2000 BMW 328CI — Problems, Recalls & Safety Data

TL* TAKATA RECALL. THE CONTACT OWNS A 2000 BMW 328CI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V853000 (AIR BAGS) AND 20V018000 (AIR BAGS) HOWEVER, THE PARTS TO DO THE RECALL REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2000 BMW 328CI. THE CONTACT STATED THAT THERE WAS A CRACK IN THE LOWER SUB PANEL OF THE VEHICLE. THE VEHICLE WAS TAKEN TO COMPETITION BMW OF SMITHTOWN (599 MIDDLE COUNTRY RD, ST JAMES, NY 11780, (888) 861-6280) WHERE A FAILURE IN THE REAR DRIVER SIDE FLOOR MOUNTS WAS DISCOVERED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 120,000. THE VIN WAS NOT AVAILABLE. *TT UPDATED 9/24/18*JB

PLEASE SEE ATTACHED PDF. DOCUMENT FOR A FULL EXPLANATION. THE SUB-FRAME ON MY BMW 3 SERIES (E46) HAS FRACTURED AND BECOME SEPARATED FROM THE CAR. THE DETACHED SUB-FRAME IS NOT CAUSED BY ANYTHING I DID, BUT IS THE RESULT OF AN INHERENT DEFECT INVOLVING THE VEHICLE'S SUB-FRAME, A MAJOR COMPONENT OF THE CAR'S STRUCTURAL SYSTEM THAT SUPPORTS THE POWERTRAIN AND IS WELDED TO THE CHASSIS. I WAS NOT AWARE OF THE DETACHED SUB-FRAME UNTIL I HEARD A METAL ON METAL SQUEAK IN THE REAR OF THE CAR; AS TIME WENT ON, THE DETACHED SUB-FRAME RIPPED THROUGH THE REAR TIN UNDERLAYMENT/SHIELD AND THE TWO ARE NOW RUBBING TOGETHER. THE DEFECTIVE SUB-FRAME IN THE BMW 3 SERIES E46 MODELS POSES A RISK TO MOTOR VEHICLE SAFETY, AS IT IS A 'CRITICAL VEHICLE COMPONENT' OF THE CAR. FURTHER, A QUICK INTERNET SEARCH WILL PROVE THAT THIS DEFECT IS HIGHLY PERSISTENT IN THE E46 BMW 3 SERIES. AND IN ACCORDANCE WITH U. S. CODES FOR MOTOR VEHICLE SAFETY, 'CRITICAL VEHICLE COMPONENTS THAT BREAK, FALL APART, OR SEPARATE FROM THE VEHICLE, CAUSING POTENTIAL LOSS OF VEHICLE CONTROL OR INJURY TO PERSONS INSIDE OR OUTSIDE THE VEHICLE,' A RECALL IS IN ORDER. PLEASE NOTE THAT I DON'T KNOW "WHEN DID THIS HAPPEN?". I JUST PUT THE DATE I HAD MY SUB-FRAME INSPECTED BY A CERTIFIED BMW DEALER (SEE ATTACHMENT FROM COLLISION CENTER OF ORLANDO). I HAD MY SUB-FRAME INSPECTED WHEN I HEARD A LOUD SQUEAKING NOISE. AS I UNDERSTAND IT, OWNERS WERE UN-AWARE THEIR SUB-FRAMES WERE DEFECTIVE; DISCOVERY WAS MADE BY A THOROUGH MECHANIC OR BY CHANCE. MY SUB-FRAME TORE THROUGH THE TIN UNDERLAYMENT/SHEILD, SO THE METAL RUBBING METAL IS WHAT WAS CAUSING THE SQUEAKING NOISE. AND AS I UNDERSTAND IT, THE SUB-FRAME TEARS THROUGH THE TIN UNDERLAYMENT ONLY AFTER BEING UNDETECTED FOR A LONG PERIOD OF TIME. THIS IS SO DANGEROUS NOT ONLY TO ME BUT OTHER DRIVERS. BMW NEEDS TO BE HELD RESPONSIBLE. A RECALL IS IN ORDER.

WHILE DRIVING DOWN THE ROAD, A LOUD METAL TO ROAD NOISE STARTED TO EMANATE FROM THE BOTTOM OF MY VEHICLE. AFTER PULLING OVER AND EXAMINING THE UNDERSIDE OF MY VEHICLE, I COULD SEE THE FUEL TANK STRAP ON THE RIGHT SIDE OF THE VEHICLE DRAGGING AGAINST THE GROUND AND THE FUEL TANK HANGING DOWN FROM ITS NORMAL POSITION. THE STRAP HAD SEPARATED FROM ITS FRONT RETENTION POINT. A THOROUGH INSPECTION REVEALED THAT THE FRONT MOUNTING BRACKET FOR THE FUEL TANK STRAP WAS NO LONGER ON THE VEHICLE. THE BRACKET HAD SEPARATED FROM THE VEHICLE. THIS BRACKET APPEARS TO BE SPOT WELDED TO THE FRAME. IN THIS CASE, METAL WAS MISSING FROM THE FRAME AT THE WELD POINTS AS IF THE WELDS WERE INTACT BUT THE METAL AROUND THE PERIMETER OF THE WELDS HAD YIELDED AND FAILED. THIS APPEARS TO BE A METAL FATIGUE ISSUE OF THE FRAME SURROUNDING THE WELD POINTS OF THE RIGHT SIDE, FUEL TANK STRAP, FRONT MOUNTING BRACKET. THIS VEHICLE HAS BEEN LOCATED IN PHOENIX SINCE NEW AND HAS NO SIGNS OF RUST OR OPERATION INDUCED DAMAGE TO THE FRAME OR STRUCTURE IN THIS AREA. *TR

2000-2006 BMW 3 SERIES. DEFECT ON FRONT PASSENGER AIR BAG. *TA THE CONSUMER STATED HE RECEIVED A SAFETY RECALL NOTICE, REGARDING THE AIR BAG, ON SEPTEMBER 23, 2014. HE STATED TOO MUCH TIME HAS GONE BY WITHOUT A REMEDY OR FURTHER INFORMATION. RECALL # 14V428000*JB