2004 BMW 325CI Electrical System Problems

HEADLIGHT WIRING INSULATION ON STANDARD BMW HEADLIGHTS IS BRITTLE AND FALLING OFF EXPOSING BARE COPPER WIRES WITHIN THE HEADLIGHT ASSEMBLY. IN ORDER TO PROTECT THE HEADLIGHTS I HAVE HAD TO WRAP THE WIRES IN ELECTRICAL TAPE AND SHRINK WRAPPING. THIS ISSUE HAS EXISTED FOR SEVERAL YEARS.

TL* THE CONTACT OWNS A 2004 BMW 325CI. THE CONTACT STATED THAT SHE NOTICED THERE WAS A LEAK FROM UNDER THE FRONT OF THE VEHICLE. THE CONTACT THEN ATTEMPTED TO START THE VEHICLE BUT TO NO AVAIL. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION WHERE THEY ADVISED HER THAT THE BATTERY FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 63,000.

DRIVER SIDE BRAKE LAMP HAS GONE OUT. IN RESEARCHING, FOUND THAT THIS IS A COMMON PROBLEM WITH THIS MODEL IN THE LED TAIL LIGHT AND CAN CAUSE A CRASH DUE TO OTHER DRIVERS NOT BEING ABLE TO TELL THAT YOU ARE STOPPING. FOUND RECALL INFORMATION ON NHTSA SITE AND CONTACTED BMW. I WAS INFORMED THAT MY SPECIFIC VIN WAS NOT INCLUDED IN THIS CAMPAIGN, YET THE PROBLEM IS THE SAME PROBLEM THAT AFFECTS 241,000 OTHER CARS. I WOULD LIKE TO ASK THAT MY SITUATION (AND VIN) BE EVALUATED AND INCLUDED IN THE RECALL SINCE THIS IS A KNOWN ISSUE WITH THIS MODEL. THANK YOU FOR YOUR ASSISTANCE! *TR

AT AROUND 20K MILES, THE SMG (SEQUENTIAL MANUAL GEARBOX W/ PADDLE SHIFTERS) ON MY '04 325CI BEGAN EXPERIENCING MANY OF THE SAME PROBLEMS THAT I'VE READ ABOUT REGARDING THE AUTOMATIC TRANSMISSION. AFTER A COLD NIGHT, THE SMG WOULD NOT SHIFT INTO REVERSE OR DRIVE. IT WOULD KEEP "CLUNKING" OVER AND OVER, CONTINUALLY LOUDER, UNTIL I SHIFTED BACK INTO NEUTRAL. I HAD THE CAR TOWED TO BMW, WHERE THEY HAD TO REPLACE THE TRANNY. AT 83K MILES, I'M STARTING TO NOTICE SOME OF THE SAME PROBLEMS AGAIN. ADDITIONALLY, WITH BOTH TRANNYS, THE CAR DELAYS ITS ACCELERATION FOR ABOUT A SECOND OR TWO WHEN STARTING FROM A STOP. THIS HAS ALWAYS BEEN A PROBLEM. ON TOP OF THAT, MY ALTERNATOR JUST WENT OUT AFTER A COLD NIGHT. IN MY OPINION, BMW'S (AT LEAST MINE) DO NOT LIKE THE COLD! *TR