2002 AUDI A4 Electrical Systemwiring Problems

DRIVERS DOOR SPEAKERS WORKING RANDOMLY AND CUTTING OUT ALL TOGETHER AT TIMES, SOMETIMES WITH STATIC PRIOR TO CUTTING OUT. SO FAR THE SPEAKERS HAVE BEEN REPLACED ON OCT 2 2004,NOV 2 2004, NOV 15, 2004,DEC 7 2004. THE CAR STILL HAS THE SAME ISSUE AND THE DEALER DOES NOT SEEM TO BE ABLE TO FIND OR FIX THE PROBLEM. I HAVE LOOKED AT IT AND IN 2 SECONDS I FOUND THE ISSUE. IT IS A BROKEN WIRE IN THE DOOR PASS THROUGH. THE DEALER TELLS ME IT'S NOT A BROKEN WIRE BECAUSE THEY TESTED ALL THE WIRES AND THEY CHECKED OUT OK. IF THE SPEAKER IS NOT WORKING OR CUTTING OUT WITH THE DOOR OPEN AND YOU MOVED THE RUBBER PASS THROUGH, THE SPEAKER COMES BACK ON AND WORKS FOR A SHORT TIME AGAIN. DEALER HAS PERFORMED THE RECALL FOR THIS ON NOV 2 2004 BUT THERE IS STILL AN...

HOMELINK SYSTEM STOPS WORKING. DEALER REPROGRAMS THE SYSTEM (WHICH I HAD ALREADY DONE 5X), AND IT STILL DOESN'T WORK. THE VISOR WITH CONTROL BUTTONS IS ORDERED & REPLACED. THE HOMELINK STARTS WORKING AGAIN. 7/2002--HOMELINK STARTS ACTING UP AGAIN--IT IS WORKING INTERMITTENTLY. 8/2002--HOMELINK TRANSCEIVER IS REPLACED AND IT STARTS WORKING AGAIN. LATER THAT MONTH, IT BEGINS WORKING INTERMITTENTLY AGAIN. 9/2002--DEALER FINALLY INVESTIGATES FURTHER, AND FINDS CORROSION IN THE WIRING HARNESS/CONNECTORS. THAT SOUNDS VERY STRANGE TO ME. WHAT WAS THE CAR EXPOSED TO DURING PRODUCTION TO CAUSE THAT? WHAT ELSE IS GOING TO FAIL/GIVE US PROBLEMS AS A RESULT? *NLM

IGNITION COIL FAILED ON HIGHWAY. CAR "SHOOK" VIOLENTLY UNTIL STOPPED IN PARKING LOT. ONCE CAR WAS OFF THE ROAD, THE COIL HOUSING CAUGHT FIRE. THE FIRE ULTIMATELY BURNED ITSELF OUT, AND THE CAR WAS TOWED TO THE LOCAL DEALERSHIP FOR REPAIR. THE DEALERSHIP NOTIFIED AUDI USA OF THE DEFECT AND RECOMMENDED VEHICLE REPLACEMENT. AUDI USA ELECTED TO REPAIR CAR UNDER WARRANTY. MULTIPLE FAILURES HAVE OCCURRED SINCE (SEE LIST). TS

THE CONSUMER HAS EXPERIENCED THE FOLLOWING PROBLEMS: THE DRIVER SEAT MOTOR IS INOP/LUMBAR MOTOR/ROCKS BACK/FORTH, THE LEFT HEADLIGHT(MOISTURE COLLECTION IN THE INSIDE DUE TO WEATHER/CAR WASH), THE AIRBAG CONTROL UNIT DEFECTIVE, THE SEAT AIR BAG TORN, THE STRAP ON DRIVER SEAT BELT DOES NOT LOWER/STUCK, WIRES WERE FOUND DAMAGED UNDER THE CARPET, AND THE VEHICLE HAS SHIFTING PROBLEMS/NOT SHIFTING EASILY-FAILED. THE CONSUMER ALSO REQUEST FOR THE DEALER TO BUY BACK THE VEHICLE AND OR COMPENSATE THE CONSUMER FOR THE TIME WITHOUT THE VEHICLE. SCC