2017 BMW 330I — Problems, Recalls & Safety Data

The cooling system is continually failing prematurely. Parts that should be lifetime are needing to be repaired below 100K miles. I have had to repair the following cooling system related items that should be under recall and are not Oil filter housing Thermostat housing Turbo coolant lines Water neck the cost of repairs is significant and BMW is denying responsibility for the premature failures.

The Oil Filter Housing (OFH), the Coolant/Water Pump, and other plastic lines for the cooling systems are well known to fail with this engine early in their lifetime. My service advisor at BMW said, "these are very common issues for a B46 engine.". The Motor Mounts also are extremely prone to failure due to the use of the Auto Start/Stop feature. This has also been noted by my service advisor at BMW. They commented, "these cars come in often before ever hitting 20k miles and needing replacement. I recommend never using the Auto Start/Stop feature ever again.'

The contact owns a 2017 BMW 330I. The contact stated that the rear driver’s side taillight cover loosened and detached but was able to be put back in place. Upon investigation, the contact discovered NHTSA Campaign Number: 19V074000 (Exterior Lighting); which the contact linked to the failure. The dealer was notified of the failure and the contact was informed that there were no recalls on the VIN related to the failure. The vehicle was not repaired. The dealer referred to the contact to the NHTSA Hotline to report the failure. The manufacturer was not notified of the failure. The failure mileage was unknown.

My BMW has had multiple repairs (3 incidents - 2 times repaired by BMW and 1 time repaired by a national mechanic garage) to the coolant system since I purchased it in 2018. BMW have verified the leaking coolant as well as the independent garage. Currently, the coolant system has another on going issue where it is still leaking and it's still unable to be fixed. This coolant issue has had catastrophic failures at times and more recently it has thrown a major engine overheating warning that has impacted the safety of my wife, kids and I as well as other individuals on the road as I have had to pull over quickly and turn the car off to allow the engine to cool down. I've had to drive the car at a reduce speed and acceleration which has frustrated many drivers causing them to over take me dangerously. Additionally, I've burnt my hand from opening the coolant expansion tank to add coolant on multiple occasions.

I noticed coolant leaking from under the vehicle. The message to add coolant was displayed. The vehicle was taken to an independent mechanic where the engine was inspected, and was notified of stains of coolant coming from the head gasket. The contact was informed that the head gasket needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. I believe this is failure is related to NHTSA Campaign Number: Recall 18V755000, October ,24 2018, My car has only 73000 Miles