY 2006 BMW 530XI. THE CAR COMPUTER INSTRUCTED ME TO DISCONTINUE DRIVING IMMEDIATELY AND BRING MY CAR TO THE CLOSEST DEALER. I BROUGHT THE CAR TO THE DEALER. IT WAS DETERMINED THE SUNROOF CASSETTE WAS FAULTY AND WATER FROM RECENT RAINS LEAKED THROUGH THE SUNROOF (IN CLOSED POSITION) RAN DOWN DRAIN LINES INTO MY BATTERY COMPARTMENT. WATER CAUSED MAJOR DAMAGE OF ELECTRICAL SYSTEM, MODULES, BATTERY ETC. BMW TOLD ME THE REPAIRS, INCLUDING A NEEDED SUNROOF CASSETTE WOULD TOTAL $23000.00. BMW ADMITTED THE SUNROOF CASSETTE WAS FAULTY, BUT SAID I WAS OUT OF WARRANTY AND IT WOULD BE MY RESPONSIBILITY TO REPAIR. I DID RESEARCH AND FOUND 3 INTERNAL SERVICE BULLETINS FROM BMW, SI B 61 13 06, SI B 54 02 08 AND SI B54 04 09 WHICH ADDRESSED THIS ISSUE WHILE MY CAR WAS UNDER WARRANTY-...

WHILE DRIVING IN HEAVY RAIN, THE VEHICLE'S ELECTRONIC CONTROL SYSTEM ISSUED A FRENZY OF ALERTS, AND INTERRUPTED FUNCTION OF SEVERAL SUBSYSTEMS INCLUDING THE WINDSHIELD WIPERS. THE SYSTEM ISSUED A MESSAGE "CONTINUED DRIVING NOT POSSIBLE" AND THEN FURTHER ALERTS. THE BMW CENTER EXAMINED THE CAR AND STATED THAT WATER HAD ENTERED THE CAR THROUGH THE SUNROOF DRAINAGE SYSTEM AND FLOODED THE COMPARTMENT HOUSING THE CONTROL SYSTEMS, CAUSING THE SUDDEN MALFUNCTION. DESPITE THE FACT THAT THERE IS NO MAINTENANCE PROTOCOL ESTABLISHED BY BMW FOR THE DRAINAGE SYSTEM, I HAD THE SUNROOF DRAINS CHECKED ON OCTOBER 2009 AND WAS ASSURED BY THE BMW CENTER THAT IT WAS WORKING TO SPECIFICATION AT THAT TIME. NEVERTHELESS, BMW'S CENTER ATTRIBUTED THE FAILURE TO THE DRAINAGE SYSTEM BEING PARTIALLY BLOCKED. (N.B. THE SYSTEM HAD NOT BEEN CHECKED FOR THE FIRST THREE YEARS OF USE, SO WHY WOULD IT FAIL 1 YEAR AND 1 MONTH AFTER INSPECTION?) THE...

TL* THE CONTACT OWNS A 2006 BMW M5. WHILE DRIVING BETWEEN 35-40 MPH THE VEHICLE CAUGHT ON FIRE. THE VEHICLE HAD A HISTORY OF ELECTRICAL PROBLEMS SINCE THE DAY OF PURCHASE. DURING THE FIRE, THE VEHICLE LOST THE ABILITY TO BRAKE. HE HAD TO USE THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. THE VEHICLE WAS COMPLETELY DESTROYED. HE SUFFERED MINOR BURNS ON HIS HANDS. THE FAILURE MILEAGE WAS 40,000.

THE PANORAMIC SUNROOF ON E60 BMW WAGONS HAS A FAULTY DESIGN OF THE DRAINS WHICH RE-DIRECTS WATER INTO THE REAR OF THE CAR (SPARE TIRE AREA) CAUSING MULTIPLE ELECTRICAL COMPONENTS TO FAIL WHILE DRIVING: LIGHTS, WINDSHIELD WIPERS, DOOR LOCKS, SPEEDOMETER, ETC. IN MY CASE, THE FAILURE OCCURRED TWICE IN A PERIOD OF 18 MONTHS. THE DEALER AND BMW NORTH AMERICA REPAIRED THE CAR AT OWNERS' EXPENSE ALTHOUGH AN EXTENDED WARRANTY WAS IN FORCE. THERE HAS BEEN A TECHNICAL SERVICE BULLETIN ISSUED BY BMW BUT THE DEALER DOES NOT ACKNOWLEDGE THE FLAW AND REFERS TO THE FAILURE BEING CAUSED BY 'ENVIRONMENTAL INFLUENCES'. *TR

THE SUNROOF DRAIN CLOGGED IN MY 2006 BMW 530XI STATION WAGON CAUSING WATER TO POOL IN THE CAR AND SHORT OUT THE ELECTRICAL SYSTEM WHILE I WAS DRIVING, WHICH RESULTED IN THE LOSS OF POWER TO THE DASHBOARD INCLUDING THE SPEEDOMETER. I HAD THE CAR TOWED TO THE DEALERSHIP AND THE TOW TRUCK DRIVER TOLD ME THAT THIS WAS THE SECOND 2006 BMW 530XI STATION WAGON HE HAD TOWED THAT DAY FOR THE VERY SAME PROBLEM, THE DEALERSHIP TELLS ME THAT IT'S A COMMON PROBLEM FOR THE SUNROOF DRAINS TO GET CLOGGED BY POLLEN AND PINE NEEDLES, WHICH SOUNDS LIKE A DESIGN FLAW TO ME. MY HUSBAND INSPECTED THE TRUNK WHERE THE WATER WAS POOLING, WHILE WE WAITED FOR THE TOW TRUCK, THERE WERE RELAY WIRES WHERE THE WATER WAS POOLING AND HEAT AND STEAM COMING FROM THE AREA SO MY HUSBAND DISCONNECTED THE WIRES, I'M FAIRLY SURE THAT IF...

TL*THE CONTACT OWNS A 2006 BMW 5 SERIES. AFTER STARTING THE VEHICLE ONE MORNING, ALL OF THE INSTRUMENT PANEL INDICATORS ILLUMINATED. THE DEALER STATED THAT THE VEHICLE NEEDED A NEW SZL MODULE, WHICH CONTROLLED MOST OF THE COMPUTER FUNCTIONS IN THE VEHICLE. THE DEALER DID NOT HAVE THE PART AVAILABLE, BUT ASSURED THE CONTACT THAT THE VEHICLE WAS SAFE TO DRIVE. THREE WEEKS AFTER THE INCIDENT, WHILE DRIVING 15 MPH, THE STEERING AND BRAKES FAILED. THE FAILURE LASTED LESS THAN A MINUTE, BUT DURING THIS TIME HE WAS UNABLE TO STOP OR STEER THE VEHICLE. HE CALLED THE DEALER AND TOOK THE VEHICLE IN FOR SERVICE. THEY KEPT THE VEHICLE FOR OVER A MONTH AND REPLACED THE SZL MODULE AND CLOCK SPRING, IN ADDITION TO AN ELECTRICAL REPAIR. WITHIN A MONTH, THE FAILURE RECURRED. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE AND RETURNED THE VEHICLE TO THE CONTACT. THE...

TL*THE CONTACT OWNS A 2006 BMW 525XI. WHILE DRIVING 60 MPH, THE LIGHTS ON THE DASHBOARD ILLUMINATED AND THE VEHICLE DECELERATED TO 10 MPH. THE VEHICLE WAS UNABLE TO DRIVE OVER 10 MPH. THE DEALER STATED THAT THERE WAS WATER ON THE PASSENGER FLOOR OF THE VEHICLE, WHICH DAMAGED ALL OF THE WIRING AND SENSORS. THE DEALER WAS UNABLE TO DETERMINE WHERE THE WATER ORIGINATED, BUT SUGGESTED THAT IT MAY HAVE ENTERED THROUGH AN OPEN WINDOW WHILE IT WAS RAINING. THE CURRENT AND FAILURE MILEAGES WERE 13,859.

I PURCHASED CAR IN MAY 2005 AND WITHIN 4 WEEKS MY CAR LIGHTS AND SIGNAL WOULD JUST FLASH OUT OF CONTROL. THE CAR WOULD THEN BEEP ALL THE TIME. THE DEALER SAID THEY DON'T KNOW WHY. THEN THE COMPUTER LOCKED MY CAR. AFTER WAITED ALMOST 2 HOURS FOR ROADSIDE THE DEALER CAME TO BRING ME TO A RENTAL CAR DEALERSHIP. THE CAR WAS TOWED AND THEN THE CAR WAS RE KEYED. THE COMPUTER WAS UPDATED AND ALL ELECTRONICALLY DEFECTS WORKED BETTER THEN DELIVERY. *JB

AFTER NUMEROUS SERVICES FOR ELECTRONICALLY DEFECTIVE PROBLEMS, MY CARS COMPUTER SHUT DOWN. JUST SHUT DOWN. SINCE THE COMPUTER CONTROLS ALL FUNCTION I WAS LEFT WITH NO CONTROL OVER MY CAR. I WAS LEFT WITH NO GPS, NO CLIMATE CONTROL, NO ENTERTAINMENT CONTROL, AND IN ORDER IN HAVE THE CAR SERVICES WITH A COMPLIMENTARY VEHICLE IT HAD TO MAKE WEEKS TO BE SERVICED. EVEN THOUGH I WAS SOLD ON THE FACT THAT THE COMPANY WILL BE PICK UP THE CAR, HOW YOU DO WAIT. THE CAR HAD TO BE SERVICED TWO TIMES AND BECAME A HUGE IN CONVINCE. *JB

COMPUTER LOCKED KEY, ALL LIGHTS INSIDE CAR AND OUTSIDE FLICKERED OUT OF CONTROL, THEN 2 WEEKS LATER BRAKE DID NOT ENGAGE WHILE TRYING TO STOP AND THE VEHICLE CRASHED INTO A POLE. *JB